Professional Documents
Culture Documents
Demonstration
This demonstration is designed to find the value of the Faraday constant the amount of electric charge carried by one mole of
electrons - from the electrolysis of aqueous copper(II) sulfate solution, using weighed copper electrodes.
Lesson organisation
This is a relatively straightforward demonstration to set up and carry out, but there is not much to see while it is taking place.
This provides an ideal opportunity to ask students to prepare a suitable results sheet and to explain how the masses of the
electrodes, the current passed and the time elapsed can be used to calculate a value for the Faraday constant. The experiment
will take around 40 minutes.
Students can be told that the calculations are relevant for industrial applications of electrolysis, for example in the extraction of
elements such as sodium and chlorine, and in the electroplating industry.
Apparatus
Chemicals
Eye protection
Access to a fume cupboard
Beaker (250 cm3)
Beaker (100 or 150 cm3)
DC power pack
Connecting leads, including two fitted
with crocodile clips, 3
Ammeter, preferably digital and a
demonstration model
Rheostat
Switch
Stop clock
Balance (weighing to +/-0.01 g)
Hot-air blower, such as a hair drier
Emery paper
Paper towels or tissues
Procedure
a Clean the copper electrodes with emery paper, rinse under the tap and dry thoroughly using paper towels and a hot-air blower.
b Mark the electrodes as + or at one end, and weigh them separately. Record the masses.
c Set up the circuit as shown in the diagram, clamping the electrodes to the rim of the beaker using the crocodile clips. Make
sure the electrodes do not touch.
d Fill the beaker with copper(II) sulfate solution to just below the crocodile clips.
e Start the stop clock and switch on the current, setting the rheostat so that a current of 0.50 A passes through the solution.
f The current alters slightly throughout the electrolysis, so it is important to make continual adjustments to the rheostat to keep
the current constant.
g After about 30 min switch off the current and stop the clock.
h Remove the electrodes from the electrolyte, wash them carefully under running water, then rinse them in a beaker of
propanone in a fume cupboard. Finally dry them by allowing the propanone to evaporate in a well-ventilated laboratory, and
away from any naked flames.
i Re-weigh the dry electrodes.
The results should be entered in a table, for example:
Use the student worksheet available with this resource to work through the process of calculating the Faraday constant.
Students could also be asked to use the official value of 96500 Coulombs per mole to calculate the percentage error.
Answers to student questions
1-4 The answers are based on your experimental observations within the experiment above.
5 The calculated value for the Faraday constant should be correct to within about 10%. The major error comes from the value for
the current, which is hard to keep constant to two significant figures.
6 The reaction at the cathode is: Cu2+(aq) + 2e Cu(s)
7 The concentration of Cu2+ ions in solution remains constant. In a given time as many of these ions are produced at the anode
as are being removed at the cathode.
8 The coating of solid copper on the cathode tends to be spongy and some can be lost when electrode is washed or dried.
Some may also have fallen off the cathode during electrolysis. Thus the mass gain of the cathode is an unreliable measure of
the quantity of copper actually deposited there.
Health & Safety checked, September 2014
Credits
This Practical Chemistry resource was developed by the Nuffield Foundation and the Royal Society of Chemistry.