Professional Documents
Culture Documents
I.
INTRODUCTION
v ( t ) = v s ( t ) sin( wt ) + v c ( t ) cos( wt )
Proceedings of the 2nd International Conference on Computer Science and Electronics Engineering (ICCSEE 2013)
(2)
di
+ v + sgn(
i)v
dt
dv
= i
dt
dv f
Vf
+
= | i |
dt
R L
ab
(3)
sgn ( x ) = 0, x = 0
1, x < 0
ip
ip
2
| i | i p
i = i 2 + i 2
s
c
p
Lr
Lr
C r
C r
C f
di s
4 is
4
= L r wi c v s
v f + sin( d ) v g
dt
2
ip
di c
4 ic
= L r wi s v c
vf
dt
ip
(5)
dv s
= C r wv c + i s
dt
dv c
= C r wv s + i c
dt
dv f
vf
2
= ip
dt
RL
3
Lr I p
4 I s I cV f
W
3
Lr I p
1
A=
Cr
2Is
C f I p
W +
4 I s I cV f
Lr I 3p
4 I s2V f
1
Lr
1
Lr
Lr I 3p
1
Cr
2Ic
C f I p
2V g cos( 2 D )
Lr
B =
4Is
Lr I p
4Ic
(6a)
Lr I p
R L C f
0
(6b)
(6c)
C = [0
0
0
0 1]
According to the relationship between (6) to transfer
function of small signal model, the transfer function (7) of
v
Proceedings of the 2nd International Conference on Computer Science and Electronics Engineering (ICCSEE 2013)
III.
SIMULATION RESULTS
a D=0.2
LrC r
= 50 . 6 kHz
b D=0.5
Fig 3.2 the open-loop bode diagram as D=0.2 and D=0.5
The Fig 3.1 and Fig 3.2, indicates that the change of D
can only result in the change of the gain of the open-loop
system, and the phase-frequency characteristic will not
change.
Also, the bode diagram changes along with the change
of Vg in a similar way.
The following figure 3.3 shows the output voltage
waveform after the simulation to the system by using PSIM
simulation software.
The figure 3.3shows, output voltage Vf static stability
values accord with theoretical analysis and 58v results.
Proceedings of the 2nd International Conference on Computer Science and Electronics Engineering (ICCSEE 2013)
IV.
0 .7
( s + 1000 )
s
(8)
CONCLUSION
[1] Weiping Zhang, The model and control of switch converter. Beijing:
Electric Power Publishing House,2005.pp.285-300
[2] S. Sanders, J. Noworolski, X.Z. Liu, and G. Verghese, "Generalized
averaging method for power conversion circuits," Power Electronics
Specialists Conference, 1990. PESC '90 Record., 21st Annual
IEEE ,pp.333-340, Jun 1990.
[3] F. Silveira Cavalcante, and J. Kolar, Small-Signal Model of a 5kW
High-Output Voltage Capacitive-Loaded Series-Parallel Resonant
DC-DC Converter, Power Electronics Specialists Conference
2005.,pp.1271-1277, Jun 2005.
[4] Divan D M, "The resonant DC link converters a new concept in static
power conversion. EEE Trans Ind Applicat,1989,25(2):3 17-325
[5] Weiping Zhang, Peng Mao, and Yuanchao Liu Small-Signal
Modeling of Series Resonant Converter PEDS 2007
[6] V. Vorperian, "Approximate Small-Signal Analysis of the Series and
the Parallel Resonant Converters," IEEE Transaction on Power
Electronics, Vol. 4, No. 1, pp.15-24, January 1989.
[7] Seth R.Sanders, J. Mark Noworolski, Xiaojun Z.Liu, andGeorge
C.Verghese "Generralized Averaging Method for Power Conversion
Circuits" IEEE Transaction on Power Electronics,Vol.6,No.2,pp.251259,April 1991.