If the inverter start mode is set to start or stop through RS485 communication, the COM OVERTIME value should be set to 20 seconds. If the inverter does not receive data from the controller within this set time, it will alarm and stop.
If the inverter start mode is set to start or stop through RS485 communication, the COM OVERTIME value should be set to 20 seconds. If the inverter does not receive data from the controller within this set time, it will alarm and stop.
If the inverter start mode is set to start or stop through RS485 communication, the COM OVERTIME value should be set to 20 seconds. If the inverter does not receive data from the controller within this set time, it will alarm and stop.
COM ON-OFF (start or stop inverter through RS485), please set the value of VSD COM OVERTIME to be 20 seconds (recommended)The inverter will alarm and stop if it doesn't receive the data from the controller within this set time;
485 485485+
Note: If the inverter start mode is set as
COM ON-OFF (start or stop inverter through RS485), please set the value of VSD COM OVERTIME to be 20 seconds (recommended)The inverter will alarm and stop if it doesn't receive the data from the controller within this set time;
485 485485+ 485 485485+
Note: If the inverter start mode is set as
COM ON-OFF (start or stop inverter through RS485), please set the value of VSD COM OVERTIME to be 20 seconds (recommended)The inverter will alarm and stop if it doesn't receive the data from the controller within this set time;