Professional Documents
Culture Documents
1. PURPOSE:-
2. SCOPE:-
3. DEFINITION:-
HOD-MEC/ MR
6. PROCDURE:6.1
6.2
Raw material inpection as per specified in drawing before fabrication work should proceed
The following inspection should be done in raw material selection
Selection of raw material (MS plate) should be done as per specified in
respective drawing
Fabrication procedure for tank are as follows: Rolling
Assembly
Inspection
Finishing job
6.3
Rolling:
For rolling a plate first edge bending in both end of MS- plate required by
punching and hammering as per requirement
As required edge bending work over should be process further for plate
rolling through rolling machine as per requirement the pressure roller of the
machine should be adjust through adjusting screw
Safety precaution should be taken during rolling a plate through rolling
machine
6.4
6.5
6.6
6.7
Finishing Job :After completion of assembly of shell final finishing jobs are to remove unwanted
material from the surface of shell through grinding ,and there after standard paint
coat should be done to prevent the steel from get rust
Safety precaution should be taken during Fabrication:
7.0 RECORDS:
During hot work Use proper leather hand gloves ,safety glass, face shield ,
apron ,safety shoe , proper nrv systems should use in L.P.G and Oxygen
cylinder And cutting torch , etc
Rolling machine operation, works man should be keep distance from the
instructed danger area by safety supervisior
Tools tackles should be proper damage tools should not be provide on site
All the protocols and records should be prepared by site Engineer and submit to Section
incharge on Daily Basis
All the inspection Records should be maintain on daily work basis
Final inspection report of section should be summit to the management as per instruction
provided