Professional Documents
Culture Documents
Integration:
The following outlines common tips for integrating Pelco Sarix
cameras with a NetBotz appliance. If you are having diffi culty
confi guring a NetBotz appliance to work with a Pelco Sarix camera,
please ensure that you have read and tried all of the following tips
and procedures.
It is best to confi gure the settings on the Pelco Sarix camera prior to
discovering it on the NetBotz appliance. If any confi guration
changes are made to the Pelco Sarix camera after it has been
discovered by a NetBotz appliance, the NetBotz appliance must be
rebooted in order for the Pelco Sarix confi guration changes to be
synchronized.
Pelco:
Start by resetting Pelco Sarix camera to defaults
1. Hardware
1. Locate the reset button on the board inside the back box.
2. Press and hold the reset button. The camera status LED will cycle through several different color
modes.
3. When the status LED flashes red, release the button. All settings have been set to factory defaults
and unit will reboot.
2. Software
1. Log in to camera
2. Click on "Settings" menu.
3. On the "General" tab is a section labeled "Reset to Factory Defaults".
4. Check in the box "Select All"
5. Click "Save"
NOTE: In some cases, resetting a camera to defaults or using one of the Presets for A/V Streams does not
achieve the above criteria. ALWAYS verify the primary and secondary streams match the above criteria
during the configuration process!
NetBotz Appliance:
Only the NetBotz 455/456, NetBotz 550, and NetBotz 570
support integrating with a Pelco Sarix camera.
Ensure that you are using botzware 3.3 or higher in order to
integrate with a Pelco Sarix Camera, and that the Advanced
View software version matches the version of botzware on the
NetBotz Appliance.
Ensure that the Pelco Sarix camera is discovered using port 80
and NO SSL options.
Pelco PTZ camera configuration can be performed via HTTP only on port 80 only. Camera
configuration settings performed on Pelco PTZ cameras discovered via HTTPS are not applied. This is
planned to be addressed in a future release of botzware.
Discover the Pelco Sarix camera under Pod & Rack Access PXHID Sharing in NetBotz Advanced View. Then ensure that you
choose the Pelco Sarix camera and select Share Remote Pod in
the bottom pane.
In botzware 4.2 you can check the Add as Camera option during discovery which will result in
the camera being shared automatically once discovery is completed.