Professional Documents
Culture Documents
TELEPHONE
NUMBERS (BASED)
71. POWER GRID CONTROL THROUGH PC
72. i.V.R.S. SYSTEM FOR INDUSTRIAL
CONTROL
Controller
49. Embedded Micro controller Based Nomad Robots for exploration Application
50. Embedded Micro controller Based Robots for weather forecasting.
51. Vehicle Accessing using Authentication
52. Non-Contact Smart Card Reader Based Campus Management system.
53. Web/wap based system for remote monitoring patients with data mining support.
54. Remote Monitoring and Control using Mobile phones
55. Secured Postal Data Communication using RFID and E-POST
56. Distributed Multi area Power systems load flow monitoring
57. Smart Card based Attendance monitoring with Multi-Door output.
58. Secure Transmission of Sensitive data using Multiple channels
59. Micro controller Based Standalone Temperature Measurement System.
60. Micro controller Based Ultrasonic Pulse Detector.
61. Pc Based Flow Control And Level Measurement In Petrol Bunks.
62. Pc As A Pid Controller.
63. Vector Controlled Device For Energy Saving Air Conditioning System.
64. Fuzzy Logic Based Differential Relay For Power Transformer Protection.
65. Electric Power Generation using Footstep Method.
66. Embedded Micro controller based Grid Synchronization.
67. Energy Management Control System with WAP
68. Home Automation Using X-10 Protocol.
69. Bi Directional VF Control of Single Phase AC Motors.
70. Frequency Actuated Load Shedding with substation monitoring
71. Management of sub-transmission and distribution system in power systems
72. Mobile - Half Bridge Configuration Based High Voltage Generation of 10KVA_1KHZ
73. Vector Controlled Drive for Energy Saving in Air Conditioning system
74. High Performance AC Supply with Low Harmonic Distortion for multiphase AC Machines.
75. Enhancement of power system performance using STATCOM
76. Management of sub-transmission and distribution system in power systems.
77. Remote data monitoring using WAP Information Gateway
78. Embedded system based highway monitoring system and control
79. Automatic Anesthesia controller with respiratory system using Heart beat Sensor
80. Intelli mobile robot for multispeciality operations
81. prepaid electricity system automation with contact less proximity card & card reader
82. IVRS Based smart home automation with voice feedback.
83. smart solar tracking for optimal power generation
84. Wireless AI Based voice controlled intelli robot for multispeciality operations
85. Network enabled Electronic Digital televoting machine.
86. Speech Recognition based complete Car Security System
87. OFDM Based Wireless Encryption/Decryption of Transfer of Messages.
88. Synchronized DC Defibrillator with PC Interface
89. Stand-alone Synchronized DC Defibrillator with LCD Interface
90. RF Based Wireless Complete Body Scanning System Using WAP
91. RF Based Medi-Kits for Houses with Emergency Dialer.
92. RF Based Wire less Heart Beat Rate Monitoring System
93. Medicare System for Hospital Automation
94. Study and working of Peritoneal Dialysis with Model.
95. IR based human radiation detection online
96. PC based emergency ambulance calling system
97. PC based body temperature measurement and control
98. Automatic anesthesia feeder based on respiratory
99. Automatic anesthesia feeder based on resp temp with temp with model
100. Automatic anesthesia feeder based on HBC with model.
101. Blue tooth Enabled Wireless Communication with Handheld Device.
102. Advanced Sensors Controlled Bank Security System.
103. Home Networking and Security System With Wap
104. Tape less Voice Storage and Retrieval using APR9600.
105. Electro magnetic Proximity Card Reader with Weigand output based Access Control System with Double Level Security.
106. Electro magnetic Proximity Card Reader with Weigand output based Time and Attendance System.
107. Electro magnetic Proximity Card Reader with Weigand output based Security Cards.
108. EMPCR with Weigand output Based Electricity Billing Automation.
109. EMPCR with Weigand output Based Electricity Billing Automation with WAP.
TELEPHONE MESSAGE CONVEYOR: Anyone will get the pre-recorded message stored in a digital
chip as voice playback system. One can record message of its own. One can put an introductory
message on it.
A good example of IVRS (Interactive voice response System) to get informations by just pressing the
mobile/telephone keys.
TELEPHONE CALL METER: - It helps the user by converting the STD and ISD calls to equivalent
local calls and storing them.(18-82)
TELE-VOTING MACHINE WITH VOICE MESSAGE: The remote voting can be done with voice
message conveyor. The mobile/landline phone can be placed at transmitting and receiving end. One
can listen the voice message and than cast his vote to the selected candidate.
TELE-BANKING WITH VOICE MESSAGE: The remote MESSAGE can be sent with voice message
conveyor. The mobile/landline phone can be placed at transmitting and receiving end. One can listen
the voice message and than act accordingly like to open account, information for loans, ATMs etc. as
IVRS.
TELE-SECURITY SYSTEM FOR HOME: The home or any other area can be made fully secured using
this device. The Infrared
sensor or microphone will activate the mobile or landline to redial your saved
DIGITAL IR VISITOR COUNTER-STOP WATCH: - This solid-state digital stopwatch display time
taken for an event in seconds upto 99. (4-110)
DIGITAL MESSAGE DISPLAY: - The SEVEN digit English alphabets (More are optional) can be
operated in a moving pattern using this device like WELCOME.
TRUTH TABLE EVALUATOR & K-MAP PLOTTER: - With this circuit you can evaluate the truth
table as well as plot Karnaugh map of any Boolean expression.(02-12-96)
ELECTRONIC DICE: - This electronics dice makes a throw for you at the push of
button. The LED display looks as a conventional dice face. (5-126-1410-148 16-130)
DIGITAL DICE WITH NUMERIC DISPLAY: - In this circuit the timer IC 555 is wired
as an astable multivibrator that produces pulses at about 48KHz and it display a random
number. (98-09-83)
SOLID STATE ADVERTISEMENT DISPLAY: - A 5 even output letter word can be
display one by one switching off relay/traic operated bulb.(15-74)
CLASSROOM ADDRESSING AMPLIFIER: A circuit which helps the principal/teacher to address
from single source to add classes.
DIGITAL SPEED
operate the connected light to save electricity. The digital up/down counter will display the
number of persons inside the hall and if nobody is there, the lights will go off.
ULTRASONIC MOTION DETECTOR: Any motion in and around ultrasonic sensing area will
activate the circuit and alarm will warn.
ULTRASONIC CAR REVERSE SENSOR/OBJECT DETECTOR: The project can be placed on
the back or front of car. It will give warning indication if the distance from wall decreases to a
certain level. It can be used as motion sensing alarm.
ULTRASONIC RADAR : It moves in 360 degree circular motion and detect the object in the near
by area and gives alarm indication.
ULTRASONIC GUN: It detect the object and fire instantly with electromagnetic gun connected
with it.
ULTRASONIC OBJECT COUNTER: It counts the number of persons going through its area.
Reference: http://seminarprojects.com/Thread-electrical-engineering-projects-for-final-year?page=2#ixzz1wbV7GcoH
a. Smart card ticketing system
b. Prepaid EB metering system
c. GSM Based Home Security System
d. GSM Based Fault alarm in industries
e. RFID based bank security system
f. RFID based voting machine
g. RFID based security system for automobiles
h. RFID Attendance System
i. APPLIANCES REMOTE CONTROL
j. ARTICLE TRACKING SYSTEM USING GPS AND GSM
k. AUTOMATIC IRRIGATION SYSTEM
l. AUTOMATIC BILLING SERVICE PROVIDER
m. AUTOMATIC COLLEGE BELL
n. AUTOMATIC GARDENING SYSTEM
o. AUTOMATIC GUIDED VEHICLE
p. AUTOMATIC INTELLIGENT PLANT WATERING SYSTEM
q. AUTOMATIC RAILWAY GATE CONTROL SYSTEM
r. AUTOMATIC ROOM ILLUMINATION CONTROL
s. AUTOMATIC GARDENING SYSTEM
t. AUTOMATION BY USING ZIGBEE PROTOCOL
u. AUTOMOTIVE SPEED MONITORING SYSTEM
v. AUTONOMOUS ROBOT
w. BANK TOKEN SYSTEM
x. BUS STOP AUTOMATION (RFID)
y. CELLPHONE BASED DEVICE CONTROL SYSTEM
z. DENSITY BASED TRAFFIC CONTROLLER
aa. DEVELOPMENT OF REMOTE PATIENT MONITORING SYSTEM USING GSM
bb. DIGITAL SECURITY LOCK
cc. DIGITAL VISITOR COUNTER
dd. GSM BASED SECURITY SYSTEM
ee. GSM BASED SECURITY USING PIR
ff. GSM BASED AUTOMATIC IRRIGATION WATER CONTROL SYSTEM
gg. GSM BASED CAR SECURITY SYSTEM
hh. HOME APPLIANCES CONTROL THROUGH IR REMOTE
ii. APPLIANCE CONTROL USING BLUE TOOTH PROTOCOL
jj. INDUSTRIAL AUTOMATION USING ZIGBEE
kk. HOME SECURITY SYSTEM
ll. INFRARED PROXIMITY DETECTOR
mm. LINE FOLLOWING ROBOT
nn. MICROCONTROLLER BASED RTC & DEVICE CONTROL BASED ON TIME
oo. MOBILE BASED HITECH DOOR LOCKING SYSTEM
pp. NIGHT LIGHT SAVER
qq. NUMBER PLATE RECOGNITION
rr. OBSTACLE AVOIDANCE ROBOT USING INFRARED SENSORS
ss. OFFICE AUTOMATION SYSTEM
tt. PASSWORD BASED DOOR LOCKING
BELL
CONTROL
33pf 2
ir pair
power supply unit
SOFTWARE:
KEIL
PROTEUS
TOPVIEW SIMULATOR
RIDE
ISP
Reference: http://seminarprojects.com/Thread-density-based-traffic-light-control-system#ixzz1wbXkN5AO
A Three Motor Walking Robot. This three motor BEAM type walking robot is a lot more capable than the one motor walking
robot above. The write-up for this project includes photos of the robot walking over a couple of fairly thick books.
Speech Amplifier/Loudspeaker. A compact amplifier/loudspeaker powered by a 6 volt battery pack to make sure you are heard,
heres the circuit and some details.
Battery Powered Guitar Practice Amplifier. Want to practice your guitar playing somewhere without power? The Ruby
amplifier is designed to work on a nine volt battery pack, heres the circuit and some details.
A 100 watt guitar amplifier. If you like the idea of building a powerful guitar amp check out this project by Rod Elliot. His
project description and circuit drawings provide clear guidance in building a 100 watt guitar amplifier. However this amplifier is
designed to plug into a wall outlet for power, if you are not familiar with building circuits powered by
attempt this project.
Vacuum Tube Guitar Amplifier. If you would like to build a tube based guitar amplifier look at these projects on the Cooperative
Tube Guitar Amp Project web site. Make sure your have the knowledge and skills to work with high voltage before you tackle
this project.
Just A Minute. This circuit on the Electronics Zone Website fits up to 8 players in a knowledge quiz game. The first one to tap
their button rings a buzzer and gets to answer the question.
A pocket sized headphone
up the sound for your headphones.
amplifier. This project shows how to fit a amplifier circuit inside a peppermint tin to soup
Analog Sound Synthesizer. This very well detailed project write-up on the Music from Outer Space Web site shows how to build
a analog sound synthesizer.
Turning Gadgets On with a Wave of Your Hand. This circuit by Dave Johnson compares the signals from two photodiodes using
a comparator chip. When you pass your hand over the photodiodes the output of the comparator chip goes high, turning on a
transistor which Dave uses to power a buzzer in his circuit.
A refrigerator door alarm. Heres a circuit by Charles Wenzel that sounds an alarm when the refrigerator door stays open
longer than the time you preset. A great way to stop your cat from getting in the refrigerator if you forget to close the door.
A Simple Walking Robot. Would you like to build a 4 legged walking robot? Try this project building a BEAM type walking robot
with a minimum of components and very low cost.
.Clap Activated Remote Control: This interesting circuit on the Electronics Zone Web site allows you to build a remote control
activated by clapping your hands.
Electric Wire Locator: This circuit by Charles Wenzel can be used to locate electric wires in walls, it may be useful when remodeling.
Let me know how accurate it is.
Sound Pressure Meter: This circuit on the Red Circuits Web site is used to calibrate the sound output of each speaker in your
sound or home
theater system so that they all have produce the same volume at your favorite chair.
Weather Station. This project on the TechDesign Electronics Web site uses the PIC 18F452 microcontroller, pressure,
temperature, and humidity sensors along with radio transmitter and receiver modules to allow you to monitor the weather.
Running Message Display. This circuit on the Electronics Zone Website shows how to use LEDs to light up a message, such as
WELCOME, one letter at a time. When the whole message is alight the message goes dark and starts up again with the first letter.
Plant Moisture Meter. This circuit takes the guesswork out of watering plants by lighting up an LED when the soil is dry.
Rain Detector. This circuit by Charles Wenzel activates a buzzer to let you know that its starting to rain so you can cover up
items in your yard.
A pocket sized LED display that lights up to music. This project on the Electronic Peasant Website shows how you can create
three spirals made up of LED's that light up to different frequencies of music. The components all fit into a shape compact enough to
clip onto your pocket, if you like to dance with lights this could be a neat effect.
Guitar Fuzz-Box: An operational amplifier based circuit which produces a wide range of sound effects.
Circuit for High Speed Photography. Would you like to take photos of split-second events such as the momentary splash when
you drop a crouton in a bowl of soup? This circuit by Matthew Swann triggers your cameras flash after the crouton, or other
object passes through an IR beam.
A wireless scarecrow. This project by Charles Wenzel detects footsteps of a deer or other creature and sounds an alarm to
scare them away from your vegetable patch. I especially like the way he shows you how to protect the circuit from bad weather.
Color Sensor. This project on the Electronics Zone Web site shows how to use of optical filters and light dependant
resistors together to drive electronic circuitry that lights a LED corresponding to which one of five different colors of light is present.
While I cant think of a practical use it's a nice demonstration of mixing optics and electronics.
Putting Together a Remote Control Lawn Mower. If you like the idea of building a remote control lawn mower check out
the instructions for building one on the Popular Science Magazine Web site. This project by Dave Prochnow shows how to build the
mower he calls the Lawnadillo.
40 meter radio receiver. The circuit for a 40 meter radio receiver comes with some interesting tips that gives a glimpse of the
techniques used to build a receiver from basic components.
75 meter ham transceiver. After youve got your ham license you might try this transceiver project, the author has
provided some very nice photos to help you lay out the circuit
Courtesy http://buildinggadgets.com/index_circuitlinks.htm
Reference: http://seminarprojects.com/Thread-electrical-instrumentation-applied-electronics-project-ideas-list#ixzz1wbYaU6s0
Dialer
card reader
36. A Control Design for Vehicle Speed using Wireless Communication Technology
37. Automatic Vehicle Register System for Highways on Toll plazas
38. Tracking Moving Person's Location (Position) Finder In Multi-Storys Building / Complex / Hospital / Industry using System
Networking
39. Home/Industrial Automation using GSM With Voice Feedback.
40. Smart palm device for industrial parameter Monitoring System using RF
41. Control of substation equipments thro mobile phone
42. Mobile Password Activation System for industrial applications
43. Tracking Moving Person's Location (Position) Finder In Multi-Storys Building / Complex / Hospital / Industry using System
Networking
44. Embedded system based highway monitoring system and control
45. Intelligent Vehicle accessing system using RFID cards
46. campus management system using RFID Cards
47. Distant Vehicle identifying and Automatic Entry System using Acative RFID
48. RFID based ATM Center Automation
49. RFID based Automation Airline baggage Systems
50. A multipurpose identification card using RFID cards
51. Electro magnetic proxinity Card Reader with Weigand output based Access Control System with Double Level
Security
52. Electro magnetic proxinity Card Reader with Weigand output based Time and Attendance System
53. EMPCR with Weigand output Based Electricity Billing Automation
54. EMPCR with Weigand output Based Electricity Billin Automation with WAP
55. Bio Metric (Finger print) based Authentication & Access Control System
56. Finger Print plus EMPCR card based ATM Authentication system and cash delivery system
57. Finger Print Authenticated, Access Control & Automated Door Opening System
58. Finger print identification based Digital Voting System
59. Finger print identification Equipment Control System on Industries
60. Fingerprint based Complete car security system
61. Fingerprint based Physical Access Control car Immobilizer
62. Mobile Password Activation System for industrial Applications
63. Biometric Finger print Identification with PIC Based Access Control System
64. Biometric Finger print Identification with PIC Based Time Recorder with Weigand Output
65. Biometric Finger print Identification with PIC Based Bank and Locker Security system
66. Fire protection system with Fire Extinguishing Ball
67. Multi Zone Fire Alarming Control panel with Zone Location
68. Biometric Finger Print identification with PIC Based Vehicle Access System
69. Biometric Finger Print Identification with PIC Based Guard Alert Monitoring system with PC interface
70. RFID Based Guard patrolling system with PC Interface
71. IRIS Recognition system in Authenticating Highly Secured Data
72. IRIS Scanner Using Access control Monitoring system
73. Voice activated door control systems
74. Voice command system for home appliance control
75. Non-Contact Smart card Reader Based Campus management system
76. Secured Postal Data Communication using RFID and E-POST
77. Smart Card based Attendance monitoring with Multiple - Door output
78. Secure Transmission of Sensitive data using Multiple Channels
79. Embedded System Based Interlocking System For Chemical And Pharmacheutical Industries
80. Home appliances control using voice Dictation
81. Industrial Security system with Sensor data acquisition and Wireless transmission
82. Advanced Wireless system with Security System for Fire Safety with Alarm
83. Contact Less Electro magnetic Proximity based campus management System
84. Remote activation of Electrical Applicances with mobile phones
85. Industrial Safety Measures System with Sensors and Web Cam
86. Industrial Safety Measures System with Sensors
87. Industrial Safety Measures System with Sensors with Voice Indication
88. Attendance Marker system with IRC Reader
89. Attendance Marker system with IRC Reader with FACE indicator
90. Embedded PIC Micro controller based Safety Road Control With WEB CAM
91. Embedded PIC Micro controller based Controlling of devices through Telephone Lines
92. Home Networking and Security System With Wap
WIRELESS VIDEO TRANSMITTER: - The signals of any video can be transmitted to TV with in
15/20mtr range. (13-162)
WIRELESS RF OBJECT COUNTER FOR INDUSTRY: - This wireless object counter count the
number of items produced by a machine placed 50mts. far from source. One can control the power
of machine remotely (RF transmitter and receiver unit) when desired.
WIRELESS RF HOME SECURITY SYSTEM: - It has an intruder sensor cum transmitter and a
receiver. The sensor reacts to light, sound and mechanical movements. (17-35)
WIRELESS RF HOME SECURITY SYSTEM WITH DIGITAL CODE LOCK: - It has an intruder
sensor cum transmitter and a receiver. The sensor reacts to light, sound and mechanical
movements. One can enter only if the four digit code number is rightly entered. (17-35)
WIRELESS RF HOME SECURITY SYSTEM WITH VOICE MESSANGER: - It has an intruder
sensor cum transmitter and a receiver. The sensor reacts to light, sound and mechanical
movements. It will transmit the audio file to FM using digital voice recording and play back circuit.(1735)
WIRELESS RF LAND ROVER : A robotic vehicle that is controlled remotely by RF transmitter using
RF 433 Mhz modules with data encoder and decoder ICs. It can go forward, reverse, left or right.
Detecting metal and inform to the operator is an optional attachment in this project.
WIRELESS RF CODE LOCK FOR CAR/DOOR: Digital combination code lock to be opened
remotely by RF transmitter and activate the door relay and motor to open the same.
WIRELESS WI-FI (Demo) AMPLIFIER: - A wireless FM transmitter and receiver unit with suitable
amplifier.
WIRELESS RF DATA COMMUNICATION CDMA DEMO: The data modules will transmit data
signals using suitable RF modules showing basic CDMA communication technique.
WIRELESS RF LOCAL POSITIONING SYSTEM: The distant location of vehicle / train can be
checked / traced by this simple technique using RF modules with data encoders and decoders.
WIRELESS RF PULSE RATE/HEART BEAT COUNTER : The simple event counter with dual
display and a minute timer can count the RF HEART pulses coming from distance. The pulse rate of
heart will be taken from the infrared IR finger sensor.
WIRELESS RF PULSE RATE/HEART BEAT COUNTER CUM GRAPH PLOTTER: The simple
event counter with dual display and a minute timer can count the RF pulses of HEART coming from
distance and plot the graph on paper to read. The pulse rate of heart will be taken from the Infrared
IR finger sensor. (9-143)
WIRELESS RF WALKIE TALKIE: FM transmitter with receiver circuit in combine for both way voice
communication.
WIRELESS RF WATER LEVEL INDICATOR CUM CONTROLLER: The data transmission from
overhead tank will be displayed at ground level for remote viewing.
WIRELESS RF TIME OPERATED ELECTRICAL DEVICE: An electrical device will be remotely
operated for specific time using simple timer circuit.
WIRELESS RF REMOTE SWITCH BOARD: The data transmission using RF 433 Mhz module will
enable to operated four electrical device switching or single fan speed control.
WIRELESS RF DC/AC MOTOR SPEED CONTROL: The remote operation to control speed of fan or
motor using single RF signal circuit with gear motor driver. Can be used as remote lamp dimmer.
WIRELESS RF RADIO CONTROLLED SWITCH: Single device operation to on or off the electrical
device using Radio communication.
WIRELESS F.M. RECEIVER: - A complete FM radio set to tune frequency between 80-108MHz.(1386 16-57)
WIRELESS/CORDLESS FM MIC: - It will transmit your voice at FM frequency and it can be received
by any FM radio. (10-133 -)
WIRELESS RF ANTI-COLLISION TRAINS WITH AUTOBRAKING SYSTEM: The circuit will
activate the auto key controlled switch brakes when two trains are coming on the same track and the
distance between them is less than specified limit.
WIRELESS RF WEATHER MONITORING DEVICE: For Earth quake, Tsunami, or Flood with or
without voice processor. The circuit can be modified as Weather monitoring Radio station.
WIRELESS RF INDUSTRIAL FAULT MONITORING DEVICE: It detects the faults in any industrial
machine lik power failure, overload, overheat, over voltage at the distance using RF link as data
communication.
ROBOTIC-SIX LEG INSECT: The actual resemblance of moving legs robot. It turns path automatically
and can run in rough surfaces too. Looks like a KAAN KHAJURA. Change the path using IR sensor in
front.
ROBOTIC YES MASTER AUTO CAR. It always follow his master using IR sensor circuit to control.
ROBOTIC IR CAR: A robotic vehicle that is controlled remotely by IR transmitter using IR 38Khz
modules with data encoder and decoder ICs. It can go forward, reverse, left or right.
ROBOTIC AIR PROPELLED MOTOR BOAT: A DC motor operated boat operates on
propeller blade and the air pressure provides the power to run the boat. An RF remote control
unit can be used to provide direction on either side.
ROBOTIC HEART BEAT PULSE PLOTTER MACHINE: This will draw the pulses from heart using a
finger sensor and will put on paper with the help of solenoid coil assembly.
ROBOTIC AUTO BREAKING VEHICLE: A vehicle that makes autobrake when obstracle will arise in
front of it, or it will change the path on right side.
ROBOTIC DIGITAL LINE TRACER/FOLLOWER: A digital circuit with opto-couplers sense the path and
follow the black line only. The vehicle stops automatically if obstracle comes in front of it and start when it
is removed.
ROBOTIC METAL DETECTOR TO FIND MINES: A metal finding vehicle will stop and gives warning
(wireless or buzzer type) when it find metal on its path.
ROBOTIC ANTI-FALLING VEHICLE: A vehicle that sense the end of table and change the path
automatically. This makes the robot as anti-falling robot. It has two or more sensors at base level.
ROBOTIC OBJECT DETECTOR ON CONVEYOR BELT: It check the metal or high size objects/boxes
running on the belt. It stop the belt till it is being removed from it. It counts the no of selected objects and
send RF signal to counter on other end.
ROBOTIC OBJECT LIFTING JACK : The object lifting Jack works with the help of geared
motors and worm gear arrangement to lift the objects. The modified version can even lift car
using the same principle. The remote operation of this is also an option.
ROBOTIC MATERIAL HANDLING (X, Y, Z MOTION CONTROL): - A switch
controlled material handling mechanical assembly that can pick or place the goods in all three
axis using three gear motors with timer circuit to control.
ROBOTIC SOLAR SUN SEEKER: - It actually track the sun as per its position and move the
solar cell/water heating plates accordingly so as to get maximum power from sun light.
ROBOTIC ARM WITH GRIPPER: - A three-geared motor setup of robotic arm is an
interesting project under material handling. Six keys operation controls the whole setup of the
model. The remote operation can be done with IR or RF link.
ROBOTIC CAR WITH SENSORS: - This is a simple geared motorized vehicle with free
wheel at front will always take right turn when the Infrared sensors sense any obstacle in front.
An emergency brake can be applied if required.
ROBOTIC RADAR SYSTEM: - This robotic radar moves 180 degree carries an IR or light
sensor fires with an electromechanical Gun if finds some object.
ROBOTIC IR AUTO BRAKING: A simple auto braking in material handling robot that stops
automatically when the obstracle comes in between. It create a switch, induction or paddle
brake to apply to stop the vehicle.
ROBOTIC AMPHIBEAN CAR: The Air propelled or water propelled boat cum car that runs
on water and surface both. The RF modules can be placed to control the same remotely.
ROBOTIC CAR OPERATES ON MOBILE NETWORK: The DTMF based robot car
operated by any mobile to be placed on it. The vehicle can be remotely operated by another
mobile.
ROBOTIC JACK/ARM OPERATES ON MOBILE NETWORK: The DTMF based robot
operated by any mobile to be placed on it. The JACK OR ARM can be remotely operated by
another mobile.
ROBOTIC UNMANNED AUTOMATION FOR RAILWAY CROSSING GATE: It
automatically open and close the motorized gate. This is an unmanned railway crossing with
magnetic reed sensors at the rain track.
ROBOTIC RF LAND ROVER : A robotic vehicle that is controlled remotely by RF transmitter using RF
433 Mhz modules with data encoder and decoder ICs. It can go forward, reverse, left or right
PC BASED FUNCTION GENERATOR: - The software will generate
sine/square/triangular and saw tooth wave forms and the parallel port will support for
its D to A conversion of this to a connected CRO to see the desired wave form.
PC BASED DIGITAL CLOCK: - The software will generate the time running at
computer at the PC screen as well as a connected four digit 7-segment display.
PC BASED RELAY SWITCHING TO OPERATE MOTOR (2/3/4): - An AC/DC
motor speed can be changed by using the relay interface hardware through the parallel
port.
PC BASED MULTIMETER: - The value of R and C will display at PC as it accepts
the change of frequency of an oscillator.
NENETWOR
KING
PC BASED BIO-TELEMETRY FOR MEDICAL AIDED INFORMATION: It
check and plot the graph for pulse rate of heart on PC screen. The TELE or RF
transmission of pulse from patient is an added attraction.
PC BASED LIGHT, FAN CONTROL: - The PC will display and control the light
and fan control options through the parallel port.
PC BASED RELAY SWITCHING: - The four electrical appliances can be
controlled independently through the parallel port of the PC.
NENETWOR
KING
PC BASED MOBILE PHONE ACTIVATION FOR PC FILE: One can operate a
file handling or electrical appliance control using a landline/mobile phone to activate
the connected hardware interfaced with PC parallel port.
(moving in 360 degree) for IR/Metal/Light detection and find their radial direction (in
degree) with date & time. It senses the IR /Ultrasonic waves and display the angle and
time on which it is being detected by RADAR.
PC BASED AC/DC MOTOR SPEED CONTROL WITH IGBT DRIVES: - It can
control the desired speed of a connected motor through PC parallel port using PWM
technique.
NENETWOR
KING
PC BASED CAMERA ACTIVATION + AUTO SNAP CLICKING: - A digital
camera connected to a PC will automatically activated with the obstruction created in
the front of it and save the picture in PC instantly. Software in VB for ATM machine
example.
PC BASED 5 CHANNEL LOGIC ANALYZER: - A digital logic analyzer is an
instrument, which is similar to a CRO. The former can resolve voltages into two levels,
either a high (+5V) or a low (0V), and hence is suitable for analyzing digital circuits.
The latter can handle both analogue and digital inputs.
PC BASED SOUJUNIOR - A Wireless Programmable Control Unit: - It consists
of a receiver unit that receives signals or commands from humans on earth and
executes the instructions on the remote planet. It also has an on-board microcontroller,
which helps it to take, decisions on its own, in environments that are alien to human
kind.
PC BASED ANGLE MEASUREMENT TOOL (with Stepper Motor & IR Link):
- It can detect the desired angle upto 360 degree from the start position upto the
destination using IR transmitter and receiver link.
PC BASED DISTANCE MEASUREMENT ROBOT: - The IR based robotic trolley
with to and fro movement can travel in a straight pipe to measure the distance traveled
till the obstruction come.
NENETWOR
KING
PC BASED SMART CARD FOR MUSIC SHOP: - This software based project in
C allows specified discount to its regular customer if they insert their smart card in
hardware slot connected to the computer.
NENETWOR
KING
PC BASED WIRELESS OBJECT COUNTER FOR INDUSTRY: - This wireless
object counter count the number of items produced by a machine placed 50mts. far
from computer. One can control the power of machine remotely (RF transmitter and
receiver unit) when desired.
NENETWOR
KING
PC BASED RADIO FREQUENCY IDENTIFICATION TAGS(RFID): - The five
persons of a company are being identified by their RFID tags. The door will
automatically open whenever it identify their presence and register their attendance
with time and date in the computer.
NENETWOR
KING
PC BASED SECURITY ALARM TRANSMISSION: - This PC based security
system check the password for each entry and open the door for validity check. And
for internal security, it will give alarm indication for fire, power failure, intruder/
unauthorized entry and temperature sensing of air conditioning plant.
NENETWOR
KING
PC BASED MUSIC ON DEMAND AT YOUR MOBILE PHONE: - This unique
PC based communication project designed in VB software, enables a person to play its
own selective song when he dial his home landline/MOBILE phone number through its
mobile phone. It has selection mode to play, stop, previous and next song options.
PC BASED EYE DETECTION FOR MESSAGE READING: - The project reads
the blinking of eyes and decode the message for the paralytic patient who cannot
speak.
PC BASED TONGUE OPERATED MOUSE: The project is a Hardware setup i.e.
physical changes in ball type mouse with an IR sensors to be fixed in eye glasses to
control the left/right keys. The tongue will roll the mouse cursor in all directions.
NENETWOR
KING
PC BASED REMOTE VOTING SYSTEM THROUGH MOBILE: This is another
telephone based communication project allows its voter to vote at the landline voting
receiver connected to PC serial port will check the frequency and thus check the depth
of an area.
PC BASED WIRELESS REMOTE CAR :THAT MAKES THE MOVEMENT
THROUGH MOUSE CURSOR
PC BASED EARTH FOSSILE LOCATOR: It check the metal non metal , depth etc
of an area to find rare fossile.
NENETWOR
KING
PC BASED VOICE TO TEXT WITH SIMULTANEOUS LCD DISPLAY AT
PORT.: The project will convert voice to text on PC screen and simultaneously
display the same output at LCD screen on the hardware.
PC BASED EARTH QUAKE PROOF BUILDING: The centre of building can be
controlled motorized by a moving weight placed on the top of roof. The PC will sense
the move the weight accordingly.
NENETWOR
KING
PC BASED ARTIFICIAL SATELLITE FOR EARTHQUAKE/TSUNAMI
SENSING DEVICES: The model of artificial satellite to be placed between the
sensing area and computer right in the sky. The sensor Eaarth quake or water rise will
be sensed and it actuate the satellite to respons and retransmit the signals to base
station computer for its location and time. A five areas zone can be implemented in
this.
PC BASED GLOBE : It automatically find the country using a mechanical
arrangement using two stepper motors fitted on an actual Globe.
NENETWOR
KING
PC BASED INTERACTIVE VOICE RESPONSE SYSTEM (IVRS): The system
connected to land line/mobile will respond the user with actual voice to be listen at
transmitting end using PC. Software in VB or .net will allow the user to get interactive
voice responses by pressing keys from mobile phone.
NENETWOR
KING
PC BASED VIDEO ON DEMAND: One can demand the Video file to play on
request on phone using VB or .net software.
PC BASED SHOOTING GAME (LASER BASED):-A laser torch is to be focused
at the target. The sensors interfaced with PC will get activated and score will be
display at PC screen.
NENETWOR
KING
PC BASED VOICE OPERATED CAR: VB based software project that recognize
the voice from the PC microphone and operate the actual hardware car connected to it
(wired/wireless) for LEFT, RIGHT, GO, Stop functions with voice commands.
PC BASED OVERLOAD CONTROLLER:- This electrical based project control the
eight junction switch as it sense the overload at the outputs. It retains the load at four
VIP areas if load exceeds the limit and load shed the other four non VIP areas
automatically.
PC BASED SOLENOID VALVE OPERATED LIQUID STIRRER:- This is a
unique project in the category of Automation & Control to operated with PC. For the
1st solenoid valve control the flow of first liquid input and 2nd solenoid valve for
second liquid (both on the top) and a 3rd solenoid valve at the bottom for liquid out
control. In build stirrer mix both the liquids for desired time. The level in tank is also
indicated at PC screen.
PC BASED LATH MACHINE CONTROL:- A CNC machine control system to
operate two stepper motors in a desired mode to cut work a work piece in specific
shape and size.
PC BASED OVER HEAD WATER LEVEL IND. & CONTROL: - It indicate the
water level in four steps viz. , , , and full With motor control and buzzer
indication at full.
PC BASED FUZZY LOGIC SYSTEM: - Only software-based project to display the
graph pattern with different conditions given to PC to analyze fuzzy logic controls.
PC BASED SCREW/DRILL SYSTEM:- This two stepper motor controlled system
either use to screw with the moving bolt jack arrangement or it can be used to drill up
to desired depth at a specific space.
PC BASED TELEPHONE DIALLER:- The software enables the modem of your PC
running DOS or Windows operating system to take up the commands and execute
them to give desired output.
lights
WATER LEVEL INDICATOR: - The hardware interfaced with
8255 port will display the water level in the container with top level
alarm facility. The kit will display the digits of the liquid level.
TRAFFIC LIGHT CONTROL SYSTEM: - The hardware
interfaced with 8255 port will display the traffic light movements
for all four sights inclusive right turn using LEDs.
VOTING MACHINE: - The hardware interfaced with 8255 port
operated with four keys (one for each candidate) will support the
voting operation and display the total votes win by each candidate at
display of the kit.
AC/DC MOTOR SPEED CONTROL: - The hardware interfaced
with 8255 port will display and control the clock wise and anti clock
wise operation of a DC motor with three different speeds.
BALANCE: - The hardware interfaced with 8255 port will support
the connected spring balance and kit will display the object under
weigh.
FASTEST FINGER FIRST: - The hardware interface with 8255
port will support the five keys (four for fastest finger and one for
reset). The kit will display whose the first to press the key.
CAPACITANCE & RESISTANCE MEASUREMENT
METER: - The hardware interfaced with 8255 port will support the
oscillator and the kit will display the value of R or C under check.
TACHOMETER: - The hardware interfaced with 8255 port will
support the RPM counter to read the revolution of a motor in one
minute and display at kit.
STEPPER MOTOR AXIS CONTROL: - The hardware
interfaced with 8255 port will support the speed and direction of a
stepper motor connected to it.
VISITOR COUNTER: - The hardware interfaced with 8255 port
will support the two separate doors each for entry and exit and the
kit will display the number of people inside the hall.
ELECTRICAL APPLIANCES CONTROL: - The hardware
interfaced with 8255 port will operate four electrical appliances. The
desired switching of each appliance control can be done separately
by the P kit.
SCHOOL TIMER/SCHOOL BELL SYSTEM: - The hardware
interfaced with 8255 port will display the periods max. 9 with ten
seconds delay for buzzer operations after each period. The time
duration can be varied as per desired time in minutes.
IC TESTER: It is testing device based on 8085 P kit. This device
will test the 14 pins IC of commonly used logic gates e.g. 7400
(Nand), 7408 (And), 7432 (Or), 7486 (X'Or'), 7404 (Hex inverter),
7407 (Buffer) etc.
ELECTRONIC LOCK: - The keys in the range 0 to 9 are used to
store the key code as well as to enter the code for opening the lock.
The maximum five-digit number can be stored in the memory.
MICROPROCESSOR BASED REVERSIBLE DC MOTOR
CONTROL: - The project is capable of controlling DC motor
speed as well as change its direction interfaced with 8255 port.
IGBT BASED INVERTER: 100 watts inverter can be made using IGBT driver circuit for fast and
energy efficient switching.
AUTOMATIC EMERGENCY TUBE LIGHT: - An inbuilt circuit for 20W tube light to
glow in emergency. Required mini 6V bike battery. (10-118) (09/01/100)
DIGITAL FAN REGULATOR: - This eight digit fan regulator display the speed at FND display and is
more reliable than conventional rotary regulator. 16-103
ELECTRONIC THERMOSTAT/ TEMP-CONTROLLER: - This simple thermostat will stabilize
temperatures to within a fraction of one degree Centigrade.
AUTOMATIC SIGNALLY AND CONTROL SYSTEM FOR TRAIN MODEL: - This helps for efficient
movement of train without colliding using six LED indicator lights.
AUTOMATIC UNMANNED RAILWAY CROSSING CONTROL: It automatically close the railway gate
when train is coming from one side and close it automatically when it passes through it.
ELECTRONIC MOTOR STARTER/ CONTROLLER: - An electronic starter to 'ON' and 'OFF' the
Reference: http://seminarprojects.com/Thread-electronics-projects#ixzz1wbZJQnMZ
Reference: http://seminarprojects.com/Thread-electronics-projects#ixzz1wbZkl6Qk
1.
2.
3.
4.
5.
6.
7.
Nuclear Radiation Detection and Tracking through Motes for Preventing from Nuclear Terrorism project
8.
9.
RF based servo and DC Motor Controller system for spy plane Project
10.
11.
12.
13.
14.
15.
16.
Automation Fan and Light Control For Industrial Appliances ECE Project
17.
18.
Rate Allocation and Network Lifetime problems For Wireless Sensor Networks
19.
20.
21.
22.
23.
24.
25.
Project on A Data-Centric Multi-Hop MAC Protocol for Underwater Acoustic Sensor Networks
26.
27.
28.
29.
30.
31.
32.
33.
34.
35.
36.
37.
38.
39.
40.
41.
42.
43.
44.
45.
46.
47.
48.
49.
50.
51.
52.
53.
54.
55.
56.
57.
58.
59.
60.
61.
62.
63.
64.
Project on Online Clock Skew Scheme for Asynchronous Wave-Pipelined Circuits Using FPGA
65.
66.
67.
68.
69.
Network Security Protocol with Cryptography and RFID System ECE Project
70.
71.
72.
73.
Moving Object Detection Based On Kirsch Operator Combined With Optical Flow Project
74.
75.
76.
77.
78.
79.
80.
81.
82.
83.
84.
85.
86.
87.
88.
89.
90.
91.
92.
93.
94.
95.
96.
97.
98.
99.
100.
101.
102.
103.
104.
105.
106.
107.
PLC Controlled In D1 Charging Conveyor For Blast Furnace In Vizag Steel Plant
108.
109.
110.
111.
112.
113.
114.
115.
Scada Based Intelligent Multi Parameter Monitoring System With Lcd Display
116.
117.
118.
119.
120.
121.
122.
123.
124.
125.
126.
127.
128.
129.
130.
131.
132.
133.
134.
135.
136.
137.
138.
139.
140.
141.
142.
143.
144.
145.
146.
147.
148.
149.
150.
151.
152.
IMPLEMENTATION OF OBSTACLE AVOIDANCE AND IR CONTROL FUNCTIONS FOR OMNI DIRECTIONAL MOBILE ROBOT
153.
Solar Tracking System For Optimal Power Generation Embedded System Project
154.
155.
156.
157.
158.
A Low Cost Microcontroller Implementation of Neural Network Based Hurdle Avoidance Controller for a Car-Like Robot
159.
160.
161.
162.
163.
164.
165.
166.
167.
168.
SECURITY ISSUES AND COUNTERMEASURES FOR THE CONGREGATE NETWORKS LIKE VOIP
169.
170.
Design Of 7 TAP FIR Filter Using HDL And Analysis Using MATLAB
171.
172.
173.
174.
175.
176.
177.
178.
179.
180.
181.
182.
Optical Data Transfer between Computer and Micro controller via Fiber optic
183.
184.
185.
Multi Sensor Strategies to Assist Blind People using A Clear Path Indicator
186.
Robust And Efficient Password Authenticated Key Agreement Using Smart Cards
187.
188.
Real time Pedestrian Detection and Tracking at Night Time for Driver Assistance System
189.
190.
New Technology For HVDC Start-Up and Operation Using VSC-HVDC System
191.
192.
193.
COMBINED ECONOMIC AND EMISSION DISPATCH USING GENETIC ALGORITHM & LAMBDA
194.
195.
196.
197.
198.
199.
200.
DESIGN, MODELING AND SIMULATION OF FUZZY CONTROLLED SVC FOR 750Km (/8) TRANSMISSION LINE
201.
202.
203.
New Technology for High Voltage Direct current using VSC-HVDC System
204.
205.
Online Monitoring system of Temperature of Conductors and Fittings Based On GSM SMS and Zigbee
206.
207.
208.
209.
210.
211.
212.
213.
214.
215.
216.
217.
218.
219.
220.
221.
222.
223.
224.
225.
226.
227.
GRASPING LATTITUDE AND LONGITUDE POSITION INTERFCAING USING GLOBAL POSITION SYSTEM
228.
229.
230.
231.
232.
233.
234.
235.
236.
237.
238.
239.
240.
241.
242.
243.
244.
245.
246.
247.
248.
249.
250.
251.
Access Control System Using I-Button With Secret Lock System Abstract
252.
253.
254.
255.
256.
257.
258.
259.
260.
261.
262.
263.
264.
265.
266.
267.
268.
269.
WIRELESS AC/DC DEVICE CONTROL FOR APPLIANCES USING REMOTE CONTROL ABSTRACT
270.
271.
272.
273.
274.
275.
276.
277.
278.
279.
PC Based Data Acquisition System Using SPI and I2C protocol Abstract
280.
281.
Super Intelligent Robot Using Smoke Sensor And Light Projects Abstract.
282.
283.
284.
285.
286.
287.
288.
289.
290.
291.