Professional Documents
Culture Documents
INTRODUCTION
Geocomposite is a production of
the combination of at least one of the
geosynthetic material with other
component.
Usually
geocomposite
consist of a three dimensional polymer
core acted as a medium for the flow of
the liquid. The core polymer is covered
by a layer of geotextile or geomembrane.
The layer of geotextile or geomembrane
allow the flow of the liquid and block
the surrounding fill from passing
through it which will clog the polymer
core. The cover material will protect the
core material and lengthen the
serviceability of the geocomposite. Due
to its ability to direct the flow of the
liquid, geocomposite is normally
designed for the use of drainage. The
geocomposite drainage is differentiate
by the type of core in it. Different core
will provide different ability and usage
to the geocomposite. Geocomposite
drainage can be classified into two basic
type which are sheet drainage and strip
drainage. Different ability of the
geocomposite can be obtained by
changing the cover material. The
geocomposite can be waterproof in one
face and protect the structure behind.
Figure 1 (Terram 2016) shows the
example of the geocomosite sheet
drainage.
Usage
Waste Management
Geocomposite drainage system
has been introduced as a barrier of the
waste to the surrounding. The
geocomposite that been used is formed
by a layer of the polymer covered by the
geomembrane or geotextile. It will help
to collect and drain any rainwater away.
This will help to prevent the overlying
soils destabilizing through saturation .
Besides that, it could also prevent the
groundwater been polluted by the
leachate. The geocomposite layer will
direct the flow of the leachate away to a
control area and prevent the contact with
the soil layer below. On the other hand,
the volume for the waste landfill will be
increased. The thick stone drainage layer
will be replaced by thin geocomposite.
The cost of installation of the traditional
stone layer will be much expensive than
the using the geocomposite layer.
Protect Buried Structure
Geocomposite has been used in
waterproof layer of many structure
which contact with the soil. The
geocomposite can prevent the water
from seepage into the concrete structure.
The polymer core in the geocomposite
will drain the water away to the
perforated pipe prepared. From example,
References
1. Terram 2016, Geocomposite,
Terram, Maldon, booklet.
2. Wick Drains, 2014, Wick Drians,
LAYFIELD CONSTRUCTION
PRODUCTS, viewed 22 April 2016,
<https://www.layfieldgroup.com/Ge
osynthetics/DrainageProducts/Wick-Drains.aspx>
3. H. Orzeszyna, D. Garlikowski, and
A. Pawlowski, 2006, Using
geocomposite with superabsorbent
synthetic polymer as water retention
element in vegetative layers,
INTERNATION Agrophysics, vol.20,
pp. 201-206.