You are on page 1of 11

Correct

1)

To cause water or other liquid to percolate through something, so as to dissolve out soluble constituents.

A. A. Aeration
B. B. Aquifer
C. C. Sand filter
D. D. Leach (Your Answer)
Correct
2)

These are fixtures that are installed in janitors closets and building maintenance areas for use by the building maintenance
personnel.

A.
B.
C.
D.
Correct
3)

A. Broom Closet
B. Service Sink (Your Answer)
C. Master Control Panel
D. Wash Basin

The septic tank has a total volume of 6.48 cum, what should be the required volume of its leaching
chamber?

A. A. 2.16 cum (Your Answer)


B. C. 3.24 cum
C. B. 1.62 cum
D. D. 2.59 cum
Correct
4)

The reference in measuring the depth of a trap seal of the trap:

A.
B.
C.
D.
Correct
5)

A. Crown weir to bottom dip


C. Inlet to outlet
B. Bottom dip to top dip
D. Crown weir to top dip (Your Answer)

The quality of Galvanized Iron pipes are rated by:

A. A. class-steel
B. B. schedule (Your Answer)
C. C. mm.
D. D. Gauge
Correct
6)

The minimum soil pipe size for a water closet:

A. A. 3 diameter (Your Answer)


B. B. 4 diameter
C. C. 2 diameter

D. D. 6 diameter
Correct
7)

The minimum distance (in meters) of well from a septic tank

A. A. 15 (Your Answer)
B. B. 10
C. C. 25
D. D. 20
Correct
8)

The length of a pipeline measured along the center lone of the pipe and pipe fittings.

A. A. Roughing-in
B. B. Nominal Diameter
C. C. Developed length (Your Answer)
D. D. Branch Interval
Incorrect
9)

Sediment that settles out of sewage, forming a semi-solid mass on the bottom of a septic tank

A. A. Sludge (Correct Answer)


B. B. Effluent (Your Answer)
C. C. Scum
D. D. Leeching Chamber
Correct
10)

Prevents water hammer:

A.
B.
C.
D.
Correct
11)

A. water meter seal


B. float valve
C. check valve
D. air chamber (Your Answer)

One of the first steps in the selection of a suitable water supply source is:

A. A. (water) potability (Your Answer)


B. B. topography
C. C. budgetary cost
D. D. (water) demand
Correct
12)

Minimum fixture drains size for Water Closets.

A. A. 1.5
B. B. 2
C. C. 3 (Your Answer)

D. D. 4
Correct
13)

Location of cleanouts should be place at every ________ run of horizontal soil or waste piping.

A. A. 25m
B. B. 10m
C. C. 20m
D. D. 15m (Your Answer)
Correct
14)

Liquid sewage that has been treated in a septic tank or sewage treatment plant

A. A. Sludge
B. B. Scum
C. C. Effluent (Your Answer)
D. D. Waste water
Incorrect
15)

In N. P. C. P. it is the lowest portion of the interior part of any pipe or conduit that is not vertical

A. A. Indirect
B. B. culvert (Your Answer)
C. C. Invert (Correct Answer)
D. D. inverted
Correct
16)

How many gallons do an average daily consumption of a Bathtub?

A.
B.
C.
D.
Correct
17)

A. 5 gallons
B. 30 gallons (Your Answer)
C. 40 gallons
D. 100 gallons

Fluoride as additive in water supply is a chemical for:

A. A. purifier-chlorine
B. B. coagulant
C. C. disinfectant
D. D. dental (Your Answer)
Correct
18)

faucet fitted with nozzle curving downward used as a draw-off tap:

A. A. firehouse
B. C. lavatory faucet (Your Answer)
C. B. hose bibb

D. D. garden hose
Correct
19)

A rigid type of pipe known to have a good chemical resistance, excellent impact strength, especially at low temperatures and
maintains rigidity at high temperatures. (black / gray pipe)

A. A. cPVC
B. B. ABS (Your Answer)
C. C. ACETAL
D. D. PP
Correct
20)

A pipe fitting to change in one single direction (course) the following of water:

A.
B.
C.
D.
Correct
21)

A. tee
B. cross tee
C. wye
D. elbow (Your Answer)

A flexible type pipe that is excellent in chemical and crush resistance has impact strength and flexibility and good low
temperature performance. (black-bluish pipe)

A. A. uPVC
B. B. Copper Tubing
C. C. Polyethylene (Your Answer)
D. D. Polybuthylene
Correct
22)

A flexible type of pipe known to have the only flexible plastic tubing suitable for use with hot and color water pressure system.
And it also known as an excellent chemical resistance to acids and alkalis but is not suited for fuel oil, gasoline or kerosene
distribution system. (blue or gray pipe)

A.
B.
C.
D.
Correct
23)

A. Polyethylene
B. Polybutylene (Your Answer)
C. Polyvinyl Chloride
D. uPVC

A flange that closed the end of a pipe. There is no opening for the passage of water.

A. A. Cap
B. B. Plug
C. C. Blind Flange (Your Answer)
D. D. Blank Flange
Correct
24)

A device for regulating the supply of water in a flush tank by means of hallow floating ball which by its rise or fall shuts or opens
a supply valve.

A. A. Ball Cock (Your Answer)

B. B. Compression Cock
C. C. Key Cock
D. D. Self-closing Cock
Correct
25)

A cast iron pipe in which the carbon is reformed by magnesium inoculation, resulting in a material having high strength without
otherwise changing its basic properties. Good corrosion resistance makes this type of pipe especially useful in underground
installations.

A. A. Acid Resistance Cast Iron Pipe


B. B. Galvanize Steel Pipes
C. C. Galvanize Wrought Iron Pipe
D. D. Ductile Iron Pipe (Your Answer)
Correct
26)

A 180 degree bend in a pipe.

A.
B.
C.
D.
Correct
27)

A. Elbow
B. Return Bend (Your Answer)
C. Drop Elbow
D. Wye

86. A pit or reservoir serving as a drain or receptacle for water or other liquids.

A. A. Building Sewer
B. B. Septic Tank
C. C. Sump (Your Answer)
D. D. Cistern
Correct
28)

69. A Piece of pipe lesser than 12 length / threaded on both ends.

A.
B.
C.
D.
Correct
29)

A. Bushing
B. Air Chamber
C. Nipple (Your Answer)
D. Coupling

64. A device installed in piping to prevent the reverse flow of storm or sewage into the drainage system ot their branches.

A. A. Check valve
B. B. Backwater valve (Your Answer)
C. C. Downspout
D. D. Catch Basin
Incorrect
30)

61. Minimum fixture drains size for a Bathtub

A.
B.
C.
D.
Correct
31)

A. 1.5 (Correct Answer)


B. 2
C. 3 (Your Answer)
D. 4

59. Water from laundries, wash basins, sinks, shower, and bathtub.

A. A. Soft Water
B. B. Grey Water (Your Answer)
C. C. Black Water
D. D. Storm Water
Correct
32)

15.

A.
B.
C.
D.
Correct
33)

In the N. P. C. P. it is a metallic sleeve caulked or joined to an opening in a piping into which a


plug is screwed that can be removed for cleaning the interior of the pipe.

A. Caulking
B. Oakum
c. Ferrule (Your Answer)
D. Lead

15. In N. P. C. P., a tank located above or integral with water closet, urinal or similar fixtures for
flushing or removing excrements in the fixture

A. A. discharge tank
B. C. flushometer tank
C. B. flush tank (Your Answer)
D. D. water tank
Correct
34)

15. In N. P. C. P. it is the law of the plumbing practice in the Philippines.

A.
B.
C.
D.
Correct
35)

A. R.A. No. 1379


B. R.A. No. 1278
C. R.A No. 1378 (Your Answer)
D. P. D. No. 1378

15. In N. P. C. P. it is a device, which discharges a predetermined quantity of water into fixtures for
flushing purposes and is activated by direct water pressure.

A. A. globe valve
B. C. gate valve
C. B. flush valve
D. D. flushometer valve (Your Answer)
Correct

36)

15. In N. P. C. P. is the top edge of a receptacle from where water overflows

A.
B.
C.
D.
Correct
37)

A. Flooded area
C. Flooded
B. Flood level
D. Flood level rim (Your Answer)

15. In N. P. C. P. individual vent is pipe installed to vent a fixture trap & which connects with the
vent system above the fixture served or terminates in the open air. A term I. P. S. means
_______________

A. A. Individual pipe size


B. B. International pipe size
C. B. Iron pipe size (Your Answer)
D. D. Industrial pipe size
Correct
38)

15. In N. P. C. P. a pipe connected from building gutter to the downspout or conductor.

A.
B.
C.
D.
Correct
39)

A. guide pipe
C. storm water pipe
B. leader (Your Answer)
D. vertical pipe

15. Common source of potable water in some rural areas

A. A. surface water
B. C. rain water
C. B. ground water (Your Answer)
D. D. all of the above
Correct
40)

15. Assuming the waste pipe of a fixture is 50 mm, what should be the size of its vent pipe?

A.
B.
C.
D.
Correct
41)

A. 32 mm (Your Answer)
B. 25 mm
C. 38 mm
D. 50 mm

. Theaters or movie houses water requirement is determined or estimated at 5 gallons of water per day
per

A. A. Total numbers of moviegoers a day


B. C. Floor area space of auditorium
C. B. Total number of auditorium seat (Your Answer)
D. D. Box-office record

Correct
42)

. The part of a vent line which connects directly with an individual trap underneath or behind the
fixture and extends to the branch or main pipe at and point higher than the fixture trap:

A.
B.
C.
D.
Correct
43)

A. blow-off pipe
B. vent thru roof
C. unit vent
D. back vent (Your Answer)

. The clear vertical distance between the spout of a faucet or other supply pipe and the flood level of a receptacle.

A. A. Air Chamber
B. B. Trap
C. C. Vent Stack
D. D. Air Gap (Your Answer)
Correct
44)

. An outlet, pipe, or receptacle for excess liquid.

A.
B.
C.
D.
Correct
45)

A. Backflow
B. Overflow (Your Answer)
C. Back Spill
D. Over spill

. A valve that supplies a fixed quantity of water to fixtures for flushing purposes when actuated by direct water pressure.

A. A. Globe Valve
B. B. Flush Valve Assembly
C. C. Mixing Valve
D. D. Flushometer Valve (Your Answer)
Correct
46)

. A type of private sewage disposal that has a vault constructed of concrete for the collection or raw sewage and a wooden shelter.

A.
B.
C.
D.
Correct
47)

A. Cesspool
B. Privy (Your Answer)
C. Latrine
D. Septic Tank

. A coupling device for connecting 2 pipes neither of which can be turned, consisting of two internally threaded end piece which
are tightened around the pipes ends to be joined, and an externally threaded center piece, which draws the two end pieces together
as it is rotated.

A. A. Reducer
B. B. Union (Your Answer)
C. C. Nipple

D. D. Coupling

1)

To cause water or other liquid to percolate through something, so as to dissolve out soluble
constituents.

2)

These are fixtures that are installed in janitors closets and building maintenance areas for use
by the building maintenance personnel.

3)

The septic tank has a total volume of 6.48 cum, what should be the required volume of its
leaching chamber?

4)

The reference in measuring the depth of a trap seal of the trap:

5)

The quality of Galvanized Iron pipes are rated by:

6)

The minimum soil pipe size for a water closet:

7)

The minimum distance (in meters) of well from a septic tank

8)

The length of a pipeline measured along the center lone of the pipe and pipe fittings.

9)

Sediment that settles out of sewage, forming a semi-solid mass on the bottom of a septic
tank

10)

Prevents water hammer:

11)

One of the first steps in the selection of a suitable water supply source is:

12)

Minimum fixture drains size for Water Closets.

13)

Location of cleanouts should be place at every ________ run of horizontal soil or waste
piping.

14)

Liquid sewage that has been treated in a septic tank or sewage treatment plant

15)

In N. P. C. P. it is the lowest portion of the interior part of any pipe or conduit that is not
vertical

16)

How many gallons do an average daily consumption of a Bathtub?

17)

Fluoride as additive in water supply is a chemical for:

18)

faucet fitted with nozzle curving downward used as a draw-off tap:

19)

A rigid type of pipe known to have a good chemical resistance, excellent impact strength,
especially at low temperatures and maintains rigidity at high temperatures. (black / gray
pipe)

20)

A pipe fitting to change in one single direction (course) the following of water:

21)

A flexible type pipe that is excellent in chemical and crush resistance has impact strength
and flexibility and good low temperature performance. (black-bluish pipe)

22)

A flexible type of pipe known to have the only flexible plastic tubing suitable for use with hot
and color water pressure system. And it also known as an excellent chemical resistance to
acids and alkalis but is not suited for fuel oil, gasoline or kerosene distribution system. (blue
or gray pipe)

23)

A flange that closed the end of a pipe. There is no opening for the passage of water.

24)

A device for regulating the supply of water in a flush tank by means of hallow floating ball
which by its rise or fall shuts or opens a supply valve.

25)

A cast iron pipe in which the carbon is reformed by magnesium inoculation, resulting in a
material having high strength without otherwise changing its basic properties. Good
corrosion resistance makes this type of pipe especially useful in underground installations.

26)

A 180 degree bend in a pipe.

27)

86. A pit or reservoir serving as a drain or receptacle for water or other liquids.

28)

69. A Piece of pipe lesser than 12 length / threaded on both ends.

29)

64. A device installed in piping to prevent the reverse flow of storm or sewage into the
drainage system ot their branches.

30)

61. Minimum fixture drains size for a Bathtub

31)

59. Water from laundries, wash basins, sinks, shower, and bathtub.

32)

15.

33)

15.

34)

15.

35)

15.

36)

15.

In the N. P. C. P. it is a metallic sleeve caulked or joined to an opening in a piping


into which a plug is screwed that can be removed for cleaning the interior of the pipe.
In N. P. C. P., a tank located above or integral with water closet, urinal or similar
fixtures for flushing or removing excrements in the fixture
In N. P. C. P. it is the law of the plumbing practice in the Philippines.
In N. P. C. P. it is a device, which discharges a predetermined quantity of water into
fixtures for flushing purposes and is activated by direct water pressure.
In N. P. C. P. is the top edge of a receptacle from where water overflows

37)

15.

In N. P. C. P. individual vent is pipe installed to vent a fixture trap & which connects
with the vent system above the fixture served or terminates in the open air. A term I. P.
S. means _______________

38)

15.

In N. P. C. P. a pipe connected from building gutter to the downspout or conductor.

39)

15.

Common source of potable water in some rural areas

40)

15.

Assuming the waste pipe of a fixture is 50 mm, what should be the size of its vent pipe?

41)

. Theaters or movie houses water requirement is determined or estimated at 5 gallons of


water per day per

42)

. The part of a vent line which connects directly with an individual trap underneath or behind
the fixture and extends to the branch or main pipe at and point higher than the fixture
trap:

43)

. The clear vertical distance between the spout of a faucet or other supply pipe and the flood
level of a receptacle.

44)

. An outlet, pipe, or receptacle for excess liquid.

45)

. A valve that supplies a fixed quantity of water to fixtures for flushing purposes when
actuated by direct water pressure.

46)

. A type of private sewage disposal that has a vault constructed of concrete for the collection
or raw sewage and a wooden shelter.

47)

. A coupling device for connecting 2 pipes neither of which can be turned, consisting of two
internally threaded end piece which are tightened around the pipes ends to be joined, and an
externally threaded center piece, which draws the two end pieces together as it is rotated.

You might also like