Professional Documents
Culture Documents
Date:
Time:3 hours
Marks:100 EVEN
b) 0.25 L
c) 0.234 L
c) 1.5 d) 3
c) Columns only
a) 1
d) Beams only
b) 2
c) 3
d) 6
in a space structure is
c) 4
a) 2
d) 6
c)4
d)6
b) j-2r
b)3
a. a) 2j-r
of a plane structure is
behaves elastically
d) 0.5 L
b) 3
10. Effects of shear force and axial force on plastic moment capacity of a
a. a) 2
b) 2
a)1
a) 0.211 L
7. For a symmetrical two hinged parabolic arch, if one of the supports settles
d)2j+r
b) is decreased
c) remains unchanged
d)
Part B (5 X 4= 20 marks)
Answer any five questions
21. Find the support moment MA at A for the propped cantilever for the span
of 12m. Compute the i.l. ordinates at 2m.
22. A three hinged parabolic arch of span 40m and a central rise of 8m
carries a concentrated load of 200kN and 150kN at the distance of 8m
and 16m from the left end and an udl of 50kN/m on the right half of the
span. Find the horizontal thrust and resultant reaction. 5kN load is
leading.
23. Suspension cable of horizontal span of 95m is supported at two two
c) both a) and b)
different levels. The right support is higher than the left support by 4m.
the dip to the lowest point of the cable below the left support is 5m.there
17.Effects of shear forces and axial force on plastic moment capacity of a structure
are respectively to
a) increase and decrease
b) increase and increase
increase
d) decrease and decrease
c) decrease and
cross sectional area of the cable is 3500mm2. Find the uniform distributed
load that can be carried by the cable if the maximum stress is limited to
600N/mm2.
24. Find the shape factor for the Diamond section.
25. Write the analysis procedure by stiffness matrix method.
26. Find the flexibility matrix of cantilever beam show in fig. 26 (b).
19.A single rolling load of 8kN rolls along a girder of 15m span. The absolute
maximum bending moment will be
a) 8kNm
b) 15kNm
c) 30kNm
d) 60kNm
27. Find the shape factor for triangle when the base is parallel to vertical axis.
Part C (5 X 16= 60 marks)
Answer any all questions
28. A) Using Muller Breslau principle, draw the influence line for bending
(OR)
B) Analyse the structure show in fig. 31(b). by stiffness method.
32. A) Analyse the continuous beam as show in fig. 32. (a) by the flexibility
method.
distance of 10m from the left of C and a second load of 60kN at 20m to
(OR)
the right of C. Find the Reaction, horizontal thrust, Bending moment and
B). Analyse the frame shown in fig.32.(b) by the matrix flexibility method.