Professional Documents
Culture Documents
Range
specification covers three Type
Heat Treatment
Product Analysis
Tension Test
Flattening Test
Hydro Test
NDT
Weight (Mass)
Diameter
Thickness
End finish
Min 5S.
Pressure not exceed 2500 psi [17 200 kPa]
for pipe NPS 3 [DN 80] or smaller, or 2800
psi [19 300 kPa] for pipe larger than NPS 3
[DN 80];
weld seam of each length of electricresistancewelded
pipe NPS 2 [DN 50] or larger shall be tested
with a
nondestructive electric test
Calibration not more than 8 h to
demonstrate
its effectiveness and the inspection
procedures
+ 10 %
For pipe NPS 112 [DN 40] or smaller, the
outside diameter at any point shall not
vary more than 6 164 in.[0.4 mm] from the
specified outside diameter. For pipe NPS
2[DN 50] or larger, the outside diameter
shall not vary more than 6 1 % from the
specified outside diameter.
The minimum wall thickness at any point
shall be not more than 12.5 % under the
specified wall
thickness.
Pipe of standard-weight or extra-strong
weight, or
in wall thickness less than 0.500 in. [12.7
mm], other than double extra-strong
weight pipe, shall be plain-end bevelled
with ends beveled to an angle of 30, +5,
Repair
Retest
Length
Galvanized Pipe