control point curve tool. Buat dua buah curve dengan tool control point curve. Then, in Grasshopper, make two Curve parametric tools. Just double click on an empty area and type Curve. kemudian, di grasshopper buat dua curve parametric tool. Double click pada area kosong dan ketikkan Curve. Right click on the Curve tools and choose set one curve. Pick the previously made curves one by one. the selected curve will in grasshopper will turn into red, and the curve tool in grasshopper will turn into gray. Klik kanan pada tool curve dan pilih set one curve. pilih curve yang telah dibuat pada grasshopper satu persatu. curve yang terpilih akan berubah warna.
Make unit Z tool, then connect it to Gravity
input of catenary tool. Buat unit Z tool, kemudian hubungkan dengan input gravity pada tool catenary.
Make rebuild curve tool and two number
slider (34) with integer rounding. Connect as shown in picture 8. Buat tool rebuild curve dan dua number slider (34). Hubungkan seperti pada gambar. Make Loft tool and connect its curve input to curve output at Rebuild curve tool. Buat tool Loft dan hubungkan input curve nya dengan output curve pada tool Rebuild curve.
Then make two Divide Curve tools and two
number slider (24) with integer rounding. connect the tools as shown in picture 5. Kemudian buat dua tool divide curve dan dua number slider 24. Hubungkan seperti pada gambar.
10 Make divide domain2 tool and two number
Make catenary tools and a number slider
with integer rounding. Connect input A and input B to both Divide Curve Tools. Then connect the number slider to Length input. Buat catenary tool dan number slider. Hubungkan input A dan B ke kedua Divide curve. kemudian hubungkan number slider ke input Length.
11 Make deconsturct brep tool and connect it
slider, connect as shown in picture 10. Then
make Isotrim tool and connect it to Loft tool and Divide domain2. Buat tool divide domain2 tool dan dua number (34) hubungkan seperti pada gambar. Kemudian buat tool Isotrim dan hubungkan dengan tool Loft dan Divide domain.
12 Make average tool and Line tool from Curve
tab and connect them as shown in picture 12.
Buat tool average dan Line dari tab Curve dan hubungkan seperti gambar.
13 Connect Line tool with Exowireframe tool.
Make four number slider (0.5, 0.5, 2.000, 3)
with it and connect as shown in picture 13. Hubungkan tool Line dan Exowireframe. Buat empat number slider (0.5, 0.5, 2.000, 3) dan hubungkan seperti gambar. 14 Make Boolean toggle tool and connect it to
Exowireframe. Double click the Boolean
toggle tool to make it True. Buat tool Boolean Toggle dan hubungkan dengan Exowireframe seperti gambar. Double klik pada tool Boolean toggle untuk merubahnya menjadi True.
15 Right click on Exowireframe tool and
choose Bake to create the model in
Rhinoceros. Klik kanan pada tool Exowireframe dan pilih bake untuk membuat modelnya pada Rhinoceros.
to surface output of Isotrim tool.
Buat tool deconstruct brep dan hubungkan dengan output surface pada tool Isotrim.