Professional Documents
Culture Documents
1.An aircraft shall not fly unless it is so equipped as to comply with the law
of the country which it was registered, this statement
is stated in?
-MCAR. t/b pg 5
2.Lap straps must be provided for
-passenger seats. t/b pg 6
3.Child restraint device must be provided for
-any child under the age of 2. t/b pg 6
4.Slides or rope must be provided as a mean of escape from cabin if
-the sill of any passenger door is more than 1.82meter from the ground.
t/b pg 6
5.A life jacket must have a
-whistle and waterproof torch. t/b pg 8
6.Life jacket is a lifed item, typically?
-6 years. t/b pg 8
7.Life jacket's inspections and tests are carried out i.a.w?
-manufacture's instructions.(6/12/18 monthly interval) t/b pg 9
8.life jackets water operated battery's insulation test should give a
-minimum reading of 5megaohms. t/b pg10
9.Any marking on life jackets may be marked only by?
-white chalk. t/b pg 10
10.Smoke hoods are only provided for?
-crew member. t/b pg 10
11.Megaphone is required on aircraft
-where there are more than 19 passengers. t/b pg 11
12.What type of hand held fire extinguishers are usually fitted in the cabin?
-BCF, WATER .t/b pg 11
13.Whenever a hanheld fire extinguishers bottle is being moved for maintenance p
urposes, it should be fitted with?
-transit pin. t/b pg 12
14.How does a slide rafts being deployed?
-a slide raft will inflates automatically when the doors are opened in t
he armed emergency mode. t/b pg 13
15.During slide tube's inflation, compressed gas passes into the slide tube via?
-air aspirator.
note:to draws in extra air from the atmosphere. t/b pg 15
16.The proper method to store slides are
-stored in deflated conditions with transit plug fitted, lightly dust wi
th french chalk, in a temperature between
15-21 degree celcious, dry atmosphere, out of sunlight.
note:do not store more than 3 on top of each other. t/b pg 22
17.Stored slide should be inspected
/b pg 127
65.The distribution line for water distribution system are usually
-flexible hose enclosed in an aluminium sheath. t/b pg 128
66.Water service panel will normally be found on the?
-lower part of the fuselage. t /b pg 130
67.In a water service panel, it contains?
-a filling point, a drain/overflow point, a quantity indication and an e
xternal air connection. t/b pg 130
68.The passenger water system may be disinfected using a?
-concentrated solution of chlorine and vinegar. t/b pg 135
69.The 3 main types of toilet fitted to aircraft are?
-removable toilet assembly, liquid flush type, vacuum toilet assembly.t/
b 138
70.The advantages of vacuum toilet are
-no corrosion risk, rapid action to drain each individual toilet. t/b pg
143
71.Vacuum toilets obtains negative pressure by?
-having waste tank connected to outside of the aircraft. t/b pg 143
note:at low speed , a small vacuum pump is operated by pressure switch t
o provide the require pressure differential.
72.Toilet waste tank emptying can be done by using?
-gravity or suction method. t/b 144
73.What must be installed in the galley areas, entry ways and under lavatories t
o prevent flood structural damage from corrosice fluid
spills?
-liquid barrier. t/b pg 148
74.Gutters are usually incorporated in the flooring around the edge of toilet an
d galley partitions to?
-drain away fluid spillages. t/b pg 148