Professional Documents
Culture Documents
T
his appliance is not intended for commercial use.
Never drop or insert any object into an opening.
Do not use the appliance with damaged or broken attachment combs or
with any teeth missing from the blades, as injury may occur.
Do not place on any surface while it is operating.
Do not use outdoors or operate where aerosol (spray) products are
being used or where oxygen is being administered.
Keep the cord away from heated surfaces
Do not use the appliance if it is damaged. In the event of damage,
discontinue use immediately and contact your dealer for instructions
on returning it for examination or exchange. If the supply cord is
damaged, it must be replaced by the manufacturer, its service agent or
similarly qualified person in order to avoid a hazard.
Never twist or pull on the trimmer cord.
After use do not wrap the cord around the appliance as in time this
may cause the cord to fracture. Coil cord loosely by the side of the
appliance in storage.
Always ensure that the voltage to be used corresponds to the voltage
marked on the unit.
For additional protection, the installation of a residual current
device (RCD) with a rated operating current not exceeding 30mA is
advisable in the electrical current circuit supplying the bathroom. Ask
your installer for advice.
Lithium Pro
Face and Body Trimmer
The VS For Men Lithium Pro is a professional grade rechargeable trimmer
with electro-chemically formed precision blades with an ultra sharp
cutting angle for smooth effortless cutting. Lithium-ion technology
gives sustained power performance for reliable cordless use, even at
low charge levels. Lightweight for easy handling, it can be used with
a mains power cord or cordless for total convenience and control and
with five professional interchangeable heads for all over trimming and
grooming giving you get a perfect result every time.
FEATURES
Cord & cordless trimmer with 5 interchangeable attachment heads.
Precision Trimmer (32mm) with Electro-chemically formed precision
blades technology for extreme precision and sharpness, with a
7-position comb guide (2-14mm).
Stubble comb guide (lengths 0.5-3mm).
Body Groomer (0.5mm) comb guide.
Detail Trimmer for creating lines and effects in the hair.
Nose & Ear Trimmer for the safe and easy removal of unwanted hair.
Foil Shaver for a clean, smooth finish.
Oil.
Charging and storage stand.
Cleaning brush.
3 year warranty.
Mains Operation
Ensure the appliance is switched off.
Connect the adaptor to the base of the appliance (disconnect and reroute the cord from the stand) and plug the adaptor into a suitable
mains socket.
The blue LED charging light will flash when the adaptor is correctly
inserted into the appliance and connected to the mains.
The appliance is now ready for use.
Cordless Operation
Ensure appliance is charged for a minimum of 30 minutes. The blue
LED charging light will flash when the adaptor is correctly inserted
into the appliance and connected to the mains.
Once the appliance is fully charged the blue LED charging light
will stop flashing but remain on. Remove the mains cord from the
appliance, turn on and use as required.
Preserving the batteries
In order to maintain the optimum capacity of the Lithium-ion
rechargeable batteries, the trimmer should be fully discharged and
then recharged for 2 hours every 3 months.
For optimum performance, we recommend you charge the unit for at
least 30 minutes before using the appliance each time. This applies to
whether you are using it with mains or cordless power.
Preparation for Use
Always inspect the appliance before use for noticeable signs of
damage. Do not use if damaged.
Ensure the heads are free from hair and debris.
Ensure the appliance is sufficiently charged.
Use on clean, dry hair that has been combed until tangle-free.
Comb Guides
fig.1
To remove the body groomer comb guide push the comb guide up
To remove the body groomer attachment place your thumb on the
back of the attachment and push up.
Attachment
The taper control with 6-position switch enables
super fine cut adjustment for precision trimming.
Attach taper control by sliding the head onto the
tracks at the rear of the handle.
To increase the length by 0.5mm to a cutting
length of 1mm, slide the switch across so the line
is lined up with the desired length ie 1mm, 1.5mm, 2mm, 2.5mm and
3.0mm.
To increase the length by a further 0.5mm to a cutting length of
1.5mm, slide the switch down so both 1 and 2 are visible above the
taper control switch.
Trimming
Precision Trimmer
Using the Precision Trimmer with 7-position comb guide or taper
comb guide
Attach the 7-position comb guides and select the required length
(2-14mm).
If you require more than one cutting length, start with the longest
length first.
Switch the trimmer on.
Hold the trimmer with the teeth of the trimmer pointing upwards,
yet flat against the skin.
Move the trimmer upwards and outward through the hair, against
the direction of hair growth.
The trimmer will work most efficiently when cutting through hair at
its own speed.
Never switch the appliance off whilst in the hair.
Note: The Precision Trimmer can be used without any comb guides
and will cut roughly to a length of 0.5mm.
MULTI VOLTAGE
This appliance has a multi voltage feature for worldwide use. The
voltage automatically converts for ease of use from 100v - 240v.
This appliance has an automatic internal converter which will
automatically convert the voltage without the need of a switch.
A suitable plug adaptor will be required, please refer to the chart
below.
Plug adaptor
required
Voltage and
plug adaptors
Country
Voltage
setting
British plug:
240V
240V
European plug:
240V
240V
Australian and
New Zealand
plug: 240V
240V
American
plugs: 120V
120V
BATTERY DISPOSAL
The appliance contains Li-ion battery. To protect the environment,
the appliance must be disposed of safely at the end of its useful life.
Please take the appliance to a recycling centre, where the internal
rechargeable battery should be removed by a professional and recycled
separately.