You are on page 1of 3

Sheet No.

Roll No.

--------

B. Tech ( Semester l) Examination, 2013-14

( Code: ECT-103)

Subjet: Basic Electronics

Max Mark: 50

03 Hours

Note:
question shown in the
Answer five questions out of following. Marks allotted for each

l.

right hand margin.


please check the question
The candidates, before starting to write the solutiont should
the question
paper for any discrepancy, and also ensure that they have been delivered

fl.

paper of right course no. and right subied title'

1--fA practGG"*."-"r-d

represe.ted either as a voltage source or as current

Explain'
source. How can you convert one representation to the other?

I Differentiate following with suitable examples'

i)

I Active and Passive components.

ii)

I Dependent and lndependent sources.

2
2

iii) | Periodic and Non-periodic signals.

8f) resistor is considered a load and could


I A simplified circuit is given in fi8u.e 1. The
, model a loud speaker.

Compute the powe.

Pin

delivered tothe amplifier'

1
1

ii)

Figure 1

Statu and ptou" m"*imum power transfer theorem

2.a

the circuit to the


For the circuit of fi8ure 2, find the Norton equivalent for

Find the value of

RL

that can be absorbed

left of Rl'

for maximum power transfer' Compute the maximum power


bY

RL-

Compute RMS value and average value forfollowing signals'


i) Square

it

DC
4

State and prove Mdlm an's theorem.

3.a
b
c

example'
What is time constant? Explain its significance through one suitable
voltage is V2- Find
The circuit of figure 3 models an amplifier circuit in which output

the gain ot the amplifier. Assume p=70'

Figure 3

4-a
i)

Simplifo following switching functions.


2

f(x,Y,z)=x Y+xYz+x(Y+x

i0

f(x,y,z)-(x+y)(i+zXY+z)

iii)

f(x,y,z):xy+;+xyz(xY+z)

Showthat NAND and

NOR gates are

2
2

universalgates'

lmplement XOR operation using four NAND gates'

5.

I Lxplain the working of following flip flops wiih suitable diagram


D

5.a

ii0D

What is race around condition in JK flip flop? How it can be avoided?

Explain.

IS

Draw the logic diagram of modulo-8 ripple up colrnter with positive edge triggered | 5
JK

SR ii)r

flip flop and explain its operation.

I Draw the lo8ic diagram of decade counter with negative edge triggered JK flip flop | 5
and explain its operation and applications.

7. a

I Briefly explain five characteristics of an ideal operational amplifier- Compare ideal | 3


OPAMP with 1C741.

i Wtrat

is

ttre significance of CMRR in operationat amplifier? Explain.

i What

is

virtual ground

I Draw the circuit of a non inverting amplifier and derive the expression of output I

? How is

it different from actual ground in OpAMp circuit?

voltage.

c
8. a

i Draw the circuit of buffer and explain its significance.

I Derive the expression for output voltage of circuit shown in figure 4.

I Write short notes on the following.


i) Applications of OPAMP-

ii)Transient response of

RC

ci.cuits.

Figure

You might also like