Professional Documents
Culture Documents
a. 2
b. 1 and 2
c. 3
16.
17.Which is characteristics of synthetic base
hydraulic fluid
a. Low flash point
b. Low moisture retention
c. High flash point
18.
19.Characteristics of MIL-H- 5606 fluids are
a. Light purple color, phosphate ester base,
fire resistant, uses butyl rubber seals
b. Blue color, will burn, uses a natural
rubber seals
c. Red color, petroleum base, will burn,
synthetic seals
20.
21.Characteristics of MIL-H- 7644 hydraulic
fluids are
a. Blue color, vegetable base, , will
burn, natural rubber seals
b. Light purple color, phosphate ester
base, fire resistant, butyl rubber seal
c. Red color, petroleum base, will burn,
synthetic rubber seals
22.
23.
24.
25.
26.Which seals are used with petroleum base
hydraulic fluid
a. Buna-N
b. Butyl rubber
c. Polyester
27.
28. One of the main advantage of skydrol is its
a. Wide operating temperature
b. Inability to mix with water
c. High operating pressure
29.
30. Hydraulic system relief valve are set to open
at
a. Lower pressure than the system
pressure regulator
b. Lower pressure than the system relief
valve
c. Higher pressure than the system
relief valve
31.
32. How many of these seals are used with
petroleum base hydraulic fluid? 1. Synthetic
rubber 2. Natural rubber. 3. Three
a. Two
b. Three
c. One
33.
34. Before removing the filler cap of a
pressurized hydraulic reservoir
a. Relieve the hydraulic system
pressure
b. Relieve the air pressure
c. Actuate several components in the
system
35.
36. A unit which transforms hydraulic pressure
in to linear motion is called
a. An accumulator
b. An actuating cylinder
c. A hydraulic pump
37.
38. The air that is expanded and no longer
needed when an actuating unit is operated
in a pneumatic system is
a. Returned to the compressor
b. Exhausted or dumped, usually
overboard
c. Charged or pressurized for use during
the next operating cycle
39.
44.