You are on page 1of 54

Analysis Dictionary

A comprehensive dictionary of vibration analysis terms you may run across in your trade.

Acceleration
The time rate of change of velocity, usually measured in Gs in the English system of
measurements, and in meters per second per second (m/s2) in the SI system. It is interesting
to note that the G is not actually a unit of acceleration, but is the magnitude of the
acceleration due to gravity at the earths surface. This causes some undue complexity in
converting parameters between acceleration, velocity, and displacement. The value of G
amounts to 32.2 feet per second per second.

Accelerometer
A transducer whose electrical output is directly proportional to acceleration over a fairly
wide frequency range. The high-frequency response of an accelerometer is limited by its
inevitable internal mechanical resonance. Most common accelerometers respond down to
one or two hertz, and some special accelerometers respond all the way down to zero
frequency, sometimes called "D. C. response".

Algorithm
An algorithm is simply a specific procedure for solving a mathematical problem. In digital
computers, algorithms for different purposes are stored and called into play when needed
for certain operations. The procedure for calculating the FFT spectrum is an algorithm.

Aliasing
To digitize an analog signal for processing in digital instruments such as FFT analyzers, it
first must be periodically sampled, and the sampling process occurs at a specific rate called
the sampling frequency. As long as the sampling frequency is more than twice as high as
the highest frequency in the signal, the sampled waveform will be a proper representation
of the analog waveform. If, however, the sampling frequency is less than twice as high as
the highest frequency to be sampled, the sampled wave form will contain extraneous
components called "aliases". The generation of aliases is called aliasing.
An example of aliasing sometimes occurs in motion pictures, as for instance when the
wagon wheels in a Western seem to be going backward. This is optical aliasing, caused by

the fact that the frame rate of the movie camera (24 frames per second) is not fast enough to
resolve the positions of the spokes. Another example of optical aliasing is the stroboscope,
where a moving object is illuminated by a flashing light and can be made to appear
stationary, or move backward.
Aliasing must be avoided in digital signal analysis to prevent errors, and FFT analyzers
always contain low pass filters in their input stages to eliminate frequency components
higher than one-half the sampling frequency. These filters are automatically tuned to the
proper values as the sampling frequency is changed, and this occurs when the frequency
range of the analyzer is changed.

Alignment
A condition where the components of a machine are coincident, parallel, or perpendicular,
according to design requirements. Misalignment is the condition where the desired
coincidence, parallelism, or perpendicularity is not achieved, and it causes abnormally high
wear and power consumption in the machine. The procedure to correct misalignment is also
called "alignment".

AM
See Amplitude Modulation.

Amplitude
The magnitude, or amount, of displacement, velocity, or acceleration, measured from the
"at rest" value. The amplitude of a vibration signal can be expressed in terms of "peak"
level, "Peak-to-peak" level, or RMS level. It is somewhat of a de facto standard that
Displacement is peak-to-peak, Velocity is peak, and Acceleration is RMS.
Amplitude Units

Amplitude Modulation
Amplitude modulation, or AM for short, is the fluctuation in amplitude of one signal
component due to the influence of another signal component called the modulating
frequency. The modulating frequency is usually much lower in frequency than the
modulated frequency. Amplitude modulation is a non-linear process, and gives rise to new
frequency components in the spectrum which would not be there without the modulation.
These new spectral components are called sidebands.
Amplitude Modulated Signal

Amplitude modulation occurs often in vibration signals generated by rotating machines. It


is usually recognized by the presence of sidebands in the vibration spectrum. The most
common modulating frequency is the turning speed, or 1X vibration component, and
common modulated frequencies are gear mesh and bearing tones. See also Demodulation.

Analog
If quantities in two separate physical systems have a consistently similar relationship to
each other, they are called analogous, and one is called the analog of the other. The
electrical output of a vibration transducer is an analog of the vibration input to the
transducer, and bears a continuous similarity to the vibration itself. This is in contrast to a
digital representation of the vibration signal, which is a sampled and quantized signal
consisting of a series of numbers, usually in binary notation.

Analog to Digital Conversion


The process of sampling an analog signal to produce a series of numbers that is the digital
representation of the same signal. The sampling frequency must be at least twice as high as
the highest frequency present in the signal to prevent aliasing errors.

Analysis Parameters
The specific characteristics of spectrum analysis, such as frequency range, frequency
resolution, windowing function, averaging type and number, etc., are called analysis
parameters. They may be different for individual measurement points.

Angular Frequency
The frequency of sinusoidal motion expressed as the rate of change of angle.

Anti-Aliasing Filter
The low pass filter in the input circuitry of digital signal processing equipment such as FFT
analyzers that eliminates all signal components higher in frequency than one-half the
sampling frequency. See Aliasing.

Apodize, Apodization

Literally, "to remove the foot". To apodize is to remove or smooth a sharp discontinuity in a
mathematical function, an electrical signal, or a mechanical structure. An example of
apodization is the use of the Hanning window in the FFT analyzer to smooth the
discontinuities at the beginning and end of the sampled time record. When stopping your
car, if you reduce the brake pedal force just as you come to a stop, you will not feel a "jerk"
and the car will come to a smooth stop. This is a form of apodization.

Asynchronous
Frequency components in a vibration signature that are not integral multiples of, or
harmonics of, the turning speed. Also called non-synchronous components. Belts and
rolling element bearings, among other things, generate asynchronous components.

Attenuation
Attenuation is the reduction in level of a signal when passing through a circuit element, or
the reduction in level of vibration energy as it passes through a structure. Attenuation is
commonly measured in Decibels, although it may be measured in percent. Attenuation is
usually frequency dependent, i.e. the amount of attenuation present varies as a function of
frequency. Attenuation of vibration energy in mechanical structures generally increases as
frequency rises, but it can be a very complex function of frequency.

Auto correlation
Auto correlation is a time-domain function that is a measure of how much a signal shape, or
waveform, resembles a delayed version of itself. It is closely related to the Cepstrum. The
value of auto correlation can vary between zero and one. A periodic signal, such as a sine
wave has an auto correlation which is equal to one at zero time delay, zero at a time delay
of one-half the period of the wave, and one at a time delay of one period; in other words, it
is a sinusoidal wave form itself. Random noise has an auto correlation of one at zero delay,
but is essentially zero at all other delays. Auto correlation is sometimes used to extract
periodic signals from noise. Certain dual-channel FFT Analyzers are able to measure auto
correlation.

Averaging
In performing spectrum analysis, regardless of how it is done, some form of time averaging
must be done to determine the level of the signal at each frequency. In vibration analysis,
the most important type of averaging employed is linear spectrum averaging, where a series
of individual spectra are added together and the sum is divided by the number of spectra.

Averaging is very important when performing spectrum analysis of any signal that changes
with time, and this is usually the case with vibration signals of machinery. It is especially
important for low-frequency measurements, which require long averaging times to achieve
a good statistically accurate estimate of the spectrum. Linear averaging smoothes out the
spectrum of the random noise in a spectrum making the discrete frequency components
easier to see, but it does not actually reduce the noise level.
Another type of averaging which is important in machinery monitoring is time domain
averaging, or time synchronous averaging, which requires a tachometer to synchronize each
"snapshot" of the signal to the running speed of the machine. Time domain averaging is
very useful in reducing the random noise components in a spectrum, or in reducing the
effect of other interfering signals such as components from another nearby machine.
In the DLI Alert software, the baseline spectrum or reference spectrum can be defined as an
average of spectra from several machines. This type of average is an average of previously
averaged spectra.

Axial
Parallel to the centerline of a shaft or turning axis of a rotating part. Axial vibration
measurements are an important part of machinery analysis. See also Orientation.

Background Noise
In machine vibration measurement, there will always be components in the spectrum that
are not of interest and may be caused by processes external to the machine being analyzed.
These components are collectively called background noise, and can sometimes mask the
data of interest. An estimate of the background noise can be made by making a vibration
measurement with the machine turned off. Some noise is contributed by the instrumentation
itself, and consists usually of random signals and line frequency and its Harmonics. One
way to reduce the effect of background noise is to use time synchronous averaging.

Balancing
The adjustment of the mass distribution of a rotating member so that the forces on the
bearings due to centrifugal effects are reduced to small values. The rotor is balanced if the
center of the mass distribution is coincident with the center of rotation. Balancing reduces
power consumption in machines, reduces vibration levels, and increases bearing life,
sometimes greatly.

Ball Pass Frequency

The frequency corresponding to the rate at which balls or rollers in a bearing pass a
particular location on one or other of the races. The inner race and outer race ball pass
frequencies are different from each other, and are dependent on the geometry of the bearing
and the rotation speed of the bearing. They are generally not harmonics of the turning
speed, and are difficult to predict exactly due to variations in bearing geometry, contact
angle, and load. The two frequencies are abbreviated BPFI for inner race and BPFO for
outer race. Ball pass frequencies are some of the fault frequencies which are noted in the
spectra of machine vibration.

Ball Spin Frequency


The frequency at which the balls or rollers revolve about their own centerline in a bearing.
This frequency is dependent on bearing geometry and the running speed of the bearing, and
is seldom a harmonic of turning speed. It is difficult to predict accurately because of
variations in bearing geometry, contact angle, and load. Ball spin frequency is one of the
fault frequencies that are noted in the spectra of machine vibration.

Band Pass Filter


A filter that only passes energy between two frequencies which are called the lower and
upper cutoff frequencies. Band pass filters can be fixed, where the cutoff frequencies are
constant, and can be variable, where the cutoff frequencies are varied with time. Variable
band pass filters are sometimes used for spectrum analysis, but the FFT analyzer has largely
supplanted them.

Bandwidth
The difference in frequency between the upper and lower cutoff frequencies of a band pass
filter or other device is called the bandwidth of the filter or device.

Baseline Spectrum
A vibration spectrum of a machine that is considered in good condition. In the DLI Alert
software, the baseline spectrum may be an average of spectra recorded from several
machines of the same type. The baseline spectrum is also sometimes called a reference
spectrum, and is used as a basis for comparison to spectra recorded as the machine
continues to operate.

Bearing Tones

Anti-friction bearings, i.e. bearings containing rolling elements like rollers or balls, produce
vibration excitation forces at specific frequencies dependent on the bearing geometry and
rotation speed. These vibration frequencies are called bearing tones. All such bearings,
regardless of their condition, will produce some level of bearing tones -- the important fact
is that they increase in level as the bearing deteriorates.
Four bearing tones are defined for rolling element bearings:
The Fundamental Train Frequency, abbreviated FTF, is the rotation rate of the cage or ball
retainer. It is usually about 0.4 times the running speed. The FTF itself is seldom seen in a
vibration spectrum because the cage is not very massive and caries essentially no load. The
FTF is seen as a modulating frequency, for instance in the case of a defective roller being
carried in and out of the bearing load zone will produce bursts of noise amplitude
modulated at the FTF rate, causing sidebands in the spectrum spaced apart by the FTF.
The Ball Spin Frequency (BSF), which is the rotation rate of the balls or rollers. A defect
such as a pit or spall on a ball will introduce the BSF into the vibration spectrum. The BSF
is strongly dependent on bearing geometry.
The Ball Pass Frequency Outer Race (BPFO), is the rate at which a ball passes over a fault
in the outer bearing race. It is very commonly found in bearing signatures. The BPFO will
be about 0.4 x RPM x No. of rollers.
The Ball Pass Frequency Inner Race (BPFI), which is the rate at which a defect in the inner
race encounters a ball. BPFI usually is lower in level than BPFO because the vibration
source is farther from the transducer -- the vibration excitation must pass through the
rolling elements and the outer race before being detected. The BPFI will be about 0.6 x
RPM x No. of rollers.

Beat Frequency
If two vibration components are quite close together in frequency, they will combine in
such a way that their sum will vary in level up and down at a rate equal to the difference in
frequency between the two components. This phenomenon is known as beating, and its
frequency is the beat frequency.
There is confusion in some areas between beating and amplitude modulation, which also
can produce an undulating vibration level. Amplitude modulation is a different effect, and is
caused by a low-frequency component being multiplied by a higher-frequency component
and is thus a non-linear effect, whereas beating is simply a linear addition of two
components whose frequencies are close to one another.

Bin
In an FFT spectrum, the individual "lines", or frequency indicators, are sometimes called
bins.

Bit
Short for Binary Digit. A number expressed in binary notation utilizes the digits 1 and 0,
and these are called bits.

Blade Pass Frequency


In the case of a fan or turbine, the rate at which the blades pass by a fixed position is called
the blade pass frequency. It is equal to the number of blades times the rpm of the rotor.
Blade pass frequency is one of the fault frequencies of interest in machine vibration spectra.

Bode Plot
A type of spectrum plot which consists of a graph of amplitude vs frequency and a graph of
phase vs frequency. In most vibration analysis work the phase spectrum is not important
and is either ignored or not recorded. In two-channel vibration measurements, such as
transfer functions and frequency response measurements used for modal analysis, phase is
of vital importance.

Bow
A shaft with a simple circular curve is said to be bowed. In electric motors, one cause of
shaft bow is uneven heating of the rotor laminations due to broken or cracked rotor bars. A
bowed shaft will exhibit a large degree of imbalance if the shaft RPM is above the first
critical speed.

BPI, BPFI
For rolling element bearings, the Ball Pass Frequency Inner Race (BPFI), is the rate at
which a defect in the inner race encounters a ball. BPI usually is lower in level than BPFO
because the vibration source is farther from the transducer - the vibration excitation must
pass through the rolling elements and the outer race before being detected. The BPI will be
about 0.6 x RPM x No. of rollers.

BPO, BPFO
For rolling element bearings, the Ball Pass Frequency Outer Race (BPFO), is the rate at
which a ball passes over a fault in the outer bearing race. It is very commonly found in
bearing signatures. The BPFO will be about 0.4 x RPM x No. of rollers.

BS, BSF
The Ball Spin Frequency (BSF), is the rotation rate of the balls or rollers in a rolling
element bearing. A defect such as a pit or spall on a ball will introduce the BS frequency
into the vibration spectrum. The BSF is strongly dependent on bearing geometry.

Brinnelling
The indentation of a race in a ball bearing due to a large static force or continuous vibratory
force applied to the bearing when stationary. A brinnelled bearing will show large amounts
of ball pass frequencies in its vibration spectrum and will fail prematurely.

Broad band
An overall vibration level which encompasses a wide range of frequencies is called a broad
band measurement, as opposed to a narrow band or FFT measurement where the energy in
narrow frequency bands is measured.

Buffer
A memory location in a computer or digital instrument which is set aside for temporarily
storing digital information while it is waiting to be processed. For instance, an FFT
analyzer will have one or more input buffers where the digital words representing the
samples of the input signal are kept.

Bump Test, Impact Test


A bump test is a type of vibration test that is normally run on a non-operating machine. The
machine is instrumented with one or more vibration transducers, and it is then impacted
with a massive object such as a hammer. The machine will respond to the impact by a
vibration that will die away, and the signals from the transducers are recorded and fed into a
spectrum analyzer. The resulting spectrum will contain peaks that correspond to the natural
frequencies, or "resonances" of the machine. In any machine, the vibration excitation forces
from its normal operation should be well away from the natural frequencies to avoid
resonant responses that can cause very high and destructive vibration levels.

Calibration

The verification of the accuracy and repeatability of transducers and measurement


electronic systems is called calibration. Vibration transducers are calibrated by subjecting
them to a known motion and accurately measuring the electrical output. They are normally
routinely calibrated at one-year intervals, and more often if they are subjected to damaging
stresses.

Carrier Frequency
In a signal which is generated by modulation, the frequency being modulated is called the
carrier frequency, by analogy to radio broadcasting, where a very high frequency signal
called the carrier is modulated by the audio signal. In machinery vibration analysis, an
example of a carrier might be a gear mesh frequency which is being amplitude modulated
by the turning speed of the gear.

Cavitation
Cavitation is a condition that often occurs in pumps and water turbines where reduced fluid
pressure results in bubbles forming near the surface of the rotor. When these bubbles
collapse, relatively large forces are transmitted to the rotor, and eventually it will cause
pitting of the surface. Cavitation in pumps commonly happens when the inlet pressure is
too low. It causes high-frequency random noise in the spectrum of the machine.

Center of Gravity
In a mechanical structure, the center of gravity is the point within the structure where the
mass seems to be concentrated. If suspended from the center of gravity, the structure would
be in equilibrium, and would not tend to rotate due to gravitational attraction. If the center
of gravity of a rotor lies on its axis of rotation, the rotor is said to be statically balanced.

Centrifugal Force
When you swing a stone on a string around in a circle, you apply an inward directed radial
force to it through the string to keep it moving in a circle. Otherwise, it would continue to
move in a tangential direction in accordance with Newton's laws of motion. The force
applied through the string is called the centrifugal force.
The stone also produces a reaction force equal to the centrifugal force in the outward radial
direction, and this is the so-called centripetal force. There exists much confusion
concerning these two forces -- what is popularly called centrifugal force is usually actually
centripetal force. The centripetal force is the force which causes 1X vibration in machines
with out of balance rotors.

Centripetal Force
See Centrifugal Force.

Cepstrum
The Cepstrum is the forward Fourier Transform of a spectrum. It is thus the spectrum of a
spectrum, and has certain properties that make it useful in many types of signal analysis.
One of its more powerful attributes is the fact that any periodicities, or repeated patterns, in
a spectrum will be sensed as one or two components in the cepstrum. If a spectrum contains
several sets of sidebands or harmonic series, they can be confusing because of overlap. But
in the cepstrum, they will be separated similar to the way the spectrum separates repetitive
time patterns in the waveform. Gearboxes lend themselves especially well to cepstrum
analysis. The cepstrum is closely related to the auto correlation function.

Charge Amplifier
A charge amplifier is a special type of preamplifier used with non-ICP piezoelectric
accelerometers. Its purpose is to convert the extremely high output impedance of the
accelerometer to a low value suitable for transmitting the vibration signal over cables to
other signal processing instruments. The charge amplifier is sensitive to the amount of
electric charge generated by the accelerometer rather than the voltage the accelerometer
generates. Because the charge is independent of the cable attached to the accelerometer, the
sensitivity of the accelerometer does not vary with cable length as it does when using a
voltage amplifier.

Coherence
Coherence is a number between one and zero, and is a measure of the degree of linearity
between two related signals, such as the input force of a structure related to the vibration
response to that force. Coherence is thus a two-channel measurement, and does not apply to
single-channel measurements of vibration signatures. In a frequency response
measurement of a mechanical structure, if the structure is linear, the coherence will be one,
but if there is some non-linearity in the structure or if there is noise in one or the other
measurement channel, the coherence will be less than one.
The dual-channel FFT analyzer is able to measure the coherence between the two channels,
and this is a useful tool in determining good from noisy or meaningless data.

Correction Weight

The correction weight is the added mass applied to a rotor to bring it into a state of balance.
To balance some rotors, several correction weights may be needed, and the procedure
required to determine the correction weights and their location is called multiple-plane
balancing.

Coulomb Damping
Coulomb damping is mechanical damping that absorbs energy by sliding friction, as
opposed to viscous damping, which absorbs energy in fluid, or viscous, friction. Sliding
friction is a constant value regardless of displacement or velocity. Damping of large
complex structures with non-welded joints, such as airplane wings, exhibit coulomb
damping.

Couple Imbalance
See Imbalance

Crest Factor
The crest factor of a waveform is the ratio of the peak value of the waveform to the RMS
value of the wave form. It is also sometimes called the "peak-to-RMS-ratio". The crest
factor of a sine wave is 1.414; i.e. the peak value is 1.414 times the RMS value. A typical
vibration signal from a machine with a large imbalance will have a crest factor similar to
this, but as the bearings begin to wear, and impacting begins to happen, the crest factor will
become much greater than this. The crest factor is one of the important measures of
machine condition.

Critical Damping
Critical damping is the minimum amount of damping which will prevent a resonant
structure from oscillating. The frequency response function of a critically damped system
will show no peak at the natural frequency. It is common to express the degree of damping
of a system as a percent of critical damping.

Critical Speed
The critical speed of a rotor is an operating range where turning speed equals one of its
natural frequencies due to bending or torsional resonances. If a rotor is operated at or near
a critical speed, it will exhibit high vibration levels, and is likely to be damaged. Much

rotating equipment is operated above its lowest critical speed, and this means it should be
accelerated relatively rapidly so as not to spend any appreciable time at a critical speed.

Cross Correlation
Cross correlation is a measure of the similarity in two time domain signals. If the signals
are identical, the cross correlation will be one, and if they are completely dissimilar, the
cross correlation will be zero. Certain dual-channel FFT analyzers are able to measure cross
correlation.

Cycle
One complete period of a periodic waveform is called a cycle. The units for frequency used
to be called "cycles per second" until the ISO standardized on the term "hertz", in honor of
Heinrich Hertz, the noted German scientist who was an early investigator of radio wave
transmission.

Damped Natural Frequency


If a resonant mechanical structure is set in motion and left to its own devices, it will
continue to oscillate at a particular frequency known as its natural frequency, or "damped
natural frequency". This will be a little lower in frequency than the resonant
frequency, which is the frequency it would assume if there were no damping. The resonant
frequency is also called the "undamped natural frequency".

Damping
Damping is the dissipation of energy within a mechanical structure and its conversion
ultimately into heat. There are several different mechanisms for damping, the most
important two of which are coulomb damping and viscous damping.

Degree of Freedom
In the description of the motion of structures or objects, a degree of freedom is one of
several orthogonal components that can be used to completely characterize the motion. For
instance, a free object in space has six different degrees of freedom -- it can translate in
three mutually perpendicular directions, and it can rotate about the three mutually
perpendicular axes. Any motion of the object, no matter how complex, can be resolved into
these 6 basic motions.

Some objects may not have all 6 degrees of freedom available to them; for instance an
elevator in an elevator shaft is constrained to 1 degree of freedom. When describing the
motion of a complex structure, different parts may be constrained in different ways, and a
great many degrees of freedom may be required to fully describe the overall motion of the
structure. In performing modal analysis of a structure or in finite element modeling of a
structure, it is not uncommon to consider hundreds of degrees of freedom.

Demodulate, Demodulation
Demodulation is the process of recovering the modulating signal from an amplitude
modulated (AM) or frequency modulated (FM). The demodulator is also called a detector.
In the field of vibration analysis, it is sometimes found that certain signal components, such
as 1X or run speed, will modulate other components such as gear mesh frequencies or
bearing tones. A demodulator can be used to detect and recover these modulating signals.
See also Amplitude Modulation and Frequency Modulation.

Detector
An electronic circuit that determines the amplitude level of a signal in accordance with
certain rules. The simplest type of detector consists simply of a resistor and capacitor, and it
measures the average value of a continuous fluctuating DC signal. A more complex but
must more useful detector is the RMS detector, which is almost always used in vibration
analysis systems. Any type of detector performs an average over time, and the averaging
time can theoretically be of any length. It is typically set to be several times longer than the
slowest fluctuation period of the signal being detected. Most detectors in vibration analysis
equipment have an averaging time of about one second. Detectors are used to determine the
levels of frequency domain signals (spectra) as well as time domain signals. Time domain
detectors are usually of the analog type, while detectors used in FFT analyzers are digital in
operation.
Demodulators used in radio receivers are also called detectors.

Deterministic
A type of signal whose spectrum consists of a collection of discrete components, as
opposed to a random signal, whose spectrum is spread out or "smeared" in frequency. Some
deterministic signals are periodic, and their spectra consist of harmonic series. Vibration
signatures of machines are in general deterministic, containing one or more harmonic
series, but they always have non-deterministic components, such as background noise.

Differentiation

In vibration analysis, differentiation is a mathematical operation that converts a


displacement signature to a velocity signature, or a velocity signature to an acceleration
signature. It is performed electronically on an analog signal, or can be performed digitally
on a spectrum. Differentiation is an inherently noisy operation, adding a significant amount
of high frequency noise to the signal, and is generally not used very much in machinery
vibration analysis. See also integration , which is the inverse of differentiation .

Digital
Digital instrumentation consists of devices that convert analog signals into a series of
numbers through a sampling process and an analog to digital converter. They then perform
operations on the numbers to achieve such effects as equalization, data storage, data
compression, frequency analysis, etc. This process in general is called digital signal
processing, and is characterized by certain advantages and disadvantages. One advantage
is that the converted signals can be manipulated, transformed, and copied without
introducing any added noise or distortion.
The disadvantage is that the digital representation may not be truly representative of the
original signal. Care must be taken that the sampling rate is high enough to encode all the
information of interest, and that artifacts are not introduced by aliasing.

Discrete
With reference to a spectrum, discrete means consisting of separate distinct points, rather
than continuous. An example of a discrete spectrum is a harmonic series. An FFT spectrum,
which consists of information only at specific frequencies (the FFT lines), is actually
discrete regardless of the input signal. For instance, the true spectrum of a transient is
continuous, and the FFT of a transient appears continuous on the screen, but still only
contains information at the frequencies of the FFT lines.
The input signal to an FFT analyzer is continuous, but the sampling process necessary to
implement the FFT algorithm converts it into a discrete form, with information only at the
specific sampled times.

Discrete Fourier Transform


The mathematical calculation which converts, or "transforms" a sampled and digitized
wave form into a sampled spectrum. The Fast Fourier Transform, or FFT, is an algorithm
that allows a computer to calculate the discrete Fourier transform very quickly.

Displacement

In machinery vibration, the displacement is the actual distance the vibration causes the part
in question to move. It is oscillatory and is measured in thousandths of an inch (mils) in the
English system and in millimeters (mm) in the SI system. By popular convention,
displacement measurements are made in peak-to-peak units.

Displacement Transducer
See Proximity Probe.

Distortion
Distortion is the presence of frequency components in the response of a system that are not
present in the excitation of the system, and it is caused by non-linearity in the system. An
example is an imbalance in a rotor in a machine that generates a sinusoidal excitation force
at the turning speed. If the machine is linear, the resulting vibration will be only at the
turning speed, but if there are non-linearities in the machine, such as looseness, then
harmonics of the turning speed will also be generated. In other words, the looseness of the
machine parts distorts the driving force signal. This property is used to diagnose machine
non-linearities such as looseness in machines.

Domain
A domain is a set of coordinates in which a mathematical function resides. A wave form,
for instance, has dimensions of amplitude vs. time, and it is said to exist in the time domain,
while a spectrum has dimensions of amplitude vs. frequency, and is said to exist in the
frequency domain.

Dynamic Imbalance
See Imbalance

Dynamic Range
The dynamic range of an instrumentation device such as an amplifier or an analyzer is the
ratio between the smallest signal it will sense without noise contamination to the largest
signal it will accept without an overload occurring. Dynamic range is usually expressed in
decibels, and most instrumentation used for vibration analysis has a dynamic range of 70 to
80 dB. An overload in any instrument is a gross non- linearity, causing spurious
components to appear in the signal, and must be avoided at all costs. For this reason, most

vibration instruments have overload indicators that warn the operator of possible data
contamination.

Eccentricity
Eccentricity is the deviation from circularity of a part, such as a rotor or a shaft. In electric
motors, eccentricity of the rotor causes undue vibration of the motor due to nonsymmetrical magnetic effects. Eccentricity of the stator also causes magnetic effects which
increase the vibration level.

Eddy Current
Eddy currents are electric currents induced in electrically conducting materials by
fluctuating magnetic fields. They cause heating of the metal, and are thus wasters of power.
A practical use for eddy currents is the eddy current probe, or proximity probe.

Eddy Current Probe


See Proximity Probe.

Engineering Units, EU
The units in which a measurement is made; for instance velocity may be expressed in
millimeters per second, miles per hour, or furlongs per fortnight, depending on the use the
data will be put to. Modern instrumentation, such as FFT analyzers allow you to specify
what the engineering units are and to apply conversion factors if needed.

EU
See Engineering Units

Excitation
In a vibrating mechanical system, the force, or forces, which cause the vibration are called
the excitation forces. If a mechanical system such as a machine is excited at a particular
frequency, it will vibrate at that frequency, and the vibration can be sensed almost anywhere
on it. Machinery analysis uses this basic fact, i.e. when a cracked bearing race causes a
force on the bearing housing at its characteristic frequency, this can be sensed by a
vibration transducer and the crack thus detected.

Expert System
The portion of Predictive Maintenance software that automatically examines recorded
vibration data, performs a diagnosis of machine problems, and writes a report is called an
expert system, or EADS (Expert Automated Diagnostic System) for short.

Fast Fourier Transform (FFT)


The FFT is an algorithm, or digital calculation routine used in the FFT analyzer, which
calculates a spectrum from a time waveform. In other words it converts, or "transforms" a
signal from the time domain into the frequency domain. See also DFT.

Fatigue
Metal fatigue is a condition in which a metal will lose its strength and will eventually crack
when subjected to too many flexings near its elastic limit.

FEM
FEM stands for Finite Element Modeling, which is a computer technique that models or
simulates a mechanical structure in software. Its physical characteristics such as resonances
and deflections under loads are calculated. The FEM model assumes that the structure can
be represented by a large number of single degree of freedom spring-mass systems. The
purpose of FEM is to perform testing on a structure without having to actually build the
structure, saving time and money. When the computer model does what the designer wants
it to do, only then is a physical structure constructed.

FFT
See Fast Fourier Transform.

FFT Analyzer
The FFT analyzer is a device that uses the FFT algorithm to calculate a spectrum from a
time domain signal, and is the most common type of spectrum analyzer available today.
The FFT analyzer is a very useful device, and is available in a great variety of models with
varying complexity. It is the heart of any machinery predictive maintenance program.

Filter
A filter is an electrical circuit that allows signals of certain frequency ranges to pass
through, and blocks all other frequencies. There are many types of filters, such as low pass
filters, high pass filters, and band pass filters. Examples of filters used in machinery
monitoring instruments are low pass filters to reject high frequency noise and to prevent
aliasing, and high pass filters to reject low frequency noise. Variable band pass filters were
used in the past to perform spectrum analysis, but they have been largely supplanted by the
FFT analyzer.

Flattop Window
The flattop window is a special window used in some FFT analyzers in addition to the more
common Hanning window and rectangular window. The flattop window does not allow as
fine a frequency resolution as the Hanning window, but it will accurately measure the level
of a signal at any frequency, even if the frequency is between the lines of the FFT analysis.
It is used in transducer calibration systems to increase amplitude accuracy.

Fluid-Film Bearing
A fluid film bearing is a sleeve bearing which supports the shaft, or journal, on a thin film
of oil. The oil film layer may be generated by the rotation of the journal itself (hydrodynamic bearing), or it may be generated by externally applied pressure (hydro-static
bearing).

Forced Vibration
The vibration of a structure or system in response to an applied force. If the system is
linear, the vibration will be at the same frequency as the force, but if it is non-linear, the
vibration will also occur at other frequencies, especially at harmonics of the forcing
frequency. Vibration of machines is typically forced vibration, and the forces result from
such things as imbalance and misalignment of rotating parts, and from bearing faults, etc.

Forcing Frequencies
In a rotating machine, the moving parts impart vibratory forces into the structure, and these
forces occur at specific frequencies determined by the dynamics of the moving element.
The resulting vibration of the machine will occur at these frequencies and other frequencies
that are related to them. The most important forcing frequencies of interest to the
maintenance engineer and vibration analyst are the ones related to various faults such as
bearing problem, misalignment, mechanical looseness, etc. These frequencies should be
identified and kept at hand by the analyst when examining vibration spectra. One of the

most important uses of the VTAG is the listing of the forcing functions present in each
machine.

Foundation
The supporting structure for a machine is generally called the foundation, and it is vitally
important to the proper operation of the machine. Loose, flexible, or cracked foundations
are the cause of many machine problems, especially misalignment.

Fourier, Jean Baptiste


The famous many-talented French engineer, one time president of Egypt, and
mathematician who devised the Fourier series and Fourier Transform for the conversion of
time functions into frequency functions and vice versa.

Fourier Transform
The mathematically rigorous operation that transforms from the time domain to the
frequency domain and vice versa. See Fourier Analysis.

Fourier Analysis
Fourier analysis is another term for spectrum analysis, although it generally refers to
analysis using an FFT analyzer.

Free Running
Free running is an operating mode of an FFT analyzer, and it means the analyzer is set to
continuously accept data and perform analyses rather than to wait for a trigger to initiate
data acquisition.

Free Vibration
Free vibration is the continuing oscillation of a structure after the excitation force is
stopped. The vibration will then be at the natural frequency of the system and will gradually
die away due to the damping in the system.

Frequency
Frequency is the reciprocal of time. If an event is periodic in time, i.e. if it repeats at a fixed
time interval, then its frequency is one divided by the time interval. If a vibrating element
takes one tenth of a second to complete one cycle and return to its starting point, then its
frequency is defined to be 10 cycles per second, or 10 hertz (Hz). Although the SI standard
unit of frequency is the Hz, when analyzing machinery vibration we often find it more
convenient to express frequency in cycles per minute, which corresponds to rpm.
Frequency in rpm is simply frequency in Hz times 60. Another common frequency
representation used in machinery monitoring is multiples of turning speed, or "orders".
Frequency in orders is frequency in rpm divided by the turning speed of the machine. The
second order is then the second harmonic of turning speed, etc. This is especially
convenient if the machine is varying in speed, for the frequency representation on a
spectrum will be the same regardless of speed. Two machine spectra can therefore more
easily be compared if they are both expressed in orders. Conversion of the frequency axis
of a spectrum to orders is called "order normalization", and is done by the monitoring
software.

Frequency Domain
Vibration exists in time, and it is said to be in the "time domain". The representation of a
vibration signal in the time domain is a "wave form", and this is what you would see if the
signal were displayed on an oscilloscope. If the waveform is subjected to a spectrum
analysis, the result is a plot of frequency vs amplitude, called a spectrum, and the spectrum
is in the frequency domain. The waveform is said to be "transformed" from the time
domain to the frequency domain. Most detailed analysis of machinery vibration data is
done in the frequency domain, but certain information is more easily interpreted in the time
domain.

Frequency Response
The frequency response is a characteristic of a system that has a measured response
resulting from a known applied input. In the case of a mechanical structure, the frequency
response is the spectrum of the vibration of the structure divided by the spectrum of the
input force to the system. To measure the frequency response of a mechanical system, one
must measure the spectra of both the input force to the system and the vibration response,
and this is most easily done with a dual-channel FFT analyzer. Frequency response
measurements are used extensively in modal analysis of mechanical systems.
The frequency response function is actually a three-dimensional quantity, consisting of
amplitude vs. phase vs. frequency. Therefore a true plot of it requires three dimensions, and
this is difficult to represent on paper. One way to do this is the so-called Bode plot, which
consists of two curves, one of amplitude vs. frequency and one of phase vs. frequency.
Another way to look at the frequency response function is to resolve the phase portion into
two orthogonal components, one in-phase part (called the real part), and one part 90

degrees out of phase (called the "quadrature" or "imaginary" part). Sometimes these two
phase parts are plotted against each other, and the result is the so-called Nyquist plot.

FT, FTF
FT stands for "fundamental train frequency", and is the rotation rate of the "cage"
supporting the rollers in a rolling element bearing. The FT is always less than one-half the
rpm of the shaft, and is one of the fault frequencies which is monitored in machines. If the
vibration spectrum of a machine shows a high amplitude of the FT, it does not mean the
bearing has a bad cage, but rather means that one of the rollers is cracked or otherwise
deformed. This causes a vibration component to occur each time the roller enters the load
zone of the bearing, which is at each revolution of the cage, giving rise to a vibration at that
rate. Frequently other fault frequencies in bearings are amplitude modulated by the FT. This
means there will be sidebands around these frequencies spaced at the interval of the FT.

Fundamental Frequency
The spectrum of a periodic signal will consist of a fundamental component at the reciprocal
of the period and a series of harmonics of this frequency. The fundamental is also called
the "first harmonic". It is possible to have a periodic signal where the fundamental is so low
in level that it cannot be seen, but the harmonics will still be spaced apart by the
fundamental frequency.

Fundamental Train Frequency


See FT, FTF

G
G is the acceleration due to gravity at the surface of the earth, and it is used as a unit of
acceleration in the English system of measurements. G is not exactly constant, but varies a
little over the earth's surface, so an average value of 32.2 feet per second per second is
used. In the SI system, G is 9.81 meters per second per second, but is not usually used as a
unit of acceleration. Because we use inches per second as a unit of velocity, it would make
more sense to use inches per second per second as an acceleration unit, but G has a long
tradition behind it.

Gear-Mesh Frequency

The gear mesh frequency, also called "tooth mesh frequency", is the rate at which gear teeth
mate together in a gearbox. It is equal to the number of teeth on the gear times the rpm of
the gear. A gearbox will always have a strong vibration component at the gear mesh
frequency, and it is one of the fault frequencies used in machinery monitoring.

Ghost Frequency
Sometimes the vibration spectrum of a gearbox will contain components which cannot be
related to any known geometry of the gearbox. These are called "ghost frequencies", and
are caused by irregularities machined into the gears in the manufacturing process. Ghost
components are independent of loading, and tend to disappear as the gears wear.

GPIB
GPIB stands for General Purpose Interface Bus, and is a method of connecting digital
instruments such as FFT analyzers and plotters, etc., together according to the IEEE-488
standard. It is also known as the HPIB, which is a version of it used by Hewlett-Packard.

Ground Loop
In instrumentation systems, such as vibration measurement data collection systems, it is
often required to mount a transducer on a machine whose structure or "ground" may have
an electrical voltage present on it caused by current leakage in motor windings, etc. The
transducer cable shield is normally connected to the housing, and is then electrically
connected to this voltage when the transducer is mounted. If the instrument to which the
transducer is connected is connected to a different ground, such as a power line neutral, this
difference in the ground potentials will cause a current in the shield, and this will add
interference to the measured signal. The interference will be at 60 Hz and its harmonics,
and it reduces the signal to noise ratio of the measurement. This condition is called a
ground loop, and there are several ways to avoid it. One is to use an insulating disc between
the transducer and the machine, and another is to use a battery-operated instrument which is
not connected to a power line.

Hanning Window
The Hanning window, also called "Hanning weighting", is a digital manipulation of the
sampled signal in an FFT analyzer which forces the beginning and end of the time record to
zero amplitude. This compensates for an inherent error in the FFT algorithm that would
cause the energy at specific frequencies to be spread out rather than well-defined in
frequency. The Hanning window causes a distortion of the waveform used by the analyzer
to calculate the spectrum resulting in the measured levels being too low. When processing

continuous data, this effect is compensated for, but an error is introduced if the Hanning
window is used for transient data.

Hamming Window
Named after its originator, the Hamming window is a Hanning window sitting on top of a
small rectangular pedestal. Its function is similar, but has its first side lobes 42 dB down,
whereas the Hanning window's first side lobes are only 32 dB down. Thus the Hamming
has better selectivity for large signals, but it suffers from the disadvantage that the rest of
the side lobes are higher, and in fact fall off slowly at 20 dB per octave like those of the
rectangular window. The Hamming window had some advantage in the days when FFT
analyzers only had 50 dB or so of dynamic range, but nowadays it is essentially obsolete.

Harmonics
Harmonics, also called a harmonic series, are components of a spectrum which are integral
multiples of fundamental frequency. A harmonic series in a spectrum is the result of a
periodic signal in the wave form. Harmonic series are very common in spectra of
machinery vibration.

Hertz
The unit of frequency in the SI measurement system is the hertz, abbreviated Hz. One hertz
is equal to one cycle per second. The name is in honor of Heinrich Hertz, an early German
investigator of radio wave transmission.

High-Pass Filter
A filter that passes signal frequencies above a specific frequency called the "cut-off"
frequency. High pass filters are used in instrumentation to eliminate low-frequency noise,
and to separate alternating components from direct (DC) components in a signal.

HTF
See Hunting Tooth.

Hunting Tooth

The hunting tooth frequency (HTF) is the rate at which a particular tooth on one gear mates
with a particular tooth on the other gear. If the numbers of teeth on the gears are a simple
ratio such as 1:2 or 1:3, the HTF will be equal to the RPM of the larger gear, but if the
numbers of teeth have no common factors, the HTF may be very low. Gear pairs with low
HTFs will wear more evenly and last longer than ones with a relatively high HTF. The HTF
is equal to the gear mesh frequency divided by the least common multiple of the numbers
of teeth on the gears.

Hysteresis
Hysteresis is a condition that exists in certain systems where a small change in input level
does not result in a change in the output of the system. It is also sometimes called
"deadband". Hysteresis exists in many types of systems; i.e. in the magnetization of
magnetic media as well as mechanical systems, especially ones that have excessive
looseness.

Hz
See Hertz.

ICP Accelerometer
ICP stands for Integrated Circuit Piezoelectric, and an ICP accelerometer contains within its
housing a small integrated circuit which effectively isolates the piezoelectric element from
the outside world. A power supply is needed at the signal-conditioning device to supply a
constant current of a few milliamperes to the IC. This current is in the same conductor as
the signal coming back from the accelerometer, and there must be a series capacitor to
isolate the DC source from the signal current.

Imbalance
A condition of a rotating part where the center of mass does not lie on the center of rotation.
Imbalance of a rotor causes a centripetal force at the frequency of the rotation rate to be
applied to the bearings. If it is large, it can severely shorten the life of the bearings, besides
causing undue vibration of the machine. Forces caused by imbalance are proportional to the
square of the RPM, and this means that high-speed machines must be balanced to a higher
standard than low-speed machines.
Imbalance exists in several forms. Static Imbalance is the condition where the principal
inertia axis of a rotor is offset from and parallel to the axis of rotation. A rotor with static
imbalance will seek a position with the heavy spot at the bottom if placed on level knife-

edges. Static imbalance can theoretically be corrected by the addition of a single correction
mass.
Couple imbalance is the condition where the principal inertia axis intersects the rotation
axis of the rotor at the center of gravity. A rotor with couple imbalance will be stable in any
position on knife edges, but will produce out-of-phase imbalance forces on the bearings
when rotated. Correction of couple imbalance requires the addition of two correction
masses.
Dynamic imbalance is a combination of these two types, and is the most common type
found in practice. In dynamic imbalance, the principal inertia axis neither intersects nor is
parallel to the axis of rotation. Correction of dynamic imbalance requires at least two
correction masses.

Impact Test
See Bump Test.

Impedance, mechanical
The mechanical impedance of a point on a structure is the ratio of the force applied to the
point to the resulting velocity at the point. It is a measure of how much a structure resists
motion when subjected to a given force, and it is the reciprocal of mobility. The mechanical
impedance of a structure varies in a complicated way as frequency is varied. At resonance
frequencies, the impedance will be low, meaning very little force can be applied at those
frequencies. Mechanical impedance measurements of machine foundations are sometimes
made to insure their suitability for the machine in question. For instance, it would not be
good to have a foundation resonance near the turning speed of the machine.

Inertia
Inertia is the tendency of a mass to remain stationary when it is not moving and to remain
in motion when it is moving. Mass is actually a quantitative measure of inertia.

Integration
Integration is the mathematical operation that is the inverse of differentiation. In vibration
analysis, integration will convert an acceleration signal into a velocity signal, or a velocity
signal into a displacement signal. Integration can be done with excellent accuracy with an
analog integrator in the time domain or can be done digitally in the frequency domain, and
for this reason the accelerometer is the best choice of vibration transducer because velocity

and displacement can so easily be derived from its output. An analog integrator is actually a
low pass filter with 6 dB of attenuation per octave.

Integrator
The integrator, sometimes called an "analog integrator", is a simple electronic circuit which
performs a mathematical integration on a signal which passes through it. It is most often
used to convert the acceleration signal output of an accelerometer to a velocity signal.
Integrators are common in signal processing equipment, including FFT analyzers.

Isolation
Vibration isolation is the reduction in the tendency of a mechanical system to respond to, or
to transmit, an excitation, and it is accomplished by a system of resilient supports. The
design of such supports is somewhat complex, and depends on the mass of the unit to be
isolated, among other things.

Jerk
Jerk is the rate of change of acceleration, and can be measured by differentiating the output
of an accelerometer. It is not normally used in vibration analysis of machinery, but is
measured by elevator makers because it is the quantity most easily felt by elevator riders.

Keyphasor
The keyphasor is an electric pulse, or trigger, which is derived from a point on a rotating
shaft. It serves as a zero phase reference for determining where imbalance is on a rotor.
Keyphasor is a trademark owned by the Bentley Nevada Company, but has almost become
a generic term by popular usage.

Kurtosis
Kurtosis is a statistical measure of the amplitude distribution of a signal, and heavily
weights the fourth power of the signal amplitude. It is strongly affected by the crest factor
of the signal, and if trended, is a sensitive indicator of crest factor changes over time. It has
been used in machinery monitoring, especially for reciprocating compressors, but has not
become commonplace.

Leakage

In an FFT analyzer, the input signal is recorded in blocks, called time records, and the
spectra are computed from the blocks of data. Because the input signal is not synchronized
with the length of the block, it will be truncated at the beginning and end of the block. This
truncation causes an error in the calculation that effectively spreads out, or "smears" the
spectrum in the frequency domain. This phenomenon is called leakage; the signal energy
essentially "leaks" from a single FFT line to adjacent lines. Leakage reduces the accuracy
of the measured levels of peaks in the spectrum, and reduces the effective frequency
resolution of the analysis. Leakage is worst for continuous signals and rectangular window,
and it is greatly reduced by use of the Hanning window, which forces the signal level to
zero at the ends of the data block.

Level
In common usage the level of a signal is simply its amplitude, but strictly speaking, the
term should be reserved for the amplitude expressed on a decibel scale relative to a
reference value.

Line Spectrum
A line spectrum is a spectrum where the energy is concentrated at specific frequencies
(lines or bins), as opposed to a continuous spectrum where the energy is smeared out over a
band of frequencies. A deterministic signal will have a line spectrum, and a random signal
will have a continuous spectrum. Spectra generated by machine vibration signatures are
always a combination of the two types.

Linear, Linearity
A system is said to be linear if it meets the two following conditions: If input A to the
system results in output B, and input 2A results in output 2B AND if input A results in
output B and input C results in output D, then input A+C results in output B+D. A linear
system generates no spurious signals of its own, and its output frequency is always the
same as its input frequency. It is non-linearities in stereo systems that result in harmonic
and intermodulation distortions. While mechanical systems tend to be linear, they always
exhibit non-linearities when driven at very high levels.

Low Pass Filter


A low pass filter is a filter that passes signal components at frequencies lower than a
specific frequency called the cut-off frequency. An example is the anti-aliasing filter.

Magnetostriction
Magnetostriction is a property of magnetic materials that causes them to change shape in
the presence of magnetic fields. This causes a vibration at the frequency of the field
fluctuations, and this is part of the cause of 120 Hz vibration found in electrical machines
such as motors and transformers.

Mask
In predictive maintenance software, a mask (often called alarm envelope) defines the alarm
level across the frequency span. You may decide that the vibration level should not
increase by more than 6 dB (that is, where the level will double), so you will design the
mask so that it is 6 dB above all of the peaks in the reference trace. Every spectrum
measurement point on a machine should have its own mask.

Mechanical Impedance
See Impedance, Mechanical

Micrometer
The micrometer, or micron as it is sometimes called, is a unit of length in the SI system
equal to one millionth of a meter. 25.4 micrometers equals one mil.

MIL-STD-167-1
This is the military standard that defines acceptable vibration levels. This limit will be used
if no average data is available for expert system analysis. This sets the alarm level at 107
VdB above a frequency of about 1000RPM:

Mils
The mil is the English system abbreviation for one thousandth of an inch. Vibration
displacement is usually measured in mils in the English system.

Mobility

Mobility is the inverse of Mechanical impedance. It is the ease with which a structure is
able to move in response to an applied force, and is a function of frequency as well as a
function of the location on the structure.
The vibration measured at a point on a machine is the result of a vibratory force acting
somewhere in the machine. The magnitude of the vibration is the equal to the magnitude of
the force times the mobility of the structure. From this it follows that the value of the
destructive forces acting on a machine are not determined directly by measuring the
vibration if the mobility is not known. For this reason, it is a good idea to measure the
mobility at the bearings of a machine in order to find out the levels of the forces acting on
the bearings due to imbalance or misalignment.

Modal Analysis
Modal analysis is generation of a computer model of a mechanical system from measured
frequency response functions of the system. Once the model exists in the software, it can be
displayed on the screen and all its modes of vibration can be animated. The model can also
be modified by adding or subtracting masses and stiffnesses to evaluate the effect of doing
this on the actual system. Modal analysis is an experimental technique, and is often used to
verify the accuracy of an FEM.

Mode of Vibration
A mode of vibration is a characteristic pattern or shape in which a mechanical system will
vibrate. Most systems have many modes of vibration, and it is the task of modal analysis to
determine these mode shapes. The actual vibration of a structure is always a combination
or mixture of all the vibration modes. But they need not all be excited to the same degree.
For instance, if a bell is rung softly, we hear primarily the fundamental mode of vibration,
but if it is hit harder, other modes are excited, and we hear the upper partials of the tone.

Mode Shape
A mode shape is a specific pattern of vibration executed by a mechanical system at a
specific frequency. Different mode shapes will be associated with different frequencies. The
experimental technique of modal analysis discovers these mode shapes and the
frequencies.

Modulation
Modulation is the variation of one parameter of a signal by the action of another signal. A
common type of modulation is amplitude modulation, where the amplitude of one signal
(called the "carrier") is caused to fluctuate in response to a modulating signal. This is the

way AM radio transmission works; a high-frequency wave called the carrier is caused to
fluctuate in level in accordance with the voice or music signal being transmitted. The radio
receiver picks up the modulated carrier and performs a demodulation to extract the audio
signal. Frequency modulation is another type where the frequency of the carrier is varied
rather than the amplitude. Modulation of a carrier causes new components to appear in the
spectrum and they are called sidebands. The frequencies of the sidebands are equal to the
carrier frequency plus and minus the modulating frequency.
In rotating machinery there are many fault mechanisms which can cause amplitude and
frequency modulation, and vibration analysis exposes the sidebands. Demodulation can be
performed to detect the modulation frequencies directly.

Narrow band Analysis


Narrow band analysis is technobabble for FFT analysis.

Natural Frequency
The natural frequency is the frequency at which a mechanical system will continue to
vibrate after the excitation signal is removed. It is sometimes called the resonant frequency,
but this is inaccurate, for the resonant frequency is the frequency at which it would vibrate
if there were no damping. See also Free Vibration.

Node
In a vibration mode shape the locations where the motion is zero are called nodes. Each
mode shape will have its nodes in different places on the structure, and there may be some
nodes that are common to several mode shapes.

Noise
Strictly speaking, noise is any unwanted signal, but the term generally is used to indicate a
random signal. Noise is caused by electrical effects as well as mechanical ones, and there
are many different types.

Noise Floor
The noise floor is the residual noise level of an instrumentation system when nothing is
being measured. The smallest measurable signal must be above this noise floor if it is to be
measured accurately.

Non-Linear
A non-linear process is defined as any process that violates the rules of linearity. Most
properly running machines are essentially linear in their response to vibration excitation,
but certain defective conditions introduce non-linearity, and this greatly affects the
vibration signature. This fact is the major reason for the success of vibration monitoring as
an effective tool for machine condition determination. Non-linearities caused by looseness
account for the generation of harmonics of running speed, and defective gears and bearings
create non-linearities that cause running speed sidebands to appear in the vibration spectra.

Non-Linear Damping
Non-linear damping is damping in a mechanical system where the damping force is not
proportional to velocity. Many complex structures exhibit non-linear damping, and their
behavior at various excitation levels is difficult to predict.

Normal Mode of Vibration


A normal mode of vibration of a mechanical system is vibration in a mode shape as
described under modal analysis. It is difficult to excite a system to vibrate in only one
mode at a time unless it is a very simple system; usually all modes are excited at least to
some extent.

Normalization
With regard to vibration spectra of rotating machines, normalization is the process of
dividing the frequency values along the x-axis by the turning speed of the machine. After
this is done, the machine speed will appear at a frequency of 1, the second harmonic will be
at a frequency of 2, etc. A glance at the spectrum is all that is needed to find the harmonics
of turning speed, and any other components are thus easily seen, especially nonsynchronous components.

Nyquist frequency
In the process of analog to digital conversion, the input signal must first be sampled. If the
signal contains any information at frequencies above one-half the sampling frequency, the
signal will not be sampled correctly, and the sampled version of the signal will contain
spurious components due to the phenomenon of aliasing. The maximum frequency that can
be correctly sampled is called the Nyquist frequency, and is equal to one-half the sampling
rate.

In all digital signal processing systems, including FFT analyzers, the sampling rate is made
to be significantly greater than twice the Nyquist frequency in order to be certain the
aliasing will not occur.

Nyquist Plot
The Nyquist plot is representation of a frequency response function by graphing the "real"
part versus the "imaginary" part. In the Nyquist plot, a resonance shows up as a circle, but
there is no indication what its frequency is - the Nyquist plot is like sighting down the
frequency axis at the real and imaginary parts of the function.

Octave
An octave is a frequency interval having a ratio of two. It is called an octave from the
music tradition where an octave spans eight notes of the scale. The second harmonic of a
spectral component is one octave above the fundamental. In acoustical measurements,
sound pressure level is often measured in octave bands, and the center frequencies of these
bands are defined by the ISO. Vibration measurements are seldom expressed as octave band
levels.
Octaves and 1/3 Octaves

Oil Whip
Oil whip is a potentially destructive condition where a shaft is operating at a speed where
the vibration excitation due to oil whirl corresponds to a shaft critical speed. The result is
violent vibration of the shaft.

Oil Whirl
A vibration of a shaft within a sleeve bearing caused by the oil film whirling around the
inside of the bearing and moving the journal around with it. It occurs at between 40 and 48
percent of the shaft rpm, and is non-synchronous with the shaft. It can be caused by
excessive clearance in the bearing and/or by insufficient radial loading of the bearing. Oil
whirl is never desirable, but if it causes oil whip, it becomes much more serious.

Orbit
The orbit is a plot of the position of the centerline of the journal in a sleeve bearing, and it
is measured by two proximity probes mounted in the bearing housing 90 degrees apart from

each other. It can be displayed on an oscilloscope if the two probe outputs are connected to
the horizontal and vertical inputs respectively, and it is a good indicator of the presence of
oil whirl in the bearing.

Orders
In rotating machines, orders are multiples or harmonics of the turning speed. In comparing
vibration spectra of rotating machines, it is convenient to express the frequency axis of the
spectra in orders, especially if the machine speed varies between measurements.

Order Analysis
Order analysis is simply frequency analysis where the frequency axis of the spectrum is
expressed in orders of rpm rather then in Hz or rpm.

Orthogonal
Orthogonal refers to independent dimensions of a measured quantity. For instance, on a
map, it is possible to locate a point by its longitude and latitude. These two measures are
independent of each other, and both are required to locate the point. They are said to be
orthogonal. In vibration measurement for machine monitoring, we measure acceleration in
three orthogonal directions, and from these three measurements, the actual orientation in
space of the vibration can be determined. In three-dimensional space, orthogonal directions
are 90 degrees from each other.

Oscillation
Oscillation is another term for vibration.

Overall Level
The overall level of vibration of a machine is a measure of the total vibration amplitude
over a wide range of frequencies, and can be expressed in acceleration, velocity, or
displacement. The overall level can be measured with an analog vibration meter, or it can
be calculated from the vibration spectrum by summing up all the amplitude values over a
frequency range. In comparing overall vibration measurements, it is important that they
encompass the same frequency range.

Overlap Processing

In the FFT Analyzer, the time signal is stored in a buffer before being processed to form the
spectrum. If the buffer is continually being updated with new information, and if the FFT
algorithm is allowed to process the signal before all the data is replaced, overlap processing
is the result. Overlap processing is desirable when using a Hanning Window because it
ensures against loss of data for parts of the signal that occur near the beginning and end of
the window. Most FFT-type data collectors use 50% overlap processing as a default.

Peak
The peak value of a signal is the maximum excursion in one direction from the zero point.
The actual value can be displacement, velocity, or acceleration, or could simply be
expressed as a voltage.
In a spectrum, a peak is simply a sharp maximum.

Peak-to-Peak (Pk-Pk) Value


In measuring the level of a signal waveform, the peak-to-peak value is the difference
between the highest positive peak level and the lowest negative peak value. In machine
vibration, displacement is generally measured in peak-to-peak units.

Pendulum
A pendulum is a simple mechanical system consisting of a mass suspended on a pivoted rod
such that it can vibrate in one direction under the influence of gravity. It is generally
considered to be a single degree of freedom system, and has been used for centuries as the
timing mechanism for clocks. If a pendulum has a constant length of swing, it will always
vibrate at exactly the same frequency; i. e., it is said to be isochronous. A pendulum
swinging in a circular arc is not isochronous if the arc length changes, a fact which has
caused much gnashing of teeth among clock makers over the years. A truly isochronous
pendulum would have to swing in a cycloidal rather than circular arc, a fact that was
recognized by Christian Huygens, who built the first pendulum clock in the 15th century.

Period
A signal which repeats the same pattern over time is called periodic, and the period is the
length of time encompassed by one cycle, or repetition. The period of a periodic waveform
is the inverse of its fundamental frequency.

Periodic

A signal is periodic if it repeats the same pattern over time. The spectrum of a periodic
signal is always a series of harmonics.

Phase
Phase is a relative time difference between two signals. It is usually measured in units of
angle rather than units of time, and it makes sense only if the two signals being compared
are of the same frequency. One cycle of a periodic signal represents a complete circle, or
360 degrees of phase angle. A phase difference of 180 degrees is thus a difference of one
half cycle. Phase measurement is a two-channel measurement, and has no meaning when
considering a single signal. In balancing of rotating equipment, phase measurement relative
to the shaft position is of vital importance, and a tachometer pulse derived from a position
on the shaft is used as a reference for zero phase angle. Phase is also an important part of
the frequency response measurement.

Phase Angle
See Phase

Phase Shift
The phase shift of one signal in relation to another is simply a time delay expressed in
degrees of angle where a full circle (360 degrees) is equal to one cycle of the signal, or one
rotation of the rotor in a rotating machine.

Phasor
A sinusoidal signal can be thought of as a rotating vector whose length represents its
magnitude and angle represents its phase. Its rate of rotation is then the frequency of the
signal. Such a vector is called a phasor.
Phasor notation is sometimes used when describing amplitude and frequency modulation.

Picket Fence Effect


See Resolution Bias Error.

Pickup

"Pickup" is instrumentation people's slang for a vibration transducer. It is not specific for
any particular type.

Piezo-electric
Certain substances, especially some crystals such as quartz, will develop an electric charge
on their surfaces when they are mechanically squeezed and they are called piezoelectric.
The word piezo comes from the Latin word meaning to squeeze. This characteristic is
utilized in the design of many different transducers, especially accelerometers.

Piezo-electric Transducer
Any transducer that uses a piezoelectric substance as an active element. Examples are force
transducers, accelerometers, pressure transducers, and phonograph pickup cartridges.

Pink Noise
A type of random noise in which its energy content is attenuated by 3 dB per octave of
frequency is called pink noise. It is often used as a test signal in acoustical testing.

Power Factor
In the 60 Hz alternating current power distribution system, the voltage and the current have
the same sinusoidal wave form. Ideally, these two waves would be exactly in phase, and
this will be true in the case of a purely resistive load. If the load is reactive, i.e., if it has
either capacitive or inductive reactance, then the current will either lead the voltage or lag
behind the voltage. When this happens, the power transmitted is reduced, even though the
voltage and current levels are the same. (Since power is current times voltage, if the two are
not in phase the produce will be smaller than if they are in phase.) The power factor is the
amount that the power is reduced because of reactive loads, and it is measured in percent.
Most industrial plants have many electric motors, and this presents a highly inductive load
to the power line, reducing the power factor and the efficiency of the power lines. Because
capacitive and inductive reactance shift the current in opposite directions, a reactive load
can be compensated by connecting a large capacitor across the line. This is frequently done
in practice.
An interesting characteristic of synchronous electric motors is that they behave like
capacitors if the rotor excitation current is larger than normal. This is called "over
excitation", and is sometimes used to correct power factor in plants with many induction
motors.

Power Spectral Density


Power spectral density, or PSD, is a method of scaling the amplitude axis in certain spectra
which consist of random rather than deterministic signals. Because a random signal has
energy spread out over a frequency band, it is not meaningful to speak of its RMS value at
any specific frequency. It only makes sense to consider its amplitude in a fixed frequency
band, usually 1 Hz. PSD is defined in terms of amplitude squared per hertz, and is thus
proportional to the power delivered by the signal in a one-hertz band.

Preload
A preload is a static axial force applied to a rolling element bearing to assure that the rolling
elements and the races are always in contact. Too little preload can cause the elements to
lose contact momentarily and then skid with consequent damage. Too much preload will
also cause premature bearing failure.

Pressure Waves
Vibratory motion in a mechanical system is seldom uniform in all parts of the system
especially at high frequencies, but travels in the metal at high speeds by pressure waves.
Any material or structure cannot transmit a force instantaneously, but does so at the speed
of sound in the material. Because this speed is not infinite, if the force being transmitted is
oscillatory, pressure waves will travel through the medium, and their wavelength will be the
speed of sound divided by the frequency of oscillation of the force.
The speed of sound in steel is about 17 times the speed of sound in air.

Prime Mover
A machine which converts chemical or electrical energy into mechanical motion, such as a
steam engine or an electric motor.

Principal Inertia Axis


In reference to a rotor, the principal inertia axis is a hypothetical axis, on which the center
of mass is located, and around which the rotor would spin if it were in free space
unencumbered by bearing or gravitational forces. See Imbalance.

Proximity Probe

The proximity probe is a displacement transducer. It consists of a small coil of wire around
a metal rod, which is connected to a special preamplifier. The voltage output of the
preamplifier is proportional to the displacement between the end of the probe and a
conducting surface. The response of the system is from DC, i.e. it measures static
displacement, and dynamic displacement up to about 1000 Hz. Proximity probes are used
extensively in instrumenting sleeve bearings, where they measure the thickness of the oil
film and can detect oil whirl and other bearing defects. They are also sometimes called
eddy current probes.

PSD
See Power Spectral Density.

Q
Q stands for "quality factor", and is a measure of the sharpness, or frequency selectivity of
a mechanical or electrical resonance. A high Q means a sharply tuned resonance and low
damping. Q is numerically equal to the resonant frequency divided by the difference in
frequency between the half power points, or the frequencies where the response is 3 dB
below the maximum.

Quasi-Periodic
A quasi-periodic signal is a deterministic signal whose frequency components are not a
harmonic series, but are nevertheless discrete frequencies. The vibration signal of a
machine which has non-synchronous components resembles a quasi-periodic signal.

Radial
Radial means in a direction toward the center of rotation of a shaft or rotor. In machine
vibration measurements, radial measurements are made with the transducer oriented so its
sensitive axis is in the radial direction. Radial measurements are best for detecting
imbalance in rotors.

Random
A random signal contains energy spread over a band of frequencies rather than concentrated
at discrete frequencies. Random signals are commonly called random noise, and a good
example is the noise heard on an FM radio receiver when tuned off station. Most vibration

signals from machines contain a certain amount of random noise in addition to the desired
vibration signature.

Rectangular Window
In the FFT analyzer, the rectangular window is actually no window at all. It is also called
rectangular weighting, or uniform weighting, and is selected when the signal to be analyzed
is a transient rather than a continuous signal. See also Hanning Window.

Resolution Bias Error


The FFT spectrum is a discrete spectrum, containing information only at the specific
frequencies that are decided upon by the FFT analyzer analysis parameters. The actual
spectrum of the analyzed signal may have peaks between the lines of the FFT spectrum,
and the peaks in the FFT spectrum will not be at exactly the correct frequencies. This is
called Resolution Bias Error, or the Picket Fence Effect. By a process of interpolation, it is
possible to increase the apparent resolution and amplitude accuracy of the FFT by a factor
of ten.

Resonance
A vibratory condition where a natural frequency and an excitation frequency coincide.
Resonance results in high vibration, and may reach damaging levels. It is of paramount
importance that a machine not be operated at a speed that corresponds to a natural
frequency of the structure!

Resonant Frequency
See Natural Frequency.

Response Spectrum
See Frequency Response.

Rigid Rotor
A rotor that does not deform significantly at its running speed.

RMS
RMS stands for Root Mean Square, and is a measure of the level of a signal. It is calculated
by squaring the instantaneous value of the signal, averaging the squared values over time,
and taking the square root of the average value. The RMS value is the value which is used
to calculate the energy or power in a signal. The RMS value of a sine wave is .707 times the
peak value, but the RMS value of a complex signal is difficult to predict without measuring
it. It is the accepted convention to measure the RMS value of acceleration when performing
vibration analysis of machines.

Roll Off, Rolloff


The attenuation of a high-pass or low-pass filter is called the roll off. The term is mostly
used for high-frequency attenuation.

Running Speed
The speed, usually expressed in revolutions per minute (rpm) at which a rotating machine
runs. It may also be expressed in Hz.

Runout
Runout, also called TIR for Total Indicator Reading, is the apparent radial motion of the
surface of a turning rotor or shaft. It can be caused by the part not being round, or it can be
caused because the center of rotation is not coincident with the geometric center of the part.
When a proximity probe is used to sense the position of a shaft, it reads the location of the
surface, and is therefore sensitive to runout, introducing an error in the measurement.

Scalar
A scalar quantity has magnitude only, as opposed to a vector, which has a direction and a
magnitude.

Seismic
Literally, seismic means caused by an earthquake, but in vibration instrumentation, it means
related to an inertial mass. A seismic transducer utilizes the inertia of a small mass to
generate a force when accelerated, or to generate a relative motion which is then sensed.
Examples are the piezoelectric accelerometer and the velocity transducer.

Selectivity
Selectivity is a measure of the narrowness of a band pass filter. The greater the selectivity,
the narrower, or more selective, the filter. The term is also used to describe the ability of a
radio receiver to separate transmitting stations that are close together on the dial.

Sensitivity
The sensitivity of a transducer is the numerical value of the output signal resulting from one
unit of the quantity being sensed. The sensitivity of a velocity transducer is expressed in
millivolts per inch per second, and the sensitivity of an accelerometer can be expressed in
millivolts per G or Pico coulombs per G. Typically, the sensitivity of a transducer will vary
significantly with frequency, and the purpose of the calibration of a transducer is to
determine this relationship and an accurate value of the sensitivity.

Shock
Mechanical shock is a non-periodic, or transient, excitation of a mechanical system, and it
typically excites all or most of the system resonances.

Shock Pulse Meter


The Shock Pulse Meter is a proprietary device which evaluates rolling element bearing
condition by very high frequency vibration. It uses a resonant transducer, and relies on the
excitation of the resonance by the bearing vibration signal.

Shorting Ring
The shorting ring is the circular conductor, usually of copper or aluminum, which
electrically connects the ends of the rotor bars in induction motors. There are two shorting
rings -- one at each end of the rotor. One of the problem areas in induction motors is the
degradation of the shorting rings, causing loss of torque and heating of the rotor.

SI
SI stands for Systme Internationale, which is the successor to the metric system of weights
and measures. The United States has the distinction of being the only industrial country in
the world which does not use it.

Sidebands
Sidebands are spectral components that are the result of amplitude or frequency
modulation. The frequency spacing of the sidebands is equal to the modulating frequency,
and this fact is used in diagnosing machine problems by examining sideband families in the
vibration spectrum. For instance, a defective gear will exhibit sidebands at the gear rpm
around the gear mesh frequency.

Signal
In vibration analysis, a signal is an electric voltage or current which is an analog of the
vibration being measured. The signal is usually meant to be the desired part of the quantity,
and the accompanying undesired part is called noise. The signal to noise ratio is an
important parameter in any measurement system.

Signal Conditioning
Signal conditioning is the manipulation of a signal from a transducer by such instruments
as preamplifiers, filters, etc., in preparation for its final destination, which might be an FFT
analyzer or recording device.

Signature
The signature, usually called the vibration signature, is the overall pattern of a vibration of
a machine. It is said that the vibration signature contains more information about the
machine than any other non-destructive test can discover.

Single Degree of Freedom


A single degree of freedom system is the simplest mechanical system possible. It can move
by translation along one direction only, or can rotate about one axis. The motion of a single
degree of freedom system is a sinusoid, having only a single frequency. Mechanical
structures are always more complex than the single degree of freedom system, but they can
be though of a being built up of a collection of single degree of freedom systems. This is
somewhat analogous to a complex waveform being considered as a collection of sinusoidal
components. The disciplines of modal analysis and finite element modeling treat
mechanical systems in this way, and the number of degrees of freedom they possess
determines their complexity.

Simple Harmonic Motion

Simple harmonic motion is the simplest possible motion of a vibrating system, and it
consists of a single frequency at constant amplitude. An example of simple harmonic
motion is a mass oscillating up and down on a spring. The waveform of simple harmonic
motion is a sine wave. A single degree of freedom mechanical system would exhibit simple
harmonic motion.

Sine Wave
A sine wave, also called a sinusoid, is the graph of the mathematical sine function from
trigonometry. It consists of a single frequency at constant amplitude. A mechanical system
of one degree of freedom would vibrate with a sinusoidal wave form, but this is never
found in the real world.
Sine Wave

Sinusoid
See sine wave.

Ski Slope
In a vibration spectrum, a "ski slope" is an artifact consisting of rising very low-frequency
content. It could be the result of actual data, but this is rare. It is usually caused by a
problem with the vibration transducer, such as a temperature transient or a loose mounting.
When applying power to an ICP accelerometer, you have to wait until the circuitry is
stabilized before taking data., This usually takes about 10 seconds or so. Another cause can
be noise introduced by the integration process if the spectrum is velocity derived from
acceleration. When you see a ski slope, it is a good idea to look at the time wave form and
see if there is an exponentially sloping curve extending over the entire time record. This
indicates an instrumentation problem, usually not enough time delay between applying
power to the transducer and the taking of the data.
Slip is the difference between the actual speed of an induction motor and the synchronous
speed, which is the speed at which a similarly wound synchronous motor would run. For
instance, the slip of a motor turning 1760 RPM would be 1800 - 1760 = 40 RPM. The slip
is dependent on the load on the motor, greater loads producing more slip, and hence lower
speeds.

Slip Cycle
The slip cycle of an induction motor is the synchronous speed divided by the slip. For
instance, a motor turning 1740 RPM would have a slip cycle of 1800 60 = 30. This means

that every thirty revolutions, the rotor will be in the same relationship with the rotating
magnetic field inside the stator. In other words, it takes thirty revolutions of the rotor for the
magnetic field to migrate all the way around it. If there is a discontinuity in the rotor, such
as a broken rotor bar, it will encounter the maximum of magnetic force twice each slip
cycle, once for the North end of the rotating pole, and once for the South end.

Spectra
Spectra is the plural of spectrum.

Spectrum
The spectrum is the result of transforming a signal from the time domain to the frequency
domain. It is the decomposition of a time signal into a collection of sine waves. The plural
of spectrum is spectra. Spectrum analysis is the procedure of doing the transformation, and
it is most commonly done with an FFT analyzer.

Spectrum Analyzer
A spectrum analyzer converts a signal from the time domain into the frequency domain,
and the FFT analyzer is the most common type today.

Spike Energy
Spike energy is a measurement of acceleration in a high-frequency range, usually to 20
kHz, for the detection of rolling element bearing problems. The name is a trademark of the
IRD company, but the technique is generic.

Squirrel Cage Motor


Another term for Induction Motor, which comes from the resemblance of the rotor bar
assembly to a rotating cage used to exercise pet squirrels.

Standard Deviation
In a vibrating quantity, the instantaneous deviation from the equilibrium position, if
considered over a long time interval, will have an average, or mean value. If these
deviation values are squared and then averaged, the result is called the variance of the
vibration. The square root of the variance is defined as the standard deviation of the

vibration. It can be thought of as the RMS value of the deviation. A vibration with a small
standard deviation never strays very far from its equilibrium position, while one with a
large standard deviation does make larger excursions.

Stationary Signal
A stationary signal is a signal whose average statistical properties over time are constant,
and it can be deterministic or not. In general, the vibration signatures of rotating machines
are stationary.

Strain
Strain is physical stretching of a mechanical member as a result of an applied force. The
amount of resultant strain for a given force depends on the stiffness of the material. Strain
is a dimensionless quantity, usually expressed in "micro strain", i.e. micro inches per inch,
etc.

Strain Gage
A strain gage is a small transducer that measures strain. It consists of a series of fine wires,
or other conductors, which are glued to the surface being measured. Strain in the material
stretches the wires and reduces their resistance, and this change in resistance is sensed by
an external circuit that outputs a voltage proportional to the strain. Strain gages are used
extensively in mechanical structural testing.

Sub harmonic
Sub harmonics are synchronous components in a spectrum that are multiples of 1/2, 1/3, or
1/4 of the frequency of the primary fundamental. They are sometimes called "subsynchronous" components. In the vibration signature of a rotating machine, there will
normally be a component at the turning speed along with several harmonics of the turning
speed. If there is sufficient looseness in the machine so that some parts are rattling, the
spectrum will usually contain sub harmonics. Harmonics of one-half turning speed are
called "one-half order sub harmonics", etc.

Sub synchronous
See Sub-Harmonic.

Synchronous
Synchronous literally means "at the same time", but in spectrum analysis, synchronous
components are defined as spectral components which are integral multiples, or harmonics,
of a fundamental frequency. They may in some cases exist as multiples of an integral
fraction of the fundamental frequency, in which case they are called sub harmonics.

Synchronous Averaging
A type of signal averaging where successive records of the time wave form are averaged
together. This is also know as time domain averaging. The important criterion is that the
start of each time record must be triggered from a repetitive event in the signal, such as 1X
rpm. The triggering assures that the phase of the wave form components that are
synchronized with the trigger are the same in each record. Then in the averaging process,
these in-phase components will add together while the rest of the signal components will
gradually average out because of their random relative phases. The technique is excellent
for extracting signals from noisy environments.

Tangential
In measuring tri-axial vibration in rotating machines, one of the sensitive axes of the
transducer is tangent to the rotating shaft in question. It is perpendicular to the radial
transducer, which is a direction toward and away from the center of the shaft.

Temperature Transient
When a piezo-electric accelerometer is subjected to a different temperature, as will be the
case when it is attached to a hot surface, it will take a certain time before the active
elements reach a constant temperature. During this time, the accelerometer will produce a
slowly varying output voltage that can be relatively large. If it is connected to a spectrum
analyzer or other instrumentation, the measured vibration signal will be contaminated with
this low-frequency noise component. The usual result is a so-called "ski-slope" at the low
end of the frequency scale. In some accelerometers, especially of the compression type, the
temperature transient is so large that the internal preamplifier is momentarily overloaded,
causing gross distortion of the data.
Whenever an accelerometer is mounted to a surface having a different temperature than the
accelerometer itself, you should wait a half-minute or so to be sure the temperature
transient has died away before taking any vibration data.

Thermography

Thermography is the art and science of utilizing infrared sensing devices to determine the
surface temperature distribution of a device that may not be readily accessible. Typically,
an infrared video camera is used, and the video image is digitized and fed into a computer
that assigns different colors to different temperatures so one can see at a glance if there are
hot spots in the device. Thermography is extensively used to check electrical breaker
panels, fuses, etc., for local heating.

Thrust
Thrust is a force in the axial direction of a rotating shaft or part. If significant thrust forces
are generated in rotating equipment, such as is the case in a vertically mounted motor/pump
assembly, a special thrust bearing is required to bear the thrust load. The term is sometimes
misused to refer to axial motion of a shaft.

Time Domain
Vibration is an oscillation in position as a function of time, and is said to exist in the time
domain. The signal from a transducer is also in the time domain, and when it is displayed
on the screen of an oscilloscope, it is called a wave form. Although most diagnosis of
machine vibration problems is done via spectrum analysis, some types of information are
more easily seen in the wave form; for example when looking at repetitive impacting in a
rolling element bearing.

TIR
Short for Total Indicator Reading. See Runout.

Tone
A signal at a specific frequency, which would be heard as a specific musical pitch, is called
a tone, by analogy with music. Sometimes a peak in a spectrum is also called a tone, such
as a "bearing tone".

Torque
Torque is defined as a force that causes rotation about a centerline. The rotational force
exerted on a shaft by an electric motor is a torque.

Torsional Resonance

A torsional resonance is a resonance where the spring is the twisting of a shaft and the mass
is polar inertia of a component connected to the shaft, such as a coupling or a rotor of some
type. Torsional resonances occur when a torsional natural frequency corresponds to a
torsion excitation frequency, and can result in high levels of torsional vibration. They can
cause severe damage to rotating machines.

Torsional Vibration
Torsional vibration is an oscillation of angular position about a centerline, and is caused by
oscillating torque forces. For instance, a motor coupled to a shaft that is driving a pinion
gear in a gearbox will experience a torque variation as each tooth meshes with the tooth of
the other gear. This causes a torsional vibration to exist in the shaft. It is important to see to
it that such forces do not occur near the frequencies of torsional resonances, or the vibration
levels can be very high.

Transducer
A transducer is a device that converts one type of energy, such as vibration or sound, into a
different type of energy, usually an electric current or voltage. Transducers are the hearts of
instrumentation systems, and are usually also the weakest links. They contribute noise to
the measured signals and also generate distortion because of non-linearities. They are
subject to changes in their sensitivity, and therefore require regular calibration. Some types
of transducer are much more reliable and linear than others; an example is the piezoelectric
accelerometer, which is by far the best type for general vibration measurement.

Transient
A transient is a signal or waveform which begins at zero amplitude, lasts for a certain time,
and ends at zero amplitude. An example is the sound of a gunshot, or the vibration due to a
hammer blow. When transients are subjected to spectrum analysis, they usually do not
generate a harmonic series, but generate a continuous spectrum where the energy is
smeared out over frequency. When analyzing transients with an FFT analyzer, care must be
taken that the entire transient is included in the time record of the analyzer, and also that the
rectangular window rather than the Hanning window be used.

Transform
A transform is a mathematical operation that converts a function from one domain to
another with no loss of information. For example, the Fourier transform converts a function
of time into a function of frequency.

Transmission Loss
See attenuation.

Trend
A trend is a plot of vibration level versus elapsed time. The trend is made by most
vibration monitoring software from stored vibration data, and is usually designed to display
the vibration level at certain important frequencies over a period of several months or years.

Trial Weight
In the performance of balancing, which is the determination of the magnitude and location
of balance weights for a rotor, it is the usual practice to attach a known trial weight to the
rotor and to measure the change in vibration level and phase that it causes.

Triaxial
Literally, with three axes. The vibration transducers often used by machine vibration
measurement systems consist of three accelerometers oriented at 90 from each other
enclosed in a single housing. This is called a triaxial accelerometer.

Trigger
A trigger is an electrical impulse that is used to initiate a process, such as data collection
with an FFT analyzer or oscilloscope. The trigger can be generated by a machine event
such as a once per revolution tachometer pulse, or can be generated manually. The once
per rev trigger is essential in performing time synchronous averaging of vibration spectra.

True RMS
True RMS is the actual RMS value of a signal as calculated by squaring the signal level
instantaneously, averaging the squared values, and taking the square root of the average,
and this is what is done in a true RMS meter. In the case of a sine wave, the RMS value is
1.11 times the average value, and many AC voltmeters use this relationship to calculate the
RMS value from the average value, which is much easier to sense. This works only with
sine waves, so such meters give the wrong answer when measuring any other wave forms.

Tunable Filter

A tunable filter is simply a filter whose cutoff frequencies, either high pass, low pass, or
band pass, are adjustable. The term comes from the practice of tuning musical instruments,
which is a frequency adjustment. Someone once said that a tunable filter is a filter that is
never at the correct frequency.

Turning Speed
In a rotating machine, the turning speed is the frequency of rotation, and it can be expressed
in Hz, or RPM. In vibration analyst slang, the turning speed is called "1 X", the second
harmonic "2 X", etc.

Uniform window
The same as rectangular window.

Vane Pass Frequency


In a centrifugal pump or a fan, the vane pass frequency is the number of fan blades or
impeller vanes times the turning speed of the rotor. The vane pass always shows up as a
relatively strong component in the vibration spectrum of a pump or fan. Thus, a pump with
7 vanes will have a spectral component at 7 times the RPM, or "7 X".

Vector
A vector quantity is a quantity that has a direction as well as a magnitude. For example a
thrust is a vector, as it is a force in the axial direction on shaft or rotor.

Velocity
Velocity is defined as the time rate of change of position, and has units of distance per unit
time. In vibration signals, velocity is also the rate of change of displacement, and is
expressed usually in inches per second or millimeters per second. Velocity is also the time
integral of acceleration, and it is often calculated in practice by integrating acceleration.

Velocity Transducer
The velocity transducer is one of the oldest types of vibration transducer, and even though
it has many drawbacks, is still in fairly common use. It is a seismic transducer that contains
either a moving coil of wire in a magnetic field, or a moving magnet inside a coil of wire.

The velocity transducer has moving parts, and is therefore subject to wear. It requires
frequent calibration, and its response depends on temperature and the orientation of the
transducer. Its frequency response extends from about 15 Hz to 1500 Hz, and its phase
response can be erratic, especially at low frequencies.
A newer type of velocity transducer, called a "velometer", consists of a piezoelectric
accelerometer with a built-in integrator to convert the signal to velocity, and it is much
better in all respects than the traditional velocity transducer.

Vibration
Vibration is the oscillation of a point, an object, or a part of an object around a fixed
reference, or rest, position. An object can vibrate as a unit, in which case it is called "whole
body vibration", or, as is usually the case, an object can vibrate in a complex way where it
deforms and different parts of it vibrate at different frequencies and amplitudes.

Vibration signature
The vibration signature of a machine is the characteristic pattern of vibration it generates
while it is in operation. The actual signal from a vibration transducer can be considered the
signature, but the spectrum of the vibration signal is usually referred to as the signature. It
has been said that of all the non-destructive tests that can be made on a machine, the one
containing the most information is the vibration signature.

Viscous Damping
Viscous damping is a type of mechanical damping where the damping force is proportional
to the velocity of vibration, as opposed to Coulomb damping, where the damping force is
constant. A good example of viscous damping is the damping provided by the shock
absorbers in cars. Most mechanical systems exhibit a combination of the two types of
damping.

Vortices
Vortices are eddies, or "whirlpools" sometimes formed at the ends of airplane wings, fan
blades, propeller blades, pump vanes, and the edges of other structures in a fluid flow.
Vortices absorb energy, and they cause turbulence and reduced efficiency in many fluid
handling machines. The vibration signature of a machine with turbulent flow will exhibit a
strong random component.

Wave
A wave is a disturbance propagated in a medium, and it results in local oscillatory motion
of the medium. Waves transmit energy in the medium, and travel at characteristic speeds
depending on the medium. The speed of sound is the speed of pressure wave propagation in
air. Sound waves are longitudinal waves, meaning that the direction of propagation is the
same as the direction of the oscillation of the medium. Ocean waves, on the other hand, are
an example of transverse waves, for the direction of wave transmission is at 90 degrees to
the direction of motion of the water; the energy moves horizontally, but a floating cork
simply moves up and down as the waves pass. Mechanical structures can have both kinds
of vibration waves, and they travel at different speeds, and the result is that most such
structures, when excited by a complex force, will vibrate in a very complicated pattern.

Waveform
The waveform is the shape of a time domain signal as seen on an oscilloscope screen. It is a
visual representation or graph of the instantaneous value of the signal plotted against time.
Inspection of the waveform can sometimes reveal information about the signal that the
spectrum of the signal does not show. For instance a sharp spike or impulse and a randomly
varying continuous signal can have spectra that look almost identical, while their
waveforms are completely different. In machine vibration, mechanical impacting usually
causes spikes, while random noise can be caused by the advanced stages of bearing
degradation.

Wavelength
The wavelength of a wave traveling in a medium is the distance in the medium spanned by
one repetition of the wave motion. The wavelength is the wave velocity divided by the
frequency of the waves. The velocity of wave motion is usually constant in a medium, and
the wavelength thus depends only on the frequency of the waves. The speed of a vibration
compression wave in steel is very fast, about 17 times as fast as the speed of sound in air,
and this means the wavelengths are extremely short.

Wear Particle Analysis


Wear particle analysis is a type of lubricating oil analysis where the particles found in the
oil are analyzed to see what process caused them to be there.

Weighting
See Hanning Window, and Window.

White Noise
White noise is defined as random noise that contains a constant energy at each frequency,
or more precisely, a uniform distribution of energy over the frequency spectrum. The noise
heard in an FM radio when tuned off station is approximately white noise.

Whole Body Motion


Whole body motion is the vibration of an object as a unit, where all parts of it are moving
in the same direction at the same time. An example is a mass oscillating up and down on
the end of a spring.

Window
The FFT analyzer does not operate in a continuous manner, but is instead a batch
processing device, taking samples of the time domain signal and transforming them into the
frequency domain. The time interval during which the signal is sampled and recorded is
called the window. In order to compensate for certain limitations of the FFT process, the
time data in the window is often multiplied by a weighting curve, such as a Hanning or
Flattop weighting. These weighting curves are also called Hanning window and flattop
window respectively.

X
Abbreviation for run speed. X refers to the speed of the shaft nearest the measurement
point, so a machine with more than one shaft will have several values of X.

Xm
Abbreviation for motor speed. See also X.

You might also like