Professional Documents
Culture Documents
Disassembly Procedures
Revision 1.0
June 2004
Table of Contents
Required Tools .......................................................................................................1
Removing the Case Parts:........................................................................................2
Access Door Removal .............................................................................................3
Input Tray Extension Removal..................................................................................4
Removing the Carriage Mechanism .........................................................................5
Removing the Paper Pick Assembly..........................................................................6
Removing the Capping Station ................................................................................7
Removing the Paper Motor Assembly.......................................................................8
Removing the Logic PCA.........................................................................................9
Required Tools
1. Small Screw Driver.
2. Needle Nose Pliers.
3. T-10 Torx screwdriver.
4. Lubricant, 6040-1322, when necessary.
1 of 9
Remove the 4 T-10 screws, which are holding the Top Case to the Base.
Lift the Top Case Assembly from the unit.
Lift the out-tray from the printer
Remove the cleanout assembly by pressing the tab towards the center of the
printer and pull out the rear access door from the printer.
1
1
2 of 9
With the access door halfway open, pull the access door from the two hinges.
3 of 9
Remove the Input Extension from the Out-tray by pressing inwards at the
center until the extension tab snaps out from the in-tray.
Lift up to remove Extension from Out-tray assembly.
4 of 9
1
1
5 of 9
6 of 9
7 of 9
8 of 9
9 of 9