Professional Documents
Culture Documents
CSDX6413S-A1
Make up Length
(ft):
2.44
2.750
8.000
Connection std:
Connection Size
(ins):
6.625
Connection Type:
Make up Torque
(ft-lbs):
47500
12 1/4"
14 1/4"
9 6250"
10 3/8"
Pilot Gauge
Length (ins):
100% TReX* cutters - Thermostable PDC cutters featuring a unique layer of thermostable PDCGeometry:
that is 200% more heat tolerant and 400% more abrasion resistant than premium PDC. The
Profile:
thermostable layer dramatically improves abrasion resistance by maintaining a sharp,
Reamer Gauge
slow-wearing, tough cutting edge. When a wearflat finally develops, the thermostable layer
wears more slowly than the multimodal polycrystalline diamond behind it, forming a sharp
Length (ins):
lip that maintains ROP. This allows the bit to drill significantly further and faster than
Geometry:
premium PDC cutter bits.
Profile:
Stabilizing Cutters cutters which are specially designed and placed to produce a
beneficial increase in cutting force. These cutters are used to reduce the bit imbalance
or to provide cutting forces that centralize the bit thus improving bit stability.
Blade Qty
Typically a bit will contain one stabilizing cutter per blade.
Pilot:
CSD* - Bicenter bits that have the capability to drill the cement and float equipment,
Reamer Full:
then drill a new hole section with a larger diameter than it passed through. These bits
Reamer Half:
reduce the number of bits used and trips required, saving significant time and money. The
CSDs patented design features not only allow it to drill out the casing equipment but
Body Materials
also demonstrate excellent directional control. The improved force balance (now comparable Pilot Body:
to standard PDC drill bits) allows the CSD to slide effectively during steering operations
Reamer Body:
on PDM.
IMPORTANT NOTE : If a motor is run behind a bicentre bit ALWAYS ensure that there is no
part of the motor that will cause pass though problems - even when using "slick" motors.
The size of the "slick sleeve or lower stabiliser thread protector" and wear pads on the
bearing housing can cause problems.
Cutting Structure
Straight
Flat
2.850
Straight
Flat
6
4
6
Steel
Steel
Pilot
Qty
Location
Dia(mm)
Shape
Primary
42
PILOT FACE
13
BULLET
Primary
PILOT FACE
13
STABILISING
Primary
11
PILOT TRIMMERS
13
BULLET
Reamer
Qty
Location
Dia(mm)
Shape
Primary
39
REAMER FACE
13
BULLET
Primary
REAMER FACE
13
STABILISING
Primary
REAMER GAGE
13
BULLET
Primary
REAMER GAGE
13
CHAMFERED
Primary
REAMER TRIMMERS
13
BULLET
2.3250
Copyright ReedHycalog
Pilot
Reamer
Qty
Type
Size
AAK
VARIABLE
Qty
Type
Size
AAK
VARIABLE