You are on page 1of 30

Job Title : SADARA Isocyanates Plant

Job No. : 110496

SADARA Chemical Company

1093

Owner : DOW and Saudi Aramco

Doc No. : A554-252-KHE-325-1032-008

P/O No. : 110496-13-252-301-A01

Item No. : ALL ITEM

PO Description :

INSTRUMENT DATA SHEET


Please fill up the data in the format attached...

Job No. 110496


A
- APPROVED WITHOUT COMMENTS
AWC - APPROVED WITH COMMENTS
R
- REJECTED
NA
- NOT APPLICABLE
SIGNED BY :
DATE:2/13/2013
DAELIM PERMISSION TO PROCEED OR REVIEW
TAKEN ON VENDOR PRINTS SHALL NOT
RELIEVE VENDOR FROM ITS RESPONSIBILITIES
OR LIABILITIES UNDER THE PURCHASE ORDER.

All instruments shall be procured only from SADARA approved vendor list

FOR APPROVAL

Total

30

Pages

2013.01.17

Issued For Approval

B.H.KIM J.G.PARK S.R.SHIN

J.O.YOO

2012.08.09

Issued For Approval

B.H.KIM J.G.PARK J.S.PARK

J.G.YI

Rev.

Date

Description

Prepared Reviewed Approved

Approved

2 OF 30

INSTRUMENT LIST
PROJECT : SADARA Isocyantes PJT
NAME
SN

Q'TY

MAKER

VIBRATION TRANSMITTER

10

BENTLY NEVADA

ACTUATOR W/ EP POSITIONER AND AFR

FISHER

-END-

REMARKS

FOR AUTO-LOUVER

3 OF 30

1. VIBRATION TRANSMITTER

4 OF 30

TAG NO FOR VIBRATION TRANSMITTER

PJT. : SADARA Isocyanates PJT


ITEM NO.

VIBRATION TRANSMITTER

Q'TY

TAG NO.
E-5114/E-5115

E-5203

E-5221/E-5603
E-5801
E-6005/E-6302
E-6803

VT-5105-62

VT-5105-63

VT-5202-38

VT-5202-45

VT-5207-37

VT-5207-38

VT-5805-31

VT-6005-01

VT-6005-02

VT-6803-09

Total

10

1 OF 1

REMARKS

5 OF 30

DATA SHEET

VIBRATION PROBE

Customer

DAELIM / ARAMCO + DOW

Project

SADARA Isocyanates Plant

SERVICE

DESCRIPTION

Tag Number

SEE ATTACHED TAG NO. LIST

Quantity

10 SETS

Service

AIR COOLED HEAT EXCHANGER

Manufacturer

BENTLY Nevada Model PC420VP-10-B3041 from Wilcoxon Research (MEGGiT)

Transmitters

177230-02

will be a better selection due to the lower rotational speed a sensor


with a Lower frequency is required.

Electrical
6

Sensitivity

Frequency Response

10 Hz to 1 kHz(600 cpm to 60 kcpm)10%

Output Format,
Ref : Pin A to Pin B

4 to 20 mA(Current loop), velocity vibration

Excitation Voltage

12 to 30 Vdc (current limited to 40 mA)

10 Setting Time

S
P
E
C
I
F
I
C
A
T
I
O
N

0.0 to 25.4 mm/s(0 to 1.0 in/s)10%, Broadband R.M.S

< 15 seconds (within 2% of final value)

11 Connector Wiring Convention

Pin A : 4 - 20 mA Positive Loop


Pin B : 4 - 20 mA Negative Loop and common for Dynamic Signal
Pin C : Dynamic Signal (in voltage, un-buffered)

12 Mounted Resonant Frequency

Greater than 12 kHz

13 Full Scale Range

196 m/s2 (20 gs) pk


420 mm/s (16.5 in/s)pk

14 Velocity Range
15 Transverse Sensitivity

Less than 5% of sensitivity

16 Sensing Element Type

Ceramic / Shear

Environmental Limits
18 Operating Temperature

- 40 to + 85 (- 40 F to + 185 F)

19 Electrical Isolation

> 108 ohms

20 Shock Survivability

9,810 m/s2 (1,000 g peak), maximum

21 Humidity Limit
22 Magnetic Field Sensitivity

To 100 % non-submerged
< 20 m/s/gauss(< 790 in/s/gauss) peak

Mechanical
23 Weight
24 Mounting Hole in Body
25 Height
26 Mounting Torque
27 Mounting Hardware Option
ORDERING
28 Connector
INFORMATION
29 Agency Approval Option

REMARK

131 grams(4.6 oz), typical


1/4-28 UNF
66.0 mm (2.6 in)
4 to 7 N-m (35.4 to 62.0 in-lbf)
Stud 3/8-in 24 to 3/8-in 24
3-pin MIL-C-5015, stainless steel
Ex nL, IIC T4

6 OF 30

Seismic Transmitter
Bently Nevada* Asset Condition Monitoring
Description
The 177230 Seismic Transmitter combines a reliable basic protection solution
with the support and service of GE products. The transducer is a simple, looppowered device whose ease of installation and maintenance may reduce
training and service costs. When integrated into the PLC or controls system of an
overall plant asset condition monitoring solution, the transducer will help you
better manage downtime, optimize maintenance planning, and avoid
unforeseen catastrophic failures of machinery assets.
Features of the 177230 Seismic Transducer include:

Ease of implementation and use


- Interfaces with PLCs and control systems (like DCS and
SCADA)
- Provides a quick learning curve for operations and
maintenance through a familiar interface similar to that
for connecting other PLC or control system inputs
- Requires no field configuration or adjustments
- Needs few additional parts for a complete system
- Includes technical support for customers on how to
monitor their equipment
- Includes self-test
- Incorporates protected interface
- Supports a variety of interface cables
Data Quality
- Provides accurate and repeatable data
- Uses simple data format
- Provides raw vibration signal for verification and analysis
EHS Compliant
- Implements safe and ergonomic design
- Supports access to hazardous areas
Incorporates robust CM design for reliability
Implements Industry standard 4 to 20mA loop-powered
transmitter

Specifications and Ordering Information


Part Number 177232-01
Rev. D (09/09)
Page 1 of 6

7 OF 30

Sensitivity
Dynamic Signal
(Signal Two)

Specifications
Electrical

10.2 mV/m/s2 (100 mV/g) 5%

Sensitivity
Main loop
(Signal One)
0.0 to 25.4 mm/s (0 to 1.0 in/s)
10%, broadband rms (root
mean square)

Output Format,
Pin C
Referenced to
Pin B
Voltage, Acceleration vibration

[4 mA equals 0.0 mm/s and


20 mA equals 25.4 mm/s]
Output Format,
Pin A
Referenced to
Pin B

Note: The Dynamic Signal Negative (Pin B)


requires isolation from any grounding. If
this terminal is grounded, the 4-20 mA
loop will short, resulting in no output.

Frequency
Response
4 to 20 mA current loop Velocity
vibration

Excitation
Voltage

2.5 Hz to 10 kHz (150 cpm to 600


kcpm) 10%
Linearity

12 to 30 Vdc (current limited to 40


mA)
Note: This product is for use with PLCs,
DCS and SCADA systems that have

1%
Output Bias
Referenced to
Pin B
2.5 V 0.1 V

internal power supply that are typically


current limited in the range of 30 mA to 35
mA.

Full Scale Range


196m/s2 (20 gs) peak

Settling Time
Less than 15 seconds within 2%
of final value

Velocity Range
420 mm/s (16.5 in/s) peak
Mounted
Resonant
Frequency

Connector
Wiring
Convention

Greater than 12 kHz

Pin A:

4-20 mA Positive Loop

Pin B:

4-20 mA Negative Loop


and common for
Dynamic Signal

Transverse
Sensitivity

Dynamic Signal in
voltage, unbuffered

Sensing
Element Type

Pin C:
Frequency
Response

Less than 5% of sensitivity

Ceramic / Shear
10 Hz to 1 kHz (600 cpm to 60
kcpm) 10%

Specifications and Ordering Information


Part Number 177232-01
Rev. D (09/09)
Page 2 of 6

8 OF 30

Environmental Limits

Physical

Operating
Temperature
Range

Weight
131 g (4.62 oz), typical
-40 C to +85 C
(-40 F to +185 F)

Diameter
25.4 mm (1.00 in)
Height

Electrical
Isolation

66.0 mm (2.60 in)


Greater than 108 ohms

Isolation
Breakdown
Voltage

Case Material
304L stainless steel
Connector

600 Vrms with less then 1 mA


leakage current
Shock
Survivability

3-pin MIL-C-5015, stainless steel


Mounting Hole
in Body
1/4-28 UNF

9.810 m/s2 (1.000 g peak),


maximum drop test

Mounting
Threads

Note: This part typically mounts directly to

3/8-24 UNF

the machine via a stub. Customers can


use this device with a mag-base, but must

-18 NPT

take care not to snap the unit onto the

-28 UNF

machine. This snapping action can create


a very large spike signal that can damage
the electronics. Rolling the mag-base onto

Mounting
Torque

the machine greatly reduces the spike


signal so that the unit should not have any
issues.

Sensor Seal
Hermetically sealed
Relative
Humidity of
Transmitter

4 to 7 N-m (35.4 to 62.0 in-lbf)


Connector
Wiring
Convention
Pin A:

4-20 mA Loop Power


(Positive with reference
to Pin B)

Pin B:

4-20 mA Loop Return


(Negative/ return for
Dynamic Signal)

Pin C:

Dynamic Signal
(Unbuffered, referenced
to Pin B)

To 100% non-submerged
Magnetic Field
Sensitivity
Less than 20 m/s/gauss (790
in/s/gauss) peak
Less than 14.7 mm/s2/gauss (150
g/gauss) peak
[base on 50 gauss, 50 - 60 Hz]

Specifications and Ordering Information


Part Number 177232-01
Rev. D (09/09)
Page 3 of 6

9 OF 30

CE Mark Directives
EMC Directives
89/336/EEC
(with
amendments)

CE Product
Safety
IEC/EN 61010-1

Approvals
Declaration of Conformity
available online http://www.geenergy.com/prod_serv/products/
oc/en/hazardous_areas_certificat
ions.htm

Operating Ambient Temperature


-40 C Ta +80 C (-40 F Ta
+176 F)

IEC/EN61326

ExnL, AExnA IIC T4

Radiated
Emissions

Exia, Aexia IIC T4

CISPR 11 Criteria B
ESD Immunity

Ex nL IIC T4
EN 61000-4-2 Criteria B

Ui 28V, Ii 120 mA, Pi 1W,


Ci 0, Li 121.06 H

Radiated
Immunity

Ex ia IIC T4

EN 61000-4-3 Criteria B

Ui 28V, Ii 120 mA, Pi 1W,


Ci 0, Li 121.06 H

Fast Transient
Immunity
EN 61000-4-4 Criteria B

Ordering Information

Surge Immunity
EN 61000-4-5 Criteria A
Conducted
Immunity
EN 61000-4-6 Criteria A
Magnetic
Immunity
EN 61010-1 Criteria A

We can provide private labels for the Seismic


Transmitter for customers who require one. Contact
your local service representative for further
information.
For standard orders use the number provided below.
Product Description
Seismic Transmitter

Safety

177230-02

Explosive
Atmosphere
General

Product Description
Interconnect Cable without Armor
EN50014

16925-AA
Option A description

Explosive
Atmosphere
Intrinsic Safety

A:
EN50020

Length in feet
Order in increments of 1 foot (0.3 m)
Minimum length: 12 feet (3.7 m)
Maximum length: 99 feet (30.2m)
Example:
2 5 = 25 feet
Specifications and Ordering Information
Part Number 177232-01
Rev. D (09/09)
Page 4 of 6

10 OF 30

Product Description
Interconnect Cable with Armor

www.thermaxcdt.com

16710-AA

P/N: 18-TE-1930 (3) SXE

Option A description

22 AWG -

A:

P/N: 22-TE-1934 (3) SXE

18 AWG -

Length in feet
Order in increments of 1 foot (0.3 m)
Minimum length: 12 Feet (3.7 m)
Maximum length: 99 Feet (30.2m)
Example:
1 8 = 18 feet

Standard Wire and Cable Co.


www.std-wire.com
18 AWG P/N: 1100-88T

Accessories
The parts listed below are possible vendor sources for the
supporting hardware. You can use this information as a
reference and select the vendor that you wish to use.

22 AWG P/N: 1100-66T


Belden

3-Pin Connector (MIL-C-5015):

www.belden.com

Base

18 AWG -

Cannon (ITT industries):

P/N: 83336

www.ittcannon.com
P/N: CA3106R-10SL-3S F97 or
P/N: MS3106R-10SL-3S

22 AWG -P/N: 83334


Studs and Adapters:
89139-01

M-M -28 UNF to 3/8-24 UNF


Standard Stud

128038-01

M-M -28 UNF to 3/8-24 Hex


Plate Stud (1-3/8 X 0.25)

www.sunbankcorp.com

146396-01

F-M -18 NPT to -28 Adapter

Glenair, Inc.

37439-01

F-M -28 UNF to -28 UNF


Mounting Base

164373

M-M -28 UNF to -28 UNF


Standard Stud with Brass Tip

Shell
Sunbank Co.

www.glenair.com
Contact a vendor with above part
number and ask for their part that
fits your application
Wire (3-wire with shield)
3-conductor 18 to 22 AWG cables
with a 0.01 minimum outer
jacket and inner wire insulation,
and 80% minimum coverage
shield. Insulation rating should be
600 V minimum.
Mil-W-16878/4 (Type E):
Sonic/Thermax

Specifications and Ordering Information


Part Number 177232-01
Rev. D (09/09)
Page 5 of 6

11 OF 30

Graphs and Figures


Note: All dimensions shown are in millimetres (inches) except as noted.

A.

Positive loop (4-20 mA)

B.

Negative loop (4-20 mA) and common for dynamic signal

C.

Dynamic signal

D.

3-pin MIL-C-5015, 5/8-24 UNEF-2A

E.

66.0 mm (2.60 in)

F.

1.27 mm (0.050 in)

G.

25.4 mm (1.00 in)

H.

1/4-28 UNF-2B (English)

I.

25.1 mm (0.990 in)

Figure 1: Transducer Mechanical Outline and Dimensions


Dimensions shown in mm (inches) except as noted
* denotes trademarks of Bently Nevada, LLC, a wholly owned subsidiary of General Electric Company.
2007 2009 Bently Nevada LLC. All rights reserved.
1631 Bently Parkway South, Minden, Nevada USA 89423
Phone: 775.782.3611
Fax: 775.215.2873
www.ge-energy.com/bently
Specifications and Ordering Information
Part Number 177232-01
Rev. D (09/09)
Page 6 of 6

12 OF 30

2. ACTUATOR W/ POSITIONER AND AFR

13 OF 30

Louver
Actuator with E/P Positioner

Customer: DAELIM/ARAMCO + DOW


Reference:
Inq. No. :
Order No. :

656 Diaphragm Actuator - DVC6200f


Quantity
-. 2 EA
Application
-. For Louver
Tag
-. Refer to Tag List
Serial No.
-.
Type
-. 656 Diaphragm Actuator
General for 656 Actuator
Size
-. 40 / (630 POUND)
Input Pressure
-. 1.4 ~ 2.4 Kg/Cm2G
Action
-. Direct / Reverse
Mounting
-. Std
Accessories
-. None
Max Travel
-. Size 40 - 3.5 In
Diaphragm Material
-. Nitril Elastomer
Dia. Plate & Yoke Mat'l -. Cast Iron
Casting & Spring Mat'l -. Steel
Peumatic Connec.
-. 1/4 Inch NPT
Name Plate Mat'l
-. SST
Operating Temp.
-. -40 to 80 Degree C
Painting
-. Maker STD
DVC6200f
Input Signal
-. Foundation Field Bus (FISCO)
Output Pressure
-. 6 ~ 140 Psig
Supply Pressure
-. Max. 145 Psig
Material(Housing)
-. Low Cooper Aluminum alloy
Action
-. Direct
Explosionproof is not required. Provide
Mounting
-. Assembled on 656 Actuator
FM or CSA nonincendive (Aex n) certification
Accessories
-. Air Set (Fisher 67CFR)
Hazardous Area
-. CSA- and FISCO, Explosion-proof, Division 2, Dust Ignition-proof
1
Electrical Housing
-. CSA Type 4x, IP66
Model No.
-. DVC6200f / FC
Weight
-. 3.5Kg
Electrical Connec.
-. 1/2" NPT
Pneumatic Connec.
-. 1/4" NPT
Name Plate Mat'l
-. SST
Operating Temp.
-. -40 to 80 Degree C Operating
Notes
Details are shown as Catalog
1
Catalog information for the actuator is missing.

Special Requirements

#####

14 OF 30

Product Bulletin

DVC6200f Digital Valve Controller

62.1:DVC6200f FD
June 2012

D103422X012

Fisher FIELDVUE DVC6200f Digital Valve


Controller
The FIELDVUE DVC6200f digital valve controller is a
FOUNDATION fieldbus communicating instrument that
converts a digital control signal into a pneumatic output
to an actuator. It can easily be retrofitted in place of
existing analog positioners on most Fisher and nonFisher
pneumatic actuators.

Features

How does the actuator mount to the louver? is a special bracket required?
Please describe the detailed mounting procedure also

Does this actuator have enough strength to move


the louvers against the air flow of the fans?

Reliability
Linkage-Less NonContact Position Feedback The
high performance, linkage-less feedback system
eliminates physical contact between the valve stem
and the DVC6200f. There are no wearing parts so
cycle life is maximized.
Built to SurviveThe field proven DVC6200f
instrument has fully encapsulated electronics that
resist the effects of vibration, temperature, and
corrosive atmospheres. A weather-tight wiring
terminal box isolates field wiring connections from
other areas of the instrument.

Performance
Accurate and Responsive The two-stage positioner
design provides quick response to large step changes
and precise control for small setpoint changes.

Ease of Use
Enhanced Safety The DVC6200f is a FOUNDATION
fieldbus communicating device, so information can be
accessed anywhere along the loop. This flexibility can
reduce exposure to hazardous environments and
make it easier to evaluate valves in hard to reach
locations.
Faster Commissioning FOUNDATION fieldbus
communications allows you to quickly commission
loops with a variety of tools, either locally at the valve
assembly or remotely.

www.Fisher.com

W9616_fieldbus

LINKAGE-LESS
FEEDBACK SYSTEM

Easy Maintenance The DVC6200f digital valve


controller is modular in design. Critical working
components can be replaced without removing field
wiring or pneumatic tubing.

Value
Hardware Savings When installed in an integrated
control system, significant hardware and installation
cost savings can be achieved. Valve accessories such
as limit switches and position transmitters can be
eliminated because this information is available as
function blocks.
Increased Uptime The self-diagnostic capability of
the DVC6200f provides valve performance and health
evaluation without shutting down the process or
pulling the valve assembly from the line.
Improved Maintenance Decisions Digital
communication provides easy access to the condition
of the valve. Sound process and asset management
decisions can be made by analysis of valve information
through Fisher ValveLink software.

15 OF 30

Product Bulletin
62.1:DVC6200f FD
June 2012

DVC6200f Digital Valve Controller


D103422X012

Figure 1. Status Monitor

ALERT
INDICATED
BY RED BAR

Valve Diagnostics

nHigh cycle due to dither or improper tuning

The DVC6200f digital valve controller provides a


comprehensive library of valve diagnostic alerts. These
alerts are easily accessed with the 475 Field
Communicator. When installed as part of a FOUNDATION
fieldbus communicating system, the DVC6200f delivers
prompt notification of current or potential equipment
issues directly to the asset management system.

nTotal travel movement has accumulated beyond a

Alerts assist in identification and notification of the


following situations:
nValve travel deviation due to excessive valve friction

or galling (see figure 1)

specified point resulting in packing wear


nValve travel is above or below a specified point

nVarious instrument mechanical and electrical issues

For additional information on FIELDVUE diagnostics and


ValveLink software refer to Fisher bulletin 62.1:ValveLink
(D102227X012).

16 OF 30

Product Bulletin

DVC6200f Digital Valve Controller

62.1:DVC6200f FD
June 2012

D103422X012

Specifications
Supply Medium

Available Mounting
J Integral mounting to the Fisher GX Control

Air or Natural Gas

Valve and Actuator System


J Integral mounting to Fisher rotary actuators,
J Slidingstem linear applications
J Quarterturn rotary applications

Air: Supply pressure must be clean, dry air that meets


the requirements of ISA Standard 7.0.01. A maximum
40 micrometer particle size in the air system is
acceptable. Further filtration down to 5 micrometer
particle size is recommended.

DVC6200f digital valve controllers can also be mounted


on other actuators that comply with IEC 6053461,
IEC 6053462, VDI/VDE 3845 and NAMUR mounting
standards

Natural Gas: Natural gas must be clean, dry, oilfree, and


noncorrosive. H2S content should not exceed 20 ppm.
Output Signal

Function Block Suites

Pneumatic signal, up to 95% of supply pressure


Minimum Span: 0.4 bar (6 psig)
Maximum Span: 9.5 bar (140 psig)
Action: JDouble, JSingle Direct or JReverse

J SC (Standard Control) (throttling control)

Includes AO, PID, ISEL, OS, AI, MAI, DO,


and four DI function blocks
J FC (Fieldbus Control) (throttling control)
Contains the AO function block
J FL (Fieldbus Logic) [discrete (on/off) connectivity]
Includes DO, and four DI function blocks

Steady-State Air Consumption(2)(3)


At 1.4 bar (20 psig) supply pressure: Less than
0.38 normal m3/hr (14 scfh)
At 5.5 bar (80 psig) supply pressure: Less than
1.3 normal m3/hr (49 scfh)

Block Execution Times


AO Block: 15 ms
PID Block: 20 ms
ISEL Block: 20 ms
OS Block: 20 ms

AI Block: 15 ms
MAI BLock: 35 ms
DO Block: 15 ms
DI Block: 15 ms

Maximum Output Capacity(2)(3)


At 1.4 bar (20 psig) supply pressure: 10.0 normal m3/hr
(375 scfh)
At 5.5 bar (80 psig) supply pressure: 29.5 normal m3/hr
(1100 scfh)

Electrical Input
Operating Ambient Temperature Limits(1)(4)

Voltage Level: 9 to 32 volts


Maximum Current: 19 mA
Reverse Polarity Protection: Unit is not polarity sensitive
Termination: Bus must be properly terminated per ISA
SP50 guidelines

-40 to 85_C (-40 to 185_F)


-52 to 85_C (-62 to 185_F) for instruments utilizing the
Extreme Temperature option (fluorosilicone
elastomers)

Digital Communication Protocol

Independent Linearity(5)

FOUNDATION fieldbus registered device

Typical Value: 0.50% of output span

Physical Layer Type(s):


Electromagnetic Compatibility

121Lowpower signaling, buspowered, Entity


Model I.S.
511Lowpower signaling, buspowered, FISCO I.S.

Meets EN 61326-1 (First Edition)


ImmunityIndustrial locations per Table 2 of the
EN 61326-1 standard.
EmissionsClass A
ISM equipment rating: Group 1, Class A

Fieldbus Device Capabilities


Backup LAS (Link Active Scheduler)

Vibration Testing Method

Supply Pressure(1)

Tested per ANSI/ISA-S75.13.01 Section 5.3.5.

Minimum Recommended: 0.3 bar (5 psig) higher than


maximum actuator requirements

Humidity Testing Method

Maximum: 10.0 bar (145 psig) or maximum pressure


rating of the actuator, whichever is lower

Tested per IEC 615142


-continued-

17 OF 30

Product Bulletin

DVC6200f Digital Valve Controller

62.1:DVC6200f FD
June 2012

D103422X012

Specifications (continued)
Vent: 3/8 NPT internal
Electrical: 1/2 NPT internal, M20 adapter optional

Electrical Classification
Hazardous Area Approvals
CSA Intrinsically Safe and FISCO, Explosionproof,
Division 2, Dust Ignitionproof
FM Intrinsically Safe and FISCO, Explosionproof,
NonIncendive, Dust Ignitionproof
ATEX Intrinsically Safe, FISCO, and Dust, Flameproof
and Dust, Type n and Dust
IECEx Intrinsically Safe and FISCO, Flameproof,
Type n
Electrical Housing
CSA Type 4X, IP66
FM NEMA 4X

Actuator Compatibility
Stem Travel (SlidingStem Linear)
Minimum: 6.35 mm (0.25 inch)
Maximum: 606 mm (237/8 inches)
Shaft Rotation (QuarterTurn Rotary)
Minimum: 45_
Maximum: 90_
Weight

ATEX IP66
IECEx IP66

The Gas Certified DVC6200f is CSA, FM, ATEX, and IECEx


approved for use with natural gas as the supply medium
Other Classifications/Certifications
INMETRO Brazil
NEPSI China
KGS Korea
TIIS Japan
Contact your Emerson Process Management sales office
for classification/certification specific information
Connections
Supply Pressure: 1/4 NPT internal and integral pad for
mounting 67CFR regulator
Output Pressure: 1/4 NPT internal
Tubing: 3/8inch recommended

Aluminum: 3.5 kg (7.7 lbs)


Stainless Steel: 8.6 kg (19 lbs)
Construction Materials
Housing, module base and terminal box:
A03600 low copper aluminum alloy (standard),
Stainless Steel (optional)
Cover: Thermoplastic polyester
Elastomers: Nitrile (standard)
Options
J
J
J
J

Supply and output pressure gauges or J Tire valves


Integral mounted filter regulator J LowBleed Relay
Extreme Temperature J Natural Gas Certified
Remote Mount(6) J Stainless Steel

Additional Information
For additional information go to www.FIELDVUE.com or
contact your Emerson Process Management sales office.

NOTE: Specialized instrument terms are defined in ANSI/ISA Standard 51.1 - Process Instrument Terminology.
1. The pressure/temperature limits in this document and any other applicable code or standard should not be exceeded.
2. Normal m3/hour - Normal cubic meters per hour at 0_C and 1.01325 bar, absolute. Scfh - Standard cubic feet per hour at 60_F and 14.7 psia.
3. Values at 1.4 bar (20 psig) based on a single-acting direct relay; values at 5.5 bar (80 psig) based on double-acting relay.
4. Temperature limits vary based on hazardous area approval.
5. Not applicable for travels less than 19 mm (0.75 inch) or for shaft rotation less than 60 degrees. Also not applicable for digital valve controllers in longstroke applications.
6. 4conductor shielded cable, 18 to 22 AWG minimum wire size, in rigid or flexible metal conduit, is required for connection between base unit and feedback unit.

Neither Emerson, Emerson Process Management, nor any of their affiliated entities assumes responsibility for the selection, use or maintenance
of any product. Responsibility for proper selection, use, and maintenance of any product remains solely with the purchaser and end user.
FIELDVUE, Fisher, and ValveLink are marks owned by one of the companies in the Emerson Process Management business unit of Emerson Electric Co.
Emerson Process Management, Emerson, and the Emerson logo are trademarks and service marks of Emerson Electric Co. FOUNDATION fieldbus is a mark
owned by the Fieldbus Foundation. All other marks are the property of their respective owners.
The contents of this publication are presented for informational purposes only, and while every effort has been made to ensure their accuracy, they are not
to be construed as warranties or guarantees, express or implied, regarding the products or services described herein or their use or applicability. All sales are
governed by our terms and conditions, which are available upon request. We reserve the right to modify or improve the designs or specifications of such
products at any time without notice.
Emerson Process Management
Marshalltown, Iowa 50158 USA
Sorocaba, 18087 Brazil
Chatham, Kent ME4 4QZ UK
Dubai, United Arab Emirates
Singapore 128461 Singapore

www.Fisher.com
E
4 2009, 2012 Fisher Controls International LLC. All rights reserved.

18 OF 30

3. AIR FILTER REGULATOR

19 OF 30

67 CFR Regulator
Specification

67 CFR
Quantity
Tag
Type
Signal & Supply
Input Pressure
Output Pressure
General
Material (Housing)
Output Gauge
Temperature Limit
Accessories
Pneumatic Connec.
Weight
Optional

-. 2 EA
-.
-. 67 CFR (67CFR-235)
-. Max 17.2Bar
-. 0 - 2.4Bar
-.
-.
-.
-.
-.
-.
-.
-.

Aluminum
1
0 - 2.4Bar
-40 - 180 Degree F (-40 - 82 Degree C )
Gauge
1/4 Inch NPT
1 Pound (0.5kg)
N/A

Notes
Details are shown as Catalog
1

Special Requirements

20 OF 30

Bulletin 71.1:67CF
02/99

67CF Series Filter Regulators

Compact and Light Weight

Designed for Digital Instrumentation

No Air Loss

Easy Maintenance
W7426

A 67CF Series regulator used as


a pilot supply regulator for the
Type 299 pressure regulator

A 67CF Series filter


regulator shown with
optional pressure gauge
W7412

W7423_1

Regulators

High Performance

Integral Filter

Internal Relief Valve

Rugged Construction
D102656X012

A 67CF Series regulator used


as a supply regulator for
digital instrumentation

www.FISHERregulators.com

21 OF 30

Bulletin 71.1:67CF
Introduction
The 67CF Series regulators are typically used to
provide constantly controlled, reduced pressures to
pneumatic and electropneumatic controllers and other
instruments. These direct-operated regulators are
suitable for most air or gas applications. Other applications include providing reduced pressures to air
chucks, air jets, and spray guns.

Features
CompactThe 67CF Series regulators are engineered for outstanding performance in a compact,
light-weight package.
Internal ReliefThe Type 67CFR has an internal
relief valve with a soft seat for reliable shutoff with no
discernible leakage.
Panel MountingPanel mount construction
includes spring case with 1/4-inch NPT vent,
handwheel adjusting screw, and mounting nut.
Instrument Supply RegulatorProvides a clean
air supply to a variety of pneumatic and electropneumatic instrumentation.
Digital Instrument Supply RegulatorDesigned
for the accuracy, repeatability, and hysteresis demands of digital instrumentation.
Pilot Supply RegulatorImproves the accuracy
of two-path control regulators by reducing inlet sensitivity caused by fluctuating inlet pressures.
Pressure Loading RegulatorProvides high
accuracy and improved performance in dirty steam
service by eliminating the need for a pilot regulator
(see figure 2).
Sour Gas Service CapabilityNACE (MR0175)
compliant construction available.
Integral FilterAn integral filter ensures clean
downstream air supply.
Ease of MaintenanceNo special tools are
required to perform maintenance, and all maintenance
can be performed with the regulator in the line. Filter
elements are easily replaced. The one-piece valve
plug cartridge allows easy inspection and replacement.

W7433

INLET PRESSURE
OUTLET PRESSURE
ATMOSPHERIC PRESSURE

Figure 2. 67CF Series Regulator Operational Schematic

Rugged ConstructionThe 67CF Series regulators are engineered for longer service life with minimal
maintenance requirements.
Second OutletBody side outlet for pressure
gauge or other uses.
Powder Paint CoatingFisher products are
powder paint coated, offering impact, abrasion, and
corrosion resistance.
Corrosion Resistant FastenersAdjusting screw
and screws are double zinc-chromated for enhanced
corrosion resistance.
Full Usable CapacityFisher regulators are
laboratory tested. 100 percent of the published
capacities can be used with confidence.

22 OF 30

Bulletin 71.1:67CF
Specifications
Body Size, Inlet and Outlets Connection Style
1/4-inch NPT screwed

Drain Valve and Spring Case Vent Location


Aligned with inlet standard, other positions optional

Maximum Inlet Pressure (Body Rating)(1)


250 psig (17,2 bar)

Approximate Unit Weight


1 pound (0,5 kg)

Outlet Pressure Ranges

Construction Materials
Body, Spring Case and Dripwell: Aluminum
(ASTM B85/Alloy 380)
Pusher Post: Polyester resin
Upper Spring Seat: Zinc-plated steel
Diaphragm Plate: Zinc-plated steel
Adjusting Screw: Zinc-plated steel
Filter Retainer: Zinc-plated steel
Valve Plug: Brass stem with nitrile (NBR) plug
(standard); aluminum stem with nitrile (NBR) or
fluoroelastomer (FKM) plug; or stainless steel
stem with nitrile (NBR) or fluoroelastomer (FKM)
plug (optional)
Soft Seat: Nitrile (NBR) (standard), or fluoroelastomer (FKM) (optional)
Diaphragm and O-Rings: Nitrile (NBR) (standard),
fluoroelastomer (FKM), or silicone (VMQ) (optional)
Control Spring: Plated steel (standard) or
Inconel (for 67CFR NACE)
Valve Spring: Stainless stee (standard) or
Inconel (NACE)
Drain Valve: Brass (standard), aluminum, or
stainless steel (optional)
Filter Element: Cellulose (standard), glass fiber, or
stainless steel (optional)

CONTROL SPRING DATA


OUTLET PRESSURE
Wire Diameter,
RANGES, PSIG (bar) Part Number
Color
Inch (mm)
0 to 20 (0 to 1,4) T14130T0012 green stripe 0.135 (3,43)
0 to 35 (0 to 2,4) T14059T0012
silver
0.156 (3,96)
0 to 60 (0 to 4,1) T14058T0012 blue stripe
0.170 (4,32)
0 to 125 (0 to 8,6) T14060T0012 red stripe
0.207 (5,26)

Maximum Emergency Outlet Pressure(1)


50 psi (3,4 bar) over outlet pressure setting
Capacities
See table 1
Wide-Open Flow Coefficients
Main Valve: Cg: 11.7; Cv: 0.36; C1: 32.2
Internal Relief Valve: Cg: 1.45; Cv: 0.045; C1: 32.8
Pressure Registration
Internal
Accuracy
Inlet Sensitivity: Less than 0.2 psig (0,014 bar)
change in outlet pressure for every 25 psig
(1,72 bar) change in inlet pressure
Repeatability: 0.1 psig (0,0069 bar)(2)
Air Consumption: testing repeatedly shows
no discernible leakage
Type 67CFR Internal Relief Performance
Low capacity for minor seat leakage only; other
overpressure protection must be provided if inlet
pressure can exceed the maximum pressure rating
of downstream equipment or exceeds maximum
outlet pressure rating of the Type 67CFR
Filter Capabilities
Free Area: 12 times pipe area
Micron Rating:
Cellulose Element: 40 microns
Glass Fiber Element: 10 microns
Stainless Steel Element: 40 microns
Regulator Temperature Capabilities
With Nitrile (NBR):
-40 to 180F (-40 to 82C)
With Fluoroelastomer (FKM):
0 to 300F (-18 to 149C)
With Silicone (VMQ)(3):
-60 to 180F (-51 to 82C)

Options
Handwheel adjusting screw
NACE construction
Ammonia service construction
Panel mount (includes spring case with 1/4-inch
vent, handwheel, and panel mounting nut)
Closing cap (available on spring case with
1/4-inch NPT vent)
Aluminum or stainless steel drain valve
Fluoroelastomer (FKM) elastomers for high
temperatures and/or corrosive chemicals
Silicone (VMQ) elastomers for cold temperatures
Triple scale outlet pressure gauge
(brass or stainless steel)
Stainless steel stem on the valve plug
Fixed bleed restriction mounted in the side outlet
Tire valve in second outlet
Pipe plug in second outlet

1. The pressure/temperature limits in this bulletin and any applicable standard or code limitation should not be exceeded.
2. Repeatability is the measure of the regulator's ability to return to setpoint consistently when traveling from steady state to transient to steady state.
3. Silicone is not compatible with hydrocarbon gas.

23 OF 30

Bulletin 71.1:67CF

67CF SERIES
FILTER REGULATOR

UPSTREAM PRESSURE
LOADING PRESSURE

W7434

DOWNSTREAM PRESSURE

TYPE 92P
STEAM REGULATOR

A 67CF SERIES PRESSURE LOADING REGULATOR USED WITH THE TYPE 92P STEAM REGULATOR ELIMINATES THE NEED FOR A
PILOT REGULATOR. THIS PROVIDES HIGH ACCURACY AND IMPROVED PERFORMANCE IN DIRTY STEAM SERVICE.

Figure 3. 67CF Series Regulator Used to Pressure Load a 92P Steam Regulator

Capacity Information
Table 1 shows the air regulating capacities of the
67CF Series regulators at selected inlet pressures and
outlet pressure settings. Flows are shown in scfh
(at 60F and 14.7 psia) and in m/h(n) (at 0C and
1,01325 bar) of air.
Note
The 67CF Series regulators may be sized
for 100% flow using capacities as shown
in table 1. It is not necessary to reduce
published capacities.

For critical pressure drops (absolute outlet pressure


equal to or less than one-half of absolute inlet pressure), use the following formula:
Q = (P1)(Cg)
where,
Q = gas flow rate, scfh
P 1 = absolute inlet pressure, psia
(P1 gauge + 14.7)
For pressure drops lower than critical (absolute outlet
pressure greater than one-half of absolute inlet pressure), use the following formula:

Q=
To determine the equivalent capacities for other gases,
multiply the table capacity by the following appropriate
conversion factor: 1.29 for 0.6 specific gravity natural
gas, 0.810 for propane, 0.707 for butane, or 1.018 for
nitrogen. For gases of other specific gravities, divide
the table capacities by the square root of the appropriate specific gravity.
To find wide-open flow capacities for relief sizing at
any inlet pressure, perform one of the following procedures. Then, if necessary, convert using the factors
provided above.

3417
520
CgP1SIN
GT
C1

P
DEG
P1

where,
Q
G
T
Cg
P1
C1
P

=
=
=
=
=
=
=

gas flow rate, scfh


specific gravity of the gas
absolute temperature of gas at inlet, Rankine
gas sizing coefficient
absolute inlet pressure, psia
flow coefficient (Cg Cv)
pressure drop across the regulator, psi

Then, if capacity is desired in normal cubic meters per


hour (at 0C and 1,01325 bar), multiply scfh by 0.0268.

24 OF 30

Bulletin 71.1:67CF
Table 1. Capacities
OUTLET PRESSURE
RANGE, SPRING PART
NUMBER AND COLOR,
PSIG (bar)

OUTLET PRESSURE,
PSIG (bar)

10% Droop

20% Droop

(1,0)

(3,4)
(5,2)
(6,9)
(10,3)
(17,2)

250
300
330
400
450

(6,7)
(8,0)
(8,8)
(10,7)
(12,1)

430
690
1150
1600
1800

(11,5)
(18,5)
(30,8)
(42,9)
(48,2)

(1,4)

50
75
100
150
250

(3,4)
(5,2)
(6,9)
(10,3)
(17,2)

350
530
750
1850
2800

(9,4)
(14,2)
(20,1)
(49,6)
(75,0)

500
820
1300
1850
3000

(13,4)
(22,0)
(34,8)
(49,6)
(80,4)

(2,4)

50
75
100
150
250

(3,4)
(5,2)
(6,9)
(10,3)
(17,2)

400
600
840
1850
3000

(10,7)
(16,1)
(22,5)
(49,6)
(80,4)

620
980
1300
1850
3000

(16,6)
(26,3)
(34,8)
(49,6)
(80,4)

35

(2,4)

50
75
100
150
250

(3,4)
(5,2)
(6,9)
(10,3)
(17,2)

370
540
760
1360
3000

(9,9)
(14,5)
(20,4)
(36,4)
(80,4)

560
940
1300
1850
3000

(15,0)
(25,2)
(34,8)
(49,6)
(80,4)

60

(4,1)

75
100
150
250

(5,2)
(6,9)
(10,3)
(17,2)

570
830
1450
2900

(15,3)
(22,2)
(38,9)
(77,7)

830
1220
1850
3000

(22,2)
(32,7)
(49,6)
(80,4)

80

(5,5)

100
150
250

(6,9)
(10,3)
(17,2)

600
880
1400

(16,1)
(23,6)
(37,5)

870
1320
2500

(23,3)
(35,4)
(67)

125

(8,6)

150
250

(10,3)
(17,2)

960
1700

25,7()
(45,6)

1400
2580

(37,5)
(69,1)

20

35

0 to 60 (0 to 4,1)
T14058T0012
Blue stripe

0 to 125 (0 to 8,6)
T14060T0012
Red stripe

CAPACITIES IN SCFH (m3/h(n)) OF AIR

50
75
100
150
250

15

0 to 35 (0 to 2,4)
T14059T0012
Silver

INLET PRESSURE,
PSIG (bar)

Overpressure Protection
The 67CF Series regulators have maximum outlet
pressure ratings that are lower than their maximum
inlet pressure ratings. A pressure relieving or pressure
limiting device is needed if inlet pressure can exceed
the maximum outlet pressure rating.
Refer to the Capacity Information section and the relief
sizing coefficient in the specifications table to determine the required relief valve capacity.
The Type 67CFR regulator has a low capacity internal
relief valve for minor seat leakage only. Other overpressure protection must be provided if the maximum

inlet pressure can exceed the maximum pressure


rating of the downstream equipment or exceeds
maximum outlet pressure rating of the Type 67CFR
regulator.

Ordering Information
When ordering, complete the Ordering Guide on page 8.
Refer to the Specifications on page 2. Review the
description to the right of each specification and the
information in each referenced table or figure. Specify
your choice whenever a selection is offered.

25 OF 30

Bulletin 71.1:67CF
4.56
(116)

2.56
(65)

3.00
(76)
1.48
(38)

0.62
(16)

3.50
(89)

INLET CONNECTION
1/4-INCH NPT

OPTIONAL GAUGE

OUTLET
CONNECTIONS
1/4-INCH NPT
0.69
(18)

MOUNTING HOLES
FOR 5/16-INCH
DIAMETER BOLTS

3.50
(89)

SIDE OUTLET
1/4-INCH NPT

2.25
(57)
B2699_A

2.87
(73)

INCHES
(mm)
B2699_B

DIMENSIONS
FOR GAUGE OPTION

STANDARD DIMENSIONS

VENT POSITION 1
(STANDARD)

VENT POSITION 3

INLET

DRAIN VALVE
POSITION 1
(STANDARD)

OUTLET

GAUGE

VENT POSITION 4

GAUGE

DRAIN VALVE
POSITION 4

VENT POSITION 2

DRAIN VALVE
POSITION 3

INLET

OUTLET

DRAIN VALVE
POSITION 2
B2699_D

B2699_C

VENT POSITIONS

Figure 4. Dimensions

DRAIN VALVE POSITIONS

26 OF 30

Bulletin 71.1:67CF
4.56
(116)

2.56
(65)

3.00
(76)

2.37
(60)
MAX PANEL
0.12 TO 0.25
(3,0 TO 6,5)

1.43
(36)

CLOSING CAP

1.48
(38)
0.72-INCH (1,8 mm)
SPRING CASE
PANEL BOSS

4.78
(121)
MAX

4.69
(119)
1/4-INCH NPT VENT
2.41
(61)
MAX
1.14
(29)

INLET CONNECTION
1/4-INCH NPT

OUTLET
CONNECTIONS
1/4-INCH NPT
0.69
(18)

OPTIONAL GAUGE

MOUNTING HOLES
FOR 5/16-INCH
DIAMETER BOLTS

3.50
(89)

SIDE OUTLET TAPPED


1/4-INCH NPT

2.25
(57)
B2700_A

2.87
(73)

INCHES
(mm)
B2700_B

DIMENSIONS FOR PANEL MOUNT OPTION


WITH HAND WHEEL AND 1/4-INCH SPRING CASE VENT

DIMENSIONS FOR CLOSING CAP OPTION


WITH 1/4-INCH SPRING CASE VENT

Figure 4. Dimensions (continued)

SPACER
(FOR INSTALLING A 67CF SERIES
REGULATOR IN AN EXISTING
INSTALLATION IF THE MOUNTING
BOLTS ARE TOO LONG)

0.25
(6.35)

0.50 OD
(12.7)

0.32
ID
(8.12)

B2697_B

SPACER OUTER DIAMETER

SPACER WIDTH AND


INNER DIAMETER
B2697_A

Figure 5. Spacer Dimensions and Installation Schematic

27 OF 30

Bulletin 71.1:67CF
Spring Case Vent Location (Select One)

Ordering Guide






Type (Select One)


 Type 67CF (without internal relief)***
 Type 67CFR (with internal relief)***

Spring Case Style (Select One)


 Standard with drilled hole vent***
 Handwheel adjusting screw***
 Panel mount (includes 1/4-inch spring case vent, handwheel
adjusting screw, and mounting nut)***
 Closing cap and 1/4-inch NPT spring case vent***

Outlet Pressure Range (Select One)


0
0
0
0

to
to
to
to

 Nitrile (NBR) (standard)***


 Fluoroelastomer (FKM)**
 Silicone (VMQ) diaphragm, O-rings, and nitrile valve plug*

Filter Material (Select One)

NACE (MR0175) Construction (Optional)


 Yes**

Ammonia Service Construction (Optional)


 Yes**

Application (Please designate units):


Specific Use
Line Size
Gas Type and Specific Gravity
Gas Temperature
Does the Application Require Overpressure Protection?
 No  Yes, if so, which is preferred:
 Relief Valve  Monitor Regulator  Shutoff Device
Is overpressure protection equipment selection assistance
desired?

Drain Valve Location (Select One)


1 - Aligned with inlet (standard)***
2
3
4

Pressure (Please designate units):


Maximum Inlet Pressure (P1max)
Minimum Inlet Pressure (P1min)
Downstream Pressure Setting(s) (P2)
Maximum Flow (Qmax)

Fisher Regulators Quick Order Guide

Brass Gauge
 0 to 30 psig/0 to 0.2 MPa/0 to 2 bar***
 0 to 60 psig/0 to 0.4 MPa/0 to 4 bar***
 0 to 160 psig/0 to 1.1 MPa/0 to 11 bar***

Specification Worksheet

 Brass (standard)***
 Aluminum***
 Stainless steel***

**

Triple Scale Pressure Gauge (Optional)

 Yes, send one replacement parts kit to match this order.

Drain Valve (Select One)

***

Open (standard)***
Plugged with pipe plug***
Tire Valve***
Pressure Gauge (see below)

Replacement Parts Kit (Optional)

 Cellulose (40 microns) (standard)***


 Glass (10 microns)***
 Stainless steel (40 microns)***

Position
Position
Position
Position






Stainless Steel Gauge


 0 to 30 psig/0 to 0.2 MPa/0 to 2 bar***
 0 to 60 psig/0 to 0.4 MPa/0 to 4 bar***
 0 to 160 psig/0 to 1.1 MPa/0 to 11 bar***

20 psig (0 to 1,4 bar) (not available for NACE)***


35 psig (0 to 2,4 bar)***
60 psig (0 to 4,1 bar)***
125 psig (0 to 8,6 bar)***

Diaphragm, O-Rings, and Valve Plug (Select One)






1 - Aligned with inlet (standard)***


2
3
4

Second Outlet (Select One)

Quantity (Specify)






Position
Position
Position
Position

Standard - Readily Available for Shipment


Non-Standard - Allow Additional Time for Shipment
Special Order, Constructed from Non-Stocked Parts.
Consult Your Fisher Sales Representative for Availability.

Performance Required:
Accuracy Requirements?
Need for Extremely Fast Response?
Other Requirements:

Availability of the product being ordered is determined by the component


with the longest shipping time for the requested construction.

Fisher Controls International, Inc., 1999; All Rights Reserved


Fisher and Fisher Regulators are marks owned by Fisher Controls International, Inc. The Emerson logo is a trade mark and service mark of Emerson Electric Co.
All other marks are the property of their respective owners.

The contents of this publication are presented for informational purposes only, and while every effort has been made to ensure their accuracy, they are not to be construed as warranties or guarantees, express
or implied, regarding the products or services described herein or their use or applicability. We reserve the right to modify or improve the designs or specifications of such products at any time without notice.

For information, contact Fisher Controls:


Marshalltown, Iowa 50158 USA
28320 Gallardon, France
Sao Paulo 05424 Brazil
Singapore 128461
Printed in U.S.A.

www.FISHERregulators.com

Regulators

28 OF 30

4. INSTRUMENT AIR TUBING


CONNECTION DWG

29 OF 30

Tubing and fittings should be Monel. Tubing from the positioner output port to the actuator is typically installed
by the equipment manufacturer. Otherwise, how can the louver system be function tested by the cooler manufacturer.
Air supply tubing to the regulator is typically provided by the Contractor.

30 OF 30

You might also like