Professional Documents
Culture Documents
FACULTY OF ENGINEERING
MECHANICAL ENGINEERING DEPARTMENT
ME 313 HEAT TRANSFER
CHAPTER 7
EXAMPLES
1) Air at 27oC blows over a flat plate with a sharp leading edge at 1.5 m/s. Find the
boundary layer thickness 0.5 m from the leading edge. Check the boundary layer
assumption u>>v at the trailing edge.
2) Calculate the average shear stress and coefficient of friction for the previous example
if the total length L = 0.5 m. Compare w with w at the trailing edge. At what point on
the surface does w = w . Finally estimate what fraction of surface can legitimately be
analyzed using boundary layer theory?
3) Air at atmospheric pressure and T = 300 K flows with velocity u = 1.5 m/s along a
plate. Determine the distance from leading edge of plate where transition begins from
laminar to turbulent flow. Calculate the drag force F acting per 1 m width of plate over
the distance from x = 0 to where transition starts.
5) Air at 0oC and 1 atm flows at a velocity of 6 m/s across a rectangular plate at a uniform
temperature of 120oC. If the dimension of the plate perpendicular to flow is 2.5 m and
plate in the flow direction is 1 m, find:
a) local heat transfer coefficient at the trailing edge
b) the average heat transfer coefficient for the entire plate
c) convective heat transfer from the plate
6) Air at 20oC and moving at 15 m/s is heated by isothermal steam heated plate at 110oC,
m length and m width. Find the average heat transfer coefficient and total heat
transferred. What are h, , and at the trailing edge?
8) Figure given below shows a flat plat, 100 cm in length and 30 cm is width, which is
used as a heating element. Air at 20oC and 1 atm pressure flows over the plate with a
velocity of 6 m/s. The plate has unheated sections at both ends, each 25 cm in length, and
the heated section is maintained at 140oC. Calculate the total heat transfer rate from the
plate to the air.
T = 20oC
U = 6 m/s
100 cm
11) A circular pipe of 25 mm outside diameter is placed in an air stream at 25oC and 1
atm air. The air moves in cross flow over the pipe at 15 m/s while the outer surface of the
pipe is maintained at 100oC. (a) What is the drag force exerted on the pipe per unit length
(b) What is the rate of heat transfer from the pipe per unit length?
V = 15 m/s
air
25 mm
12) Air stream at 27oC moving at 0.3 m/s across 100 W incandescent bulb, glowing at
127oC. If the bulb is approximated by a 60 mm diameter sphere, estimate the heat transfer
rate
and
the
percentage
of
power
lost