Professional Documents
Culture Documents
Glycolysis itself results in a net gain of 2 ATP and 2 NADH per glucose consumed; this plus the
oxidation of the two pyruvates yields a total of 30-32 ATP per glucose. This combination makes
glucose a good energy source to support cell growth.
However the process shown above is strictly dependent on availability of oxygen, which is required
so that NADH can be recycled by oxidative phosphorylation.
Oxidative phosphorylation generates most of the ATP produced.
As pyruvate is converted to lactate, an equivalent number of NAD+ are produced, maintaining a balance
with glyceraldehyde-3-P dehydrodenase in glycolysis. However, only two ATP can be produced per
glucose, so high glucose consumption is necessary to keep up with energy demands.
An additional problem is the production of H+ so that anaerobic glucose consumption results in
acidification. As a result animals can only maintain anaerobic glycolysis for a short time. Some acid
tolerant bacteria can maintain growth by secreting lactate to the medium, as happens when milk goes
sour.
Yeast provides a better solution to the problem of recycling NADH, through the enzyme pyruvate
decarboxylase (A). This converts pyruvate to acetaldehyde by releasing CO2 , which is a non-acidic
product. Acetaldehyde can then be reduced to ethanol by alcohol dehydrogenase (B), which
consumes NADH and releases NAD+ so that glycolysis can continue.
A major advantage is that the final products are neutral, so that acidification is no longer a problem.
Since yeast lacks a central nervous system to fall under the adverse influence, significant amounts of
ethanol can accumulate while maintaining good growth rates. Also since ethanol can permeate the
cell membrane, ethanol can accumulate in the medium and not just in cell cytoplasm.
Pyruvate decarboxylase acts by reaction of pyruvate with thiamine pyrophosphate, displacing CO2 .
This is very similar to the action of subunit E1 of pyruvate dehydrogenase. The difference is that
pyruvate decarboxylase releases the acetaldhyde product whereas pyruvate dehydrogenase continues
reaction by an oxidative attack of lipoamide so that acetyl-CoA is produced.
ATP is produced at a low rate, 2 ATP per mole of glucose and per 2 moles of ethanol
produced so that substrate is rapidly converted to product to provide the energy needs of cell
growth.
Ethanol can escape into the medium rather than accumulating in the cell. This makes
recovery of the product easier.
Pure ethanol has to be recovered by distillation, which could represent the most expensive component
of the production process. In tropical countries, solar distillation is possible making ethanol production
economically viable.
Yield considerations.
1 tonne of glucose can be converted into a bit less than 0.5 tonne of ethanol. The reason for
this is very simple. The molar mass of glucose is 180 g mol-1, ethanol is 46 g mol-1 and CO2 is 44 g
mol-1.
glucose d 2 ethanol + 2 CO2
C6 H12 O6
2 C2 H6 O
180 g
92 g
88 g