Professional Documents
Culture Documents
1.
2.
3.
4.
5.
6.
7.
8.
52. The no.of parallel paths required for a 2 pole duplex lap winding
machine----(4)
53. The voltage equation for a dc motor------(Eb=V-IaRa)
54. The angle b/w rotating field flux and rotor---------(synchronizing angle)
55. An SCR is a------------(4-layer, 3terminal device)
56. In normal operation of a pnp transistor its junctions are biases-------(EB-forward,CB-reverse)
57. The voltage that is applied to diode when its reverse biased-------(PIV)
58. The min no.of diodes required for a fullwave rectifier-----------(2)
59. The input of rectifier is 230v, 50hz the o/p freq is-------(zero)
60. An ideal opamp---------(infinite i/p impedance, zero o/p impedance)
61. Photo transistor works on-------------(Light intensity)
62. A transistor amplifier with low efficiency------------(Class A)
63. By considering noise level which type of modulation is preferred-------(FM)
64. Modulation purpose is--------(enable efficient transmission over long
distance)
65. DVM measures---------(rms value)
66. The time settings in CRO can be done by--------(x-axis)
67. The bidirectional operation of two SCRs connected back to back
is---------(TRIAC)
68. SMPS uses---------(MOSFET)
69. Moving coil instruments are used to measure-----------(DC)
70. The speed of the motor can be measured by----------------(Tachometer)
71. Orifice meter is used for measuring-----------(flow)
72. Pressure measuring instrument-------73. Temperature measuring instruments------------(thermocouple)
74. Megger is used for -----------(measuring insulation R)
75. The Otto cycle is a-------------(4-stroke engine)
76. In a petrol engine mixing of fuel and air occurs in-----------(carburetor)
77. How PLC connecting with PC--------(RS-232, RS-485, Ethernet )
78. Non volatile memory is--------(when power off memory will be lost)
79. EX-OR gate-------------(AB+AB)