Professional Documents
Culture Documents
4. In order to get uniform thickness of the plate by rolling process, one provides
(A) Camber on the rolls
(B) Offset on the rolls
(C) Hardening of the rolls
(D) Antifriction bearings
Correct Answer
7. A casting defect which occurs near the ingates as rough lumps on the surface of a
casting is known as
(A) Shift
(B) Sand wash
(C) Swell
(D) Scab
Correct Answer
9. The operation of cutting a cylindrical hole in a sheet of metal by the punch and die is
called
(A) Shearing
(B) Piercing
(C) Punching
(D) Blanking
Correct Answer
10. In arc welding, the electric arc is produced between the work and the electrode by
(A) Voltage
(B) Flow of current
(C) Contact resistance
(D) All of these
Correct Answer
13. The property of sand due to which it evolves a great amount of steam and other
gases is called
(A) Collapsibility
(B) Permeability
(C) Cohesiveness
(D) Adhesiveness
Correct Answer
14. In backhand welding, the angle between the welding torch and the work is kept as
(A) 30-40
(B) 40-50
(C) 50-60
(D) 60-70
Correct Answer
(A) 1800C
(B) 2100C
(C) 2400C
(D) 3200C
Correct Answer
4. In order to get uniform thickness of the plate by rolling process, one provides
(A) Camber on the rolls
(B) Offset on the rolls
(C) Hardening of the rolls
(D) Antifriction bearings
Correct Answer
7. A casting defect which occurs near the ingates as rough lumps on the surface of a
casting is known as
(A) Shift
(B) Sand wash
(C) Swell
(D) Scab
Correct Answer
9. The operation of cutting a cylindrical hole in a sheet of metal by the punch and die is
called
(A) Shearing
(B) Piercing
(C) Punching
(D) Blanking
Correct Answer
10. In arc welding, the electric arc is produced between the work and the electrode by
(A) Voltage
(B) Flow of current
(C) Contact resistance
(D) All of these
Correct Answer
13. The property of sand due to which it evolves a great amount of steam and other
gases is called
(A) Collapsibility
(B) Permeability
(C) Cohesiveness
(D) Adhesiveness
Correct Answer
14. In backhand welding, the angle between the welding torch and the work is kept as
(A) 30-40
(B) 40-50
(C) 50-60
(D) 60-70
Correct Answer