You are on page 1of 10

Brought to you by

2016

ANTENNA SURVEY
After choosing the most appropriate receiver for your application from the Receiver Survey
in the January issue of GPS World, you may need an antenna, too. We have collected key
specifications for 320 antennas from 30 manufacturers.

We publish the Antenna Survey each year in our February issue. To recommend improvements
or to be listed in the survey next year, please email gpsworld@gpsworld.com.

FOOTNOTES
1

User environment and applications:














A = aviation
D = defense
E = meteorology
G = survey/GIS
L = land
M = marine
N = navigation
O =
other
P =
other position reporting
R =
real-time DGPS reference
S =
space
T =
timing
V =
vehicle/vessel tracking

GPS L1 frequency 1575.42 MHz


GPS L2 frequency 1227.60 MHz

ABBREVIATIONS
3

A single voltage standing wave ratio


(VSWR) figure indicates a combined
antenna and amplifier.

Noise figure is expressed in maximum


decibels.

L/D = lightning/diode.


cm: centimeter

dB: decibel

: diameter

ft: foot

g: force of gravity

g: gram

Hz: hertz

in: inch

kg: kilogram

lb: pound

m: meter

mA: milliampere

max: maximum

MHz: megahertz

min: minimum

mm: millimeter

na: not applicable

nr: no response

qty: quantity

RHCP: right-hand circular
polarization

typ: typical

ANTENNA SURVEY 2016

sponsored by

A WORD FROM OUR SPONSOR

S2 G P S W O R L D

WWW.GPSWORLD.COM

FEBRUARY 2016

Survey
GIS
Reference Station
Aviation/Aerial Survey
Marine
Construction/Mining
Precision Agriculture
Vehicle Tracking
Dock Operations
Unmanned Aircraft
Unmanned Vehicle
Timing

FEBRUARY 2016

Extended
Temperature Range
Small Form-factor/
Lightweight
High Altitude
Operation

TSO/FAA Certification

Pole Mount

Magnetic/Surface
Mount

Desirable Feature
High Multipath
Suppression

Positioning errors are caused by multipath, which is multiple reflections of


the GNSS signal off of nearby or far
objects.
Multipath degrades the positioning
accuracy and should be suppressed.
For optimum multipath rejection, an
antenna should be mounted as close to
the horizontal surface as possible and
away from reflecting objects including
water, antenna masts, air conditioners,
ventilation shafts, etc.

Plot of Good and Poor


Antenna Phase Center Variation over
Elevation Angle

Corrosion Resistant

Very important. Gain roll-off is a factor


of beamwidth and specifies how much
the gain changes over the elevation
angle of the antenna. From the antennas
point of view the satellites rise from the
horizon towards zenith and fall back
to the horizon. The variation in gain
between zenith (directly overhead) and
the horizon is known as the gain roll-off.
Different antenna technologies have
different gain roll-off characteristics.
Patch antennas can track down to low

Plot of Good and Poor


Antenna Phase Center Offset over
Elevation Angle

Weatherproof

Why should I be concerned about


multipath rejection?

The phase center of the antenna is the


point where the signals transmitted
from satellites are collected. When
your receiver reports a location fix, that
location is essentially the phase centre
of the antenna.
If you are specifying an antenna for
use with geodetic survey or a reference
station application, phase center offset
(PCO) and phase centre stability or
variation (PCV) are important. The
electrical phase center of any antenna
will vary with the position of the transmitting signal it is receiving by as much
as a few millimetres. As GNSS satellites
move across the sky, the electrical phase
center of the signal received will typically move with the satellite position
unless the antenna has been carefully
designed to minimize PCO/PCV.
The Phase Center Offset with respect to the antenna reference point
(ARP) is the difference between the
mechanical center of antenna rotation
and electrical phase center location.
The PCO is also frequency dependent
which means that there can be a different offset for each signal frequency.
The Phase Center Variation identifies
how much the phase center moves with
respect to the satellite elevation angles.

Narrow Bandwidth

How important is antenna


beamwidth and gain roll-off?

What is phase center stability and


why is it important?

Multi Frequency
(RTK)
L-band frequency
(Correction Services)

The element gain defines how efficient


the antenna element is at receiving the
signals. In any signal chain, you are
only as good as the weakest link, so an
antenna element with low element gain
might be compensated by an increased
low noise amplifier gain, but the signal
to noise ratio or C/N0 is degraded.

The voltage standing wave ratio or


VSWR is a measure of how much power
is reflected back upon the transmission
line (coaxial cable between receiver and
antenna) and indicates how well the
antenna is matched to a specific impedance, typically 50 ohms. An ideal VSWR
of 1 indicates that a perfect match exists
and that no power is reflected back from
the antenna.

Why is element gain so important?

Depending on the application, an antenna may have to meet certain environmental, mechanical, and operational
requirements.
GNSS Antenna is characterized by
several metrics: gain, gain roll-off,
multipath rejection, axial ratio, bandwidth, PCO, PCV.
Gain is not necessarily the most
important metric; various antenna
parameters can impact positioning
accuracy.
Survey, PPP positioning using L-band
delivered corrections, and Heading
applications are shown to be impacted by antenna selection.
A well-designed antenna is a critical
part of a GNSS System.
The table below highlights some of
the important desirable features needed
for a GNSS antenna based upon the
users application.
Go to novatel.com/antennas to learn
more.

Multi Constellation

What is VSWR?

error translates to a 10-15% error in


reported position. For RTK survey
applications, geodetic grade antennas
such as the NovAtel GPS-70x and
Antcom G8 series offer superior PCO/
PCV performance. For reference station applications a NovAtel GNSS-750
antenna is ideal.

What are the requirements for my


application?

Rugged

Noise figure directly impacts the C/N0


of the GNSS receiver. The lower the
overall noise figure the better the C/N0
and tracking capability.
The noise figure is the difference
between the signal-to-noise ratio at the
input and output of the receiver and
identifies how much additional noise
is being added into the signal through
the system or its individual components
such as the low noise amplifier. Good
antennas will have a noise figure less
than 3dB.

Many users can accept accuracies


of less than a metre so these small
phase center variations cause a negligible amount of position error. But
if you require high precision, Real
Time Kinematic (RTK) receivers can
achieve position accuracies of 2-4 cm
and a few millimetres of phase center

Single Frequency

Active GNSS constellations include


GPS, GLONASS, Galileo, QZSS and
BeiDou. Position correction services,
known as Space Based Augmentation
Services (SBAS), transmit on geostationary satellites in orbit around the
earth.
Each of the constellations and SBAS
have their own signal frequencies
and bandwidths, some of these frequencies are shared (e.g. GPS L1,
WAAS (SBAS), Galileo E1). Multiple
frequency antennas are used to help
correct for ionospheric errors in RTK
applications.
The signal bandwidth of your antenna is important as many GNSS
receivers take advantage of the full
signal power transmitted. NovAtels
GNSS receivers utilizes a patented
Pulse Aperture Correlator technology (PAC) which uses a wider signal bandwidth to mitigate position
errors caused by multipath and can
support precision carrier phase RTK
algorithms with centimetre accuracy.
Other basic GNSS receivers only look
at the constellations coarse acquisition
(C/A) code and only require a narrow
bandwidth of a few MHz and as such
are restricted to positional accuracies
of a few metres.

What is Noise Figure?

Choke ring antennas offer high multipath rejection due to their unique
concentric ring design that block out
multipath signal reflections to the antenna element.
The Axial Ratio also defines the antennas ability to reject multipath-generated replicas of the original GPS signal.
A good GNSS antenna provides a low
axial ratio not only at each of the GNSS
frequencies, but also over all elevations
angles of the satellites in view. NovAtels
GPS-700 series of antennas maintains
an axial ratio as low as 3dB at azimuth
or horizon.

High Vibration

What GNSS constellations and


signals do I want to receive?

Gain is one of the key performance indicators of a GNSS antenna. A minimum


gain is required to achieve a minimum
C/N0 (carrier-to-power-noise ratio) to
track the GNSS satellites. The antenna
gain is directly related to the overall C/
N0 of the navigation GNSS receivers.
Hence, antenna gain helps define the
tracking ability of the system.
GNSS receiver manufacturers will
typically specify the expected RF input
level required for optimum performance. This level is important to avoid
underdriving (causing poor C/N0) or
overdriving (causing limiting or distortion) the front end of the receiver. Nearly
all receivers have automatic gain control,
but there is only so much dynamic
range in the system and the antenna
gain, including cable losses, needs to be
considered carefully.

elevation angles such as 10 degrees.


Most choke ring antennas will typically
not receive signals below 30 degrees with
the exception of NovAtels GNSS-750
which can track down to and below
the horizon.

Low PCO/PCV

The antenna you choose must match


your receivers capabilities and specifications. Since the antenna behaves
both as a spatial and a frequency filter,
it will have significant impact on the
performance of the GNSS receiver.
Choose an antenna that covers the
signal frequencies transmitted by the
constellation and bandwidth supported by your GNSS receiver. Your
application will also help determine
form factor and antenna performance.

What amount of antenna gain do I


need?

Low Profile

Where do you start?

Ultra-low PCO/PCV

Selecting the Right GNSS Antenna

WWW.GPSWORLD.COM

G P S W O R L D S3

ANTENNA SURVEY 2016

sponsored by

Manufacturer

Model

Intro. Date

User Environment 1

Size: Length x Width


x Height

Weight

Frequency/Bandwidth 2

VSWR 3

Axial Ratio
(dB)

Gain/Gain with
Amplifier (dB)

Pattern

Noise Figure
(dB) 4

Amplifier DC Voltage Amplifier Current


(mA)

Operating Temperature
(C)

AEI
www.GPSantennas.com

GPS-SMA

2008

All interior/exterior

43 x 33 x 14mm

100g

1575.42 MHz

2:01

2dBi

253 dB

RHCP

1.5 dB

3~5V

8~15mA

40 to +85C

GPS, GSM & WIFI Dual & Triway


Antennas

2009

All interior/exterior

D80 x H15mm

165g

1575.42 MHz / 824 MHz~894


MHz / 1710 MHz~1990 MHz /
2400~2500 MHz

2:01

2dBi

253 dB

RHCP

1.5 dB

3~5V

8~15mA

40 to +85C

GPSMRS232, GPSMUSB

2008

All interior/exterior

H14 x W32 x L43mm

135g

1575.42 MHz

2:01

3dBi

253 dB

RHCP

1.5 dB

5V

5mA

GPS GSM Jamming signal detector,


AE-55SP

2014

Detects GPS GSM


Jamming Equipment
and triggers gps
panic button

L 9 x W 5 x T 1.7 cm

65g

50 MHz
6.0 GHz

12V ~ 24V DC

AT1675-7 L1/L2 GPS & GLONASS

2007

7.25 x 3.20in

1.36lb

1590 25 & 1238


21.5 MHz

2.0:1

3 dB Max @
Boresight

38 dB

RHCP

2.4 dB Max

AT1675-8 GPS/GLONASS L1
-BEIDOU B3/ B1

2009

4.70 x 3.00 x .75in

8oz

1268 12 MHz & 1590


125MHz

2.0:1

as above

42 dB

RHCP

AT1675-17 GPS/GNSS Antenna

2000

AG

4.70 x 3.0 x .75in

8oz

1590 25 & 1238


21.5 MHz

2.0:1

as above

26 & 40 dB

RHCP

AT1675-19, GPS/GLONASS L1

2010

LD

2.20 x .57in

75g

1565-1607 MHz

2.0:1

as above

26 dB

AT1675-32 GPS/GNSS Antenna

2009

LG

5.75 x 2.46in

1.00lb

157045 & 1164-1260 MHz

2.0:1

as above

AT1675-80 (TSO ) GPS/GNSS/LBand Antenna

2008

AG

4.70 x 3.0 x .92in

10oz

1570 45 & 1238 21.5 MHz

1.5:1

AT1675-116

2010

LG

3.5 x .84in

200g

1551 -1615 MHz

AT1675-120 GPS/GNSS
Choke Ring

2009

LG

14 x 13in

11.00lb

AT1675-180 GNSS Airborne


Antenna, Iridium Protected

2011

4.31 x 1.46 x 5.55in

AT1675-182 GPS/GNSS Antenna

2009

LG

5.75 x 2.46in

AT1675-219 GNSS Antenna

2014

4.45 x 1.43in

AT1675-286 GNSS Marine

2014

5.64 x 3.79in

AT1675-257, GPS e Glomass


Embedded Antenna

2014

1.35 x 1.35 x .54in

AT1675-300, GNSS Choke Ring


Antenna

2014

14.70 x 13.77in

AT1675-460, GNSS Antenna,


Inmarsat Protected

2013

7.00 x 3.17in

AT1675-540 GNSS Antenna, Rover

2011

7.0 x 2.88in

1.0lb

AT1675-560, GNSS Marine


Antenna, Inmarsat Protected

2013

7.00 x 3.17in

AT1675-382, GNSS ANTENNA

2010

LG

AT1675-339, L1 GPS + GLONASS

2010

AT1621-23,, Dual Iridium Antenna

AeroAntenna Technology, Inc.


www.aeroantenna.com

Allis Communications Co., Ltd.


www.alliswireless.com

Antcom, Inc.
www.antcom.com

Connectors

Cable Type/Length

Mounting Configuration

List Price in U.S. Dollars

Integration

Waterproof IP66

SMA, BNC, FME, MCX, MMCX,


SMB, SMC, TNC, FAKRA

RG174/3meter

stick / magnet / screw mount

$6 to $12

Custom cable lengths,mounts


and connectors available

Waterproof IP66

SMA, BNC, FME, MCX, MMCX,


SMB, SMC, TNC, FAKRA

RG174/3meter

stick / magnet / screw mount

$12 to $34

Custom cable lengths,mounts


and connectors available

40 to +85C

Waterproof IP66

USB or RS232

RG174/3meter

stick / magnet / screw mount

$20 to $38

Custom cable lengths,mounts


and connectors available

9ma

40 to +85C

Interior use only

N/C and N/O relay contact output

20 guage

Stick / Screw mount

$45 to $65

Installs nest to GPS antenna


and GSM modules to detect any
Jamming frequency transmitters
in area to dissable the GSP
systems. Unit triggers GPS
panick buttom with built in relay

+4.25 to +15 VDC

70 mA

-40 to +85

nr

TNC Female

None

Pole Mount

nr

Amplifier

2.5 dB Max

+4.5-+15 VDC

70 mA

-55 to +85

nr

TNC/SMA Female

None

Roof Mount

nr

Amplifier

2.5 dB Max

+5 to +15 VDC

28, 55 and 75 mA

-55 to +85

nr

TNC OR SMA Female

None

Roof Mount

nr

Amplifier

RHCP

2.5 dB Max

+2.5 -+5.5 VDC

60 mA

-40 to +85

nr

SMA Female

None

Roof Mount

nr

Amplifier

26 and 39 dB

RHCP

2.6 dB Max

+4.2 +15 VDC

40 & 65 mA

-55 to +85

nr

TNC Female

None

Roof Mount

nr

Amplifier

as above

43 dB

RHCP

2.6 dB Max

+5 to +15 VDC

70 mA

-55 to +85

nr

TNC Female

None

Roof Mount

nr

Amplifier

2.0:1

as above

43 dB

RHCP

2.5 dB Max

+4.5 -+18 VDC

65 mA

-55 to +85

nr

TNC Female

None

Roof Mount

nr

Amplifier

157045 & 1164-1260 MHz

2.0:1

as above

26 and 39 dB

RHCP

2.6 dB Max

+4.2 +15 VDC

40 & 65 mA

-55 to +85

nr

TNC Female

None

Pole Mount

nr

Amplifier

1565-1607 MHz & 12171260 MHz

2.0:1

as above

26 dB

RHCP

2.5 dB Max

+2.5 TO +5.5 vdc

38 mA

-50 to +70

nr

SMA Female

None

Pole Mount

nr

Amplifier

1.00lb

157045 & 1164-1260 MHz

2.0:1

as above

26 and 39 dB

RHCP

2.6 dB Max

+4.2 +15 VDC

40 & 65 mA

-55 to +85

nr

TNC Female

None

Roof Mount

nr

Amplifier

220g max

1525-1610 & 1160-1252 MHz

2.0:1

as above

39 dB

RHCP

2.6 dB Max

+4.2 +15 VDC

65 mA

-55 to +85

nr

TNC Female

None

Roof Mount

nr

Amplifier

1.2lb

1525-1610 & 1160-1252 MHz

2.0:1

as above

39 dB

RHCP

2.6 dB Max

+4.2 +15 VDC

65 mA

-55 to +70

nr

TNC Female

None

Pole Mount

nr

Amplifier

1565-1607 & 1217 -1260 MHz

2.0:1

as above

20-30 dB

RHCP

2.5 dB Max

3.3 VDC

Amphenol Cable and


Connector

Roof Mount

L-Band, L1/L2, G1, G2, E%a,


E5b, B1, B2 and B3

2.0:1

as above

39 dB

RHCP

2.6 dB Max

+4.2 +15 VDC

65 mA

-55 to +85

nr

TNC Female or N Female

None

Roof Mount

nr

Amplifier

1525-1610 & 1160-1252 MHz

2.0:1

as above

39 & 45 dB

RHCP

2.6 dB Max

+5 to +18 VDC

65 mA

-55 to +70

nr

TNC Female

None

Pole Mount

nr

Amplifier

1525-1610 & 1160-1252 MHz

2.0:1

as above

39 dB

RHCP

2.6 dB Max

+3 to +15 VDC

65 mA

-55 to +70

nr

TNC Female

None

Pole Mount

nr

Amplifier

1.6lb

1525-1610 & 1160-1252 MHz

2.0:1

as above

39 dB

RHCP

2.6 dB Max

+3 to +15 VDC

70 mA

-55 to +85

nr

TNC Female

None

Pole Mount

nr

Amplifier

5.75 x 2.46in

1.1lb

1525-1615 & 1164-1260 MHz

2.0:1

as above

26 & 39 dB

RHCP

2,5 dB Max

4.3 ro 15 VDC

65 mA

-55 to +85

nr

TNC, BNC OR SMA Female

None

Pole Mount

nr

Amplifier

LG

7.50 x 2.88in

1.0lb

1565-1615 MHz

2.0:1

as above

38 dB

RHCP

2,5 dB Max

4.2 to 15 VDC

65 mA

-40 to +70

nr

TNC Female

None

Pole Mount

nr

Amplifier

2012

7.85 x 3.99 x .88in

1.1lb

1616-1626.5 MHz

1.8:1

as above

3.1 dBic

RHCP

-55 to +71

nr

TNC Female

None

Roof Mount

nr

AT575-230, GPS Antenna

2013

3.75 x 4.00 x .93in

.65lb

1575 MHz

2.0:1

as above

43 dB

RHCP

-55 to +85

nr

AT1621-20, Active Iridium Antenna

2012

LM

4.86 x 5.61in

AT7521-4 GPS/iridium Antenna,


Gooseneck

2012

.79 x 5.83in

1.90oz

1575 & 1616-1626 MHz

2.0:1

as above

AT1675-242, GPS Antenna

2015

GM

3.00 x 3.16in

10oz

1565-1610 MHz

2.0:1

as above

39 dB

RHCP

2.5 dB Max

3-15 VDC

AT1675-0 GPS/GLONASS Antenna

1997

3.00 x 4.70 x .75in

8oz

1565-1615 MHz

2.0:1

as above

26, 36 dB

RHCP

2.5 dB Max

4.5-19 VDC

AT1675-304, L-Band GPS/GLONAS


Antenna

2012

2.71 x 1.05in

.275lb

1525-1607 MHz

2.0:1

as above

28 dB

RHCP

2,5 dB Max

AT1675-504, GPS/GLONASS
Antenna

2012

2.71 x 1.05in

.275lb

1565-1615 MHz

2.0:1

as above

26 & 36 dB

RHCP

AT1675-450, GPS/GLONASS
Antenna

2011

3.5 x .84in

213g

1565-1607 & 1217-1260 MHz

2.0:1

2.0:1

43 dB

AT2775-65, L1/L2 GPS Antenna

2000

4.00 x 3.75 x 59in

11oz

1227 & 1575 MHz

2.0:1

2.0:1

36 dB

GCRTB

2003

NV

100 D x 39mm

280g max. (without


cable)

GPS: 1575.42 3
MHz Cellular: 824~960
/1850~1990 MHz

GPS: 2.0: 1 max.


Cellular: 2.0: 1 max.

GPS: 3 dB max.

M828G

2015

48 x 40 x 13mm

42g max. (without


cable)

GPS/ GLONASS: 1560~1605


MHz

2.0: 1 max.

CMIDM

2013

MO

75 D x 15.8mm

75g max. (without


cable)

Iridium: 1621 3 MHz

CE200

2015

124 x 21.7 x 5.9 mm

11.5g max.(without
cable)

GCRGI

2013

MN

100 D 67mm

MPIDM

2013

MO

AM460

2013

IMPP9

11lb

Amplifier

SMA Female

None

Roof Mount

nr

Amplifier

TNC Female

None

Pole Mount

nr

Amplifier

nr

TNC Male

None

Hand Held Mount

nr

Amplifier

-55 to +85

nr

TNC Female

None

Pole Mount

nr

Amplifier

50 mA

-55 to +85

nr

TNC Female

None

Roof Mount

nr

Amplifier

3.3 to 5.5 VDC

20 mA

-40 to +70

nr

SMA Female

None

Roof Mount

nr

Amplifier

2,5 dB Max

3.3 to 5.5 VDC

45 mA

-40 to +85

nr

SMA Female

None

Roof Mount

nr

Amplifier

RHCP

2,5 dB Max

4.5 to 18 VDC

-55 to +85

nr

TNC & SMA Female

None

Roof Mount

nr

Amplifier

RHCP

3.0 db

4.5-15 VDC

50 mA

-55 to +85

nr

TNC & SMA Female

None

Roof Mount

nr

Amplifier

GPS: 27dB typ.

GPS: RHCP Cellular:


Omni-direction/ Linear

GPS: 1.5 dB
max.

GPS: 2.7~6V

8.54.5mA

-40C~85C

Sine Sweep,1G(0P),10-150-10Hz
each axis

Y: IP56/IP67

N/N

BNC, TNC, SMA, SMB, MCX, SMC,


MMCX, FAKRA

GPS: RG174/ RG316 Cellular:


RG58/ RG174/ RG316

Thread Permanent Mount

GPS/ Cellular

3 dB max.

27dB typ.

RHCP

2.0dB max.

2.7~5.5 V

6~11mA

-40C~85C

Sine Sweep,1G(0P),10-150-10Hz
each axis

Y: IP56/IP67

N/N

BNC, TNC, SMA, SMB, MCX, SMC,


MMCX, FAKRA

RG174/RG316

Magnetic base

GPS/ GLONASS

1.5: 1 max.

3 dB max.

4dBic typ.

RHCP

na

nr

nr

-40C~85C

Sine Sweep,1G(0P),10-150-16Hz
each axis

Y: IP67

N/N

BNC, TNC, SMA, SMB, MCX, SMC,


MMCX, FAKRA

RG174/3m

Magnetic base

Iridium only

Cellular: 824~960MHz,
1710~2170MHz

3.0: 1 max.

na

3dBi max.

Omni-direction/ Linear

na

nr

nr

-40C~+85C

Sine Sweep,1G(0P),10-150-18Hz
each axis

Y: IP67

N/N

BNC, TNC, SMA, SMB, MCX, SMC,


MMCX, FAKRA

RG174/RG316

na

Cellular

280g max. (without


cable)

GPS: 1575.42 3 MHz


Iridium: 1621 3 MHz

GPS: 1.5: 1 max.


Iridium: 1.5: 1 max.

3 dB Max.

GPS: 28 dB typ.
Iridium: 5dBic typ.

RHCP

GPS: 1.8 dB
max.

2.7~6.0V

125.5 mA

-40C~85C

Sine Sweep,1G(0P),10-150-18Hz
each axis

Y: IP56/IP67

N/N

BNC, TNC, SMA, SMB, MCX, SMC,


MMCX, FAKRA

GPS: RG174/ RG316 Cellular:


RG58/ RG174/ RG316

Thread Permanent Mount

Iridium/ GPS

48 x 40 x 13 mm

42g max. (without


cable)

Iridium: 1621 3 MHz

1.5: 1 max.

3 dB max.

4dBic typ.

RHCP

na

nr

nr

-40C~85C

Sine Sweep,1G(0P),10-150-19Hz
each axis

Y: IP56/IP67

N/N

BNC, TNC, SMA, SMB, MCX, SMC,


MMCX, FAKRA

RG174/3m RG316/3m

Magnetic base

Iridium only

MNOV

139 D 60mm

<1.1kg (without cable)

GPS: 1575.42 3 MHz


Iridium: 1616~1626MHz
Cellular: 696~960MHz,
1710~2170MHz Wi-Fi:
2.4~2.5GHz, 4.7~5.9GHz

GPS: 1.5: 1 max.


Iridium: 2.0: 1 max
Cellular: 3.0: 1 max.
Wi-Fi: 3.0:1 max.

GPS/ Iridium: 3
dB Max.

GPS: 27dB typ.


Iridium: 4dbic typ.
Cellular: 6dBi max.
Wi-Fi: 7dBi max.

GPS/ Iridium: RHCP


Cellular/ WiFi: Omnidirection/ Linear

GPS: 1.8dB
max.

GPS: 2.7~6.0V

8.54.5mA

-40C~85C

Sine Sweep,1G(0P),10-150-20Hz
each axis

Y: IP67 stainless
bottom

N/N

BNC, TNC, SMA, SMB, MCX, SMC,


MMCX, FAKRA

GPS: RG174/ RG316 Cellular:


RG58/ RG174/ RG316 Wi-Fi:
RG58/ RG174/ RG316

Thread Permanent Mount

GPS/ LTE/ 2G/ 3G/ Wi-Fi

2013

MN

100 D 67mm

280g max. (without


cable)

GPS Module: 1575.42


3 MHz
Cellular: 824~960MHz,
1710~2170MHz Wi-Fi:
2.4~2.5GHz, 4.7GHz~5.9GHz

GPS Module: na
Cellular: 2.0:1 max.
Wi-Fi: 2.0:1 max.

GPS Module: 3
dB Max.

GPS Module: na
Cellular: 5dBi max.
Wi-Fi: 6dBi tmax.

GPS Module: RHCP


Cellular/ WiFi: Omnidirection/ Linear

na

GPS: 5.0V

50mA

-40C~85C

Sine Sweep,1G(0P),10-150-21Hz
each axis

Y: IP56/IP67

N/N

GPS: USB A Type C: Option


WiFi: Option

GPS Module: USB Cable O.D.


3.50.2mm Cellular: RG58/
RG174/ RG316 Wi-Fi: RG58/
RG174/ RG316

Thread Permanent Mount

GPS NEMA/ Cellular/ Wi-Fi

SG25C

2015

48 x 40 x 13mm

42g max.(without
cable)

GPS/GLONASS/BDS:
1559MHz ~1615MHz

2.0: 1 max.

3 dB max.

25dB typ.

RHCP

2.0dB max.

2.7~5.5V

12~16mA

-40C~85C

Sine Sweep,1G(0P),10-150-21Hz
each axis

Y: IP56/IP67

N/N

BNC, TNC, SMA, SMB, MCX, SMC,


MMCX, FAKRA

RG174/RG316

Magnetic base

GPS/GLONASS/BDS/Galileo

X830B

2013

36 x 36 x 13.9mm

35g max. (without


cable)

GPS/GLONASS/BDS:
1559~1615MHz

2.0: 1 max.

3 dB max.

30dB typ.

RHCP

1.5 dB max.

2.7~6 V

9.54.5mA

-40C~86C

Sine Sweep,1G(0P),10-150-22Hz
each axis

Y: IP67

N/N

SMA

RG174/5m

Magnetic base

GPS Only

0.9G15A-XX-X (active)
0.9G15P-XX-X (passive)

2009

DLMOV

31.75 x 31.75 x
13.59mm

30g

1575.42 12 MHz

1.5:1

2.5 dB typ

24 dB typ (passive
also available)

RHCP

1 dB typ

2.5 - 24 VDC

15 to 25 mA typ

-55 to +85

>30 G

Y/hermetically

Y/Y

RA MCX, MCX, SMA, SMB, SSMA,


SSMB, SSMC, TNC, Lemo

RG-316/15.24cm (custom
length available)

2x flange mounts

Contact Antcom

nr

1G1215A-XX-X (active)
1G1215P-XX-X (passive)

2007

DLMOV

52.78 x 52.78 x
17.54mm

82g

1575.42 15 MHz
1227.60 15 MHz

1.5:1

2 dB typ

L1: 33 dB typ
L2: 35 dB typ
(passive also
available)

RHCP

3 dB typ

2.5 - 24 VDC

20 to 50mA typ

-55 to +85

>30 G

Y/hermetically

Y/Y

SMA F, TNC, TNC-Bulkhead, N,


N-Bulkhead, MCX, MMCX

RG-178/7.39cm (custom
length available)

4x screws back mount &


adhesive gasket

Contact Antcom

nr

1.3G1215A-XX-X (active)
1.3G1215P-XX-X (passive)

2013

DGLMNOV

33.53 x 33.53 x
17.58mm

53.9g

1575.42 15 MHz
1227.60 12 MHz

1.5:1

L1: 1 dB typ
L2: 3dB typ

24 dB typ (filter
option available)

RHCP

1.8dB typ

2.5 - 28 VDC

15 to 25 mA typ

-55 to +85

>30 G

Y/hermetically

Y/Y

SMA F, MCX, QMA, TNC, SMB,


SSMA, SSMB, SSMC, SSMP,
MCX, SMP

cable and hardward options


available

4x screws back mount + o-ring

Contact Antcom

nr

WWW.GPSWORLD.COM

FEBRUARY 2016

40 mA

L/D 5

nr

S4 G P S W O R L D

+4.5 -+15 VDC

-40 to +55

Environmentally
Sealed (Y/N)/Type

-40 to +85

1616-1626.5 MHz

3.0 dB Max

Vibration

RHCP
RHCP

FEBRUARY 2016

WWW.GPSWORLD.COM

G P S W O R L D S5

ANTENNA SURVEY 2016

Manufacturer

Antenova
www.antenova-m2m.com

sponsored by

Model

Intro. Date

User Environment 1

Size: Length x Width


x Height

Weight

Frequency/Bandwidth 2

VSWR 3

Axial Ratio
(dB)

Gain/Gain with
Amplifier (dB)

Pattern

Noise Figure
(dB) 4

Amplifier DC Voltage Amplifier Current


(mA)

Operating Temperature
(C)

Vibration

Environmentally
Sealed (Y/N)/Type

L/D 5

Connectors

Cable Type/Length

Mounting Configuration

List Price in U.S. Dollars

Integration

1.9G1215A-XX-X (active)
1.9G1215P-XX-X (passive)

2004

DGLMNOV

50 x 50 x 13.54mm

68g

1575.42 12 MHz
1227.60 12 MHz

1.5:1

2 dB typ

20 dB and 30 dB
typ (filter option
available)

RHCP

<3dB typ

2.5 - 24 VDC

20 to 50 mA typ

-55 to +85

>30 G

Y/hermetically

Y/Y

SMA F, TNC, TNC-Bulkhead, N,


N-Bulkhead, MCX, SMA

cable and hardward options


available

4x corner flange mounts

Contact Antcom

nr

2G1215A-XX-X (active)
2G1215P-XX-X (passive)

2007

ADGLMNOTV

66.04 x 18mm nomag. 66.04 x 22mm


with-mag

113g no mag 198g


with mag

1575.42 15 MHz 1227.60


15 MHz

1.5:1

2 dB typ

L1: 33 dB typ
L2: 35 dB typ (filter
option available)

RHCP

3 dB typ

2.5 - 24 VDC

<50 mA typ

-55 to +85

>30 G

Y/hermetically

Y/Y

SMA F, TNC, N, MCX, MMCX,

cable and hardward options


available

screw mount, magnetic mount

Contact Antcom

nr

G3Ant-2XXX (2.7 dia. screw/


thruhole/magmount)
G3Ant-3XXX (3.5 dia. aviation/
screw thruhole)

2009

ADGLMNOTSV

2.7: 68.81 x
17.30mm
3.5: 88.90 x
21.89mm

184g
256g

1575.42 17 MHz
1609 7 MHz
1542.4 14 MHz
1561.098 10 MHz

1.5:1

1 dB typ

33 dB typ (passive
also available)

RHCP

3 dB typ

2.5 - 24 VDC

30 to 40 mA

-55 to +85

>30 G

Y/hermetically

Y/Y

SMA MALE, TNC, N, MCX, MCX

cable, hardward options and


other enclosure form factors
available

screw mount, 4x hole surface


mount, magnetic mount

Contact Antcom

nr

G5Ant-42XXX (ARINC 743)

2009

ADGLMNOTSV

119.38 x 76.20 x
22.80mm

227g

1575.42 16 MHz
1609 7 MHz
1227.6 12 MHz
1252.5 7.5 MHz
1542.5 14 MHz

2.0:1

2 dB typ

33 - 35 dB typ
(passive also
available)

RHCP

3.0 dB typ

2.5 - 24 VDC

20 to 50 mA typ

-55 to +85

>30 G

Y/hermetically

Y/Y

TNC F, SMA, BNC, TNC Bulkhead,


N, N Bulkhead, MCX, MMCX

cable, hardward options and


other enclosure form factors
available

4x hole, surface

Contact Antcom

nr

G8Ant-52A4XX Rev A (active)


G8Ant-52PXX (passive)

2013

DGLMNOV

127 D x 83.55mm

567g

1575.42 17 MHz
1598 - 1609 MHz
1164.45 - 1219.14 MHz
1242 - 1252 MHz
1266.75 - 1290.75 MHz
1227.6 12 MHz
1207.14 10MHz
1252.5 7.5 MHz
1542.5 14 MHz

2.0:1

1 dB typ

42 - 43 dB typ
(passive also
available)

RHCP

2.6dB

2.5 - 24 VDC

<50 mA typ

-55 to +85

>30 G

Y/hermetically

Y/Y

TNC F, SMA, BNC, TNC Bulkhead,


N, N Bulkhead, MCX, MMCX

cable, hardward options and


other enclosure form factors
available

5/8-11 UNC

Contact Antcom

nr

4NC-3.5CG1215X-XS-X-X Rev B

2006

CRPA

88.90 D x 17.53mm

146g

1575.42 50 MHz
1227.60 27 MHz

2.0:1

2 dB typ

na (active also
available)

RHCP

na

na

na

-55 to +85

>30 G

Y/hermetically

Y/Y

SMA, SMB, SMC, SSMA, SSMB,


SSMC, MCX, MMCX

cable, hardward options and


other enclosure form factors
available

4x hole, surface

Contact Antcom

nr

5NF-4.5CG1215P-XS-X Rev D

2007

CRPA

114.3 D x 13.90mm

146g

1575.42 24 MHz
1227.60 24 MHz

2.0:1

2 dB typ

na (active also
available)

RHCP

na

na

na

-55 to +85

>30 G

Y/hermetically

Y/Y

SMA, TNC, SMB, SMC, SSMA,


SSMB, SSMC, MCX, MMCX

cable, hardward options and


other enclosure form factors
available

5x hole, bottom

Contact Antcom

nr

Cyaneus A10137

2006

LMNOPRV

20.1 x 9.0 x 1.6

<0.7g

1575 MHz

1.4:1

na

RHCP

na

na

-40 to +125

na

na

na

na

SMD

Contact distributor or
Antenova

Brevis A10204

2009

LMNOPRV

22 x 3 x 3

<0.2g

1575 MHz

1.4:1

na

RHCP

na

na

-40 to +125

na

na

na

na

SMD

Contact distributor or
Antenova

Brevis GNSS 10204-1

2014

LMNOPRV

11 x 6.1 x 3.2

<0.2g

1559-1609 MHz

1.5:1

na

RHCP

na

na

-40 to +125

na

na

na

na

SMD

Contact distributor or
Antenova

Sinica SR4G008

2015

LMNOPRV

7 x 5.8 x 0.4

<0.2g

1559-1609 MHz

1.4:1

na

RHCP

na

na

-40 to +125

na

na

na

na

SMD

Contact distributor or
Antenova

Belti SRG013

2016

LMNOPRV

15.65 x 4.4 x 3.2

<0.5g

1559-1609 MHz

2.24:1

na

RHCP

na

na

-40 to +125

na

na

na

na

SMD

Contact distributor or
Antenova

Bentoni SRFG017

2016

LMNOPRV

40 x 14 x 0.15

<0.5g

1559-1609 MHz

1.48:1

na

RHCP

na

na

-40 to +125

na

na

1.13mm RF Cable with IPEX MHF

50mm,100mm,150mm

self-adhesive

Contact distributor or
Antenova

Asper SRFW018

2016

LMNOPRV

81 x 14 x 0.15

<0.5g

1559-1609 MHz / 2.4-2.5 GHz

1.4:1

na

RHCP

na

na

-40 to +125

na

na

1.13mm RF Cable with IPEX MHF

100mm,150mm,200mm

self-adhesive

Contact distributor or
Antenova

M10382 GPS RF Antenna Module

2011

LMNPTV

24.2 x 9.9 x 3.8mm

1.1g

GPS L1 frequency 1575.42


MHz, 30MHz

na, integrated reciever

na, integrated
reciever

na, integrated
reciever

RHCP

na, integrated
reciever

1.8 VDC or 3.3 VDc

na, integrated
reciever

-40 to +85

na

na

na

na

SMD

Contact Antenova

M10477 GPS and GNSS RF


Antenna module

2012

LMNPTV

24.2 x 9.9 x 3.8

1.1g

1575MHz

na, integrated reciever

na, integrated
reciever

na, integrated
reciever

RHCP

na, integrated
reciever

1.8 VDC

na, integrated
reciever

-40 to +85

na

na

na

na

SMD

Contact distributor or
Antenova

M10478-A1

1013

LMNPTV

13.8 x 9.5 x 1.8

<1g

1575MHz

na, integrated reciever

na, integrated
reciever

na, integrated
reciever

RHCP

na, integrated
reciever

1.8 VDC

na, integrated
reciever

-40 to +85

na

na

na

na

SMD

Contact distributor or
Antenova

M10478-A2-1

2015

LMNPTV

13.8 x 9.5 x 1.8

<1g

1575MHz

na, integrated reciever

na, integrated
reciever

na, integrated
reciever

RHCP

na, integrated
reciever

2.8-4.2 VDC

na, integrated
reciever

-40 to +85

na

na

na

na

SMD

Contact distributor or
Antenova

M10478-A3

2013

LMNPTV

13.8 x 9.5 x 1.8

<1g

1575-1609MHz

na, integrated reciever

na, integrated
reciever

na, integrated
reciever

RHCP

na, integrated
reciever

2.8-4.2 VDC

na, integrated
reciever

-40 to +85

na

na

na

na

SMD

Contact distributor or
Antenova

M10578-A2

2016

LMNPTV

9 x 9 x 1.8

<1g

1575MHz

na, integrated reciever

na, integrated
reciever

na, integrated
reciever

RHCP

na, integrated
reciever

2.8-4.2 VDC

na, integrated
reciever

-40 to +85

na

na

na

na

SMD

Contact distributor or
Antenova

M10578-A3

2016

LMNPTV

9 x 9 x 1.8

<1g

1575-1609MHz

na, integrated reciever

na, integrated
reciever

na, integrated
reciever

RHCP

na, integrated
reciever

2.8-4.2 VDC

na, integrated
reciever

-40 to +85

na

na

na

na

SMD

Contact distributor or
Antenova

ftech Radio Frequency System


Corporation
www.f-tech.com.tw

FA02

2010

ALMNV

52.5 x 36.5 x 11.65mm

20g

1575.42MHz/L1

<= 5

29

RHCP

0.65

2.5~3.3

-40 to +85

na

Y/ IP65

SMA/MCX/MMCX

various length available

magnetic /sticker

price will be quoted by qty.

GPS Source, Inc.


www.gpssource.com

L1A

2006

ADELMNOTV

3.5 x 3.5 x .65in

3.5

1575.5 k +/- 10MHz

2:01

nr

3 dB/33dB

Hemispheric

2.0dB

3-16 VDC

20 mA max

-30 to +70

Sine 10-500 Hz 5G
XYZ, Shock 30G

Y/Water Proof

DC ground

SMA, TNC, N

na

10-32 4-Hole 2.3in

Please call

GPS

L1P

2006

ADELMNOTV

3.5 x 3.5 x .65in

2.7oz

1575.5 k +/- 10MHz

2:01

nr

3 dB

Hemispheric

na

na

na

-30 to +70

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

10-32 4-Hole 2.3in

Please call

GPS

L1L2-2GP

2010

ADELMNOTV

2.6 x .94in

6.4oz

1575.5 k 10MHz 1227.6


k 10MHz

2:01

nr

3 dB

Hemispheric

na

-54 to +71

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

6-32 4-Hole 2.3in

Please call

GPS

L1L2-2GA

2010

ADELMNOTV

2.6 x .94in

6.4oz

1575.5 k 10MHz 1227.6


k 10MHz

2:01

nr

L1 3dB/33 dB
L2 6.7dB/33 dB

Hemispheric

na

3-10 VDC

50 mA max

-54 to +71

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

6-32 4-Hole 2.3in

Please call

GPS

L1L2-RA-1

2011

ADELMNOTV

3 x 2.27in

6.3oz

1575.42 k 15MHz 127.6


k 15MHz

2.0:1

2dB max

L1 3dB/26 dB
L2 3dB/26dB

Hemispheric

2.8dB

2.5 - 10 VDC

30 mA max

-54 to +71

as above

Y/Water Proof

DC ground

SMA

na

Magnet or 10-32 1-hole and


6-32 3-hole

Please call

GPS

L1L2-RA-2

2011

ADELMNOTV

3.4 x 2.2in

6.7oz

1575.42 k 15MHz 1227.6


k 15MHz

2.0:1

2dB max

L1 3dB/26 dB
L2 3dB/26dB

Hemispheric

2.8dB

2.5 - 10 VDC

30 mA max

-54 to +71

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

6-32 4-hole

Please call

GPS

L1G1A

2015

ADELMNOTV

3.5 x 3.5 x .65in

3.5oz

1585 +/- 25MHz

2.0:1

2dB max

3 dB/30dB

Hemispheric

2dB

3-16 VDC

20 mA max

-30 to +70

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

10-32 4-Hole 2.3in

Please call

GNSS

L1G1P

2015

adELMNOTV

3.5 x 3.5 x .65in

2.7oz

1585 +/- 25MHz

2.0:1

2dB max

3 dB

Hemispheric

2dB

3-16 VDC

na

-30 to +70

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

10-32 4-Hole 2.3in

Please call

GNSS

GNSS-3A

2014

3.5 x .97in

9.6oz

1584 +/- 26MHz


1215 +/- 25MHz

2.0:1

2.8dB max

L1 3dB/30 dB

Hemispheric

3dB

3.3 - 10 VDC

35 mA max

-54 to +71

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

6-32 4-Hole or 10-32 4-Hole

Please call

GNSS

GNSS-3P

2014

ADELMNOTV

3.5 x .97in

9.4oz

2.0:1

2.8dB max

3 dB

Hemispheric

2dB

na

na

-54 to +71

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

10-32 4-Hole 2.3in

Please call

GNSS

L1AW

2015

ADELMNOTV

3.5 x 3.5 x .65in

3.5

1575.5 k +/- 10MHz

2.0:1

nr

3 dB/33dB

Hemispheric

2dB

3-16 VDC

20 mA max

-30 to +70

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

10-32 4-Hole 2.3in

Please call

GPS

L1PW

2015

ADELMNOTV

3.5 x 3.5 x .65in

3.5

1575.5 k +/- 10MHz

2.0:1

nr

3 dB

Hemispheric

2dB

na

na

-30 to +70

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

10-32 4-Hole 2.3in

Please call

GPS

L1G1A-STD

2015

ADELMNOTV

3.5 x 3.5 x .65in

3.5

1585 +/- 25MHz

2.0:1

nr

3 dB/33dB

Hemispheric

2dB

3-16 VDC

20 mA max

-30 to +70

as above

Y/Water Proof

DC ground

SMA, TNC, N

na

10-32 4-Hole 2.3in

Please call

GNSS

Gutec AB
www.gutec.se

GNSSA210

2015

96 x 170mm

300g

GPS L1, GPS L2, GPSL5,


GLONASS G1, GLONASS
G2, GLONASS G3, GALILEO
E1, GALILEO E5

<0.1

<3 dB

6 dB/29 dB

Hemispheric

<1.5 dB

415 VDC

15 mA

-40 to +85

Sine10200 Hz 1 G
XYZ, Shock 10 G

Y/ventilated
body(Gore vent),
hermetic connector

na

TNC

na

5/8in UNC

2500

Hemisphere GNSS
www.hemispheregnss.com

A21

2009

ADEGLMNV

70 x 130mm

380g

1525 - 1610MHz

30 dB

RHCP

2.0, typ

3 - 12 VDC

24mA typ

/- 40 to +70

EP455

Y/IP69K

N/N

TNC

5m typ

Magnetic, screw 1 or 5/8


adapter

call

L1 GPS / L1 GLONASS / L-Band

A22

2009

ADEGLMNV

70 x 130mm

380g

1525 - 1610MHz

30 dB

RHCP

2.0, typ

3 - 12 VDC

24mA typ

/- 40 to +70

EP455

Y/IP69K

N/N

5m typ

Magnetic, screw 1 or 5/8


adapter

call

L1 GPS / L1 GLONASS / L-Band

A25

2014

DEGLMNV

47 x 152mm

400g

1525 - 1615MHz

30 dB

RHCP

2.0, typ

3 - 12 VDC

12mA typ

/- 40 to +70

EP455

Y/IP69K

N/N

TNC

5m typ

Magnetic, screw 5/8

call

L1 GPS / L1 GLONASS / B1
BeiDou / E1 Galileo/ L-Band

A31

2011

DEGLMNV

104 x 145mm

730g

283.5 - 325kHz, 1525 1610MHz

30 dB

RHCP

2.0, typ

5 - 12 VDC

50 - 60mA typ

/- 30 to +70

EP455

Y/IP69K

N/N

TNC

5m typ

Magnetic, screw 1 or 5/8


adapter

call

L1 GPS / L1 GLONASS / L-Band


/ Beacon

A42

2011

DEGLMNV

70 x 130mm

380g

1165 - 1253MHz, 1525 1613MHz

30 dB

RHCP

2.0, typ

3 - 12 VDC

35mA typ

/- 40 to +70

EP455

Y/IP69K

N/N

TNC

5m typ

Magnetic, screw 5/8

call

L1/L2/L5 GPS / L1/L2


GLONASS / B1/B2/B3 Beidou /
Galileo / QZSS / SBAS / L-Band

A43

2012

DEGLMNV

104 x 145mm

730g

283.5 - 325kHz, 1165 1278MHz, 1525 - 1613MHz

30 dB

RHCP

2.0, typ

5 - 12 VDC

50 - 60mA typ

/- 40 to +70

EP455

Y/IP69K

N/N

TNC

5m typ

Magnetic, screw 1 or 5/8


adapter

call

L1/L2/L5 GPS / L1/L2


GLONASS / B1/B2/B3 Beidou /
Galileo / QZSS / SBAS / L-Band/
Beacon

A45

2014

DEGLMNV

47 x 152mm

500g

1165 - 1278MHz, 1525 1615MHz

30 dB

RHCP

2.0, typ

3 - 12 VDC

25mA typ

/- 40 to +70

EP455

Y/IP69K

N/N

TNC

5m typ

Magnetic, screw 5/8

call

L1/L2/L5 GPS / L1/L2


GLONASS / B1/B2/B3 Beidou /
Galileo / QZSS / SBAS / L-Band

S6 G P S W O R L D

WWW.GPSWORLD.COM

FEBRUARY 2016

FEBRUARY 2016

WWW.GPSWORLD.COM

Antenna, RF Front-end,
GPS engine

G P S W O R L D S7

ANTENNA SURVEY 2016

Manufacturer

Inventeksys
www.inventeksys.com

Intro. Date

User Environment 1

Size: Length x Width


x Height

Weight

Frequency/Bandwidth 2

Gain/Gain with
Amplifier (dB)

Pattern

Noise Figure
(dB) 4

Amplifier DC Voltage Amplifier Current


(mA)

Operating Temperature
(C)

Vibration

Environmentally
Sealed (Y/N)/Type

L/D 5

Connectors

Cable Type/Length

Mounting Configuration

List Price in U.S. Dollars

Integration

A52

2010

DEGLMNV

76 x 185mm

780g

1165 - 1253MHz, 1525 1613MHz

30 dB

RHCP

2.0, typ

3 - 12 VDC

35mA typ

- 40 to +70

EP455

Y/IP69K

N/N

TNC

5m typ

Magnetic, screw 5/8

call

L1/L2/L5 GPS / L1/L2


GLONASS / B1/B2/B3 Beidou /
Galileo / QZSS / SBAS / L-Band

ACTPAT154-01-IP

2007

GLMNV

15 x 15 x 4mm

0.01oz

1578.00 +/-2.0 MHz

1.5

ACTPAT184-01-IP

2007

GLMNV

18 x 18 x 4mm

0.01oz

1578.00 +/-2.0 MHz

1.5

2 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +85

nr

U.FL

63

Active Patch

$9.75

2 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +85

nr

U.FL

63

Active Patch

ACTPAT182-025-IP

2008

GLMNV

18 x 18 x 2mm

0.01oz

1578.00 +/-2.0 MHz

$9.75

1.5

2 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +85

nr

U.FL

25

Active Patch

ACTPAT182-01-IP

2008

GLMNV

18 x 18 x 2mm

0.01oz

$9.75

1578.00 +/-2.0 MHz

1.5

2 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +85

nr

U.FL

63

Active Patch

ACTPAT182-07-IP

2008

GLMNV

18 x 18 x 2mm

$9.75

0.01oz

1578.00 +/-2.0 MHz

1.5

2 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +85

nr

U.FL

165

Active Patch

ACTPAT254-01-IP

2008

GLMNV

$9.75

25 x 25 x 4mm

0.01oz

1581.00 +/-2.0 MHz

2 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +85

nr

U.FL

25

Active Patch

ANTDOM-05-01-WPM

2008

ANTDOM-10-MCX-WPM

2008

$9.75

ADGLMNV

45 x 14.5mm

0.01oz

1575.42 MHz

1.0 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +90

nr

SMA

5000

Active Dome

$12.75

ADGLMNV

45 x 14.5mm

0.01oz

1575.42 MHz

1.0 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +90

nr

MCX

10000

Active Dome

ANTDOM-10-MCX-WPMT

$13.27

2008

ADGLMNV

45 x 14.5mm

0.01oz

1575.42 MHz

1.0 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +90

nr

MCX

10000

Active Dome

$13.27

ANTDOM-05-MMCX-WPM

2008

ADGLMNV

45 x 14.5mm

0.01oz

1575.42 MHz

1.0 dB Typical

26 to 35 dB

RHCP

1.4

2.7-5.4 V

10

-40 to +90

nr

MMCX

5000

Active Dome

$13.27

ANTBULK-0.2-SMB-RG316

2009

ADGLMNV

47 x 15.2mm

0.01oz

1575.42 MHz

1.0 dB Typical

26 to 35 dB

RHCP

1.5

3.0- 5.4 V

10

-40 to +90

nr

SMB

200

Bulkhead

$14.75

ANTBULK-05-SMA

2009

ADGLMNV

47 x 15.2mm

0.01oz

1575.42 MHz

1.0 dB Typical

26 to 35 dB

RHCP

1.5

3.0- 5.4 V

10

-40 to +90

nr

SMA

5000

Bulkhead

$13.27

ANTBULK-05-SMA-RG316

2009

ADGLMNV

47 x 15.2mm

0.01oz

1575.42 MHz

1.0 dB Typical

26 to 35 dB

RHCP

1.5

3.0- 5.4 V

10

-40 to +90

nr

SMA

5000

Bulkhead

$13.27

15.2 x 15.2mm

0.01oz

1575.42 MHz

1.0 dB Typical

26 to 35 dB

RHCP

1.4

3.0- 5.4 V

10

-40 to +85

nr

None

GrAnt-G5T

2014

GDLMNRVPO

140 x 140 x 62mm

515g

15551610 MHz, 11641300


MHz

1.5:1/ 2.0:1

3 dB

5 / L1 322 dB
4 / L2 322 dB

Omnidirectional,
hemispherical

L1 1.7 dB
L2 1.7 dB

315 V DC

45 mA @ 5 V

-45 to +85

nr

Y/nr

Y/N

TNC

RG58/3 m

Threaded 5/8-11; 1in-14;


4 holes

nr

GPS/GLONASS/GALILEO/
BeiDOU/QZSS/SBAS; opt. Snow
Cone; opt. N-type connector

GrAnt-G3T-JS

2012

GDLMNRVPO

140 x 140 x 62mm

515g

15651610 MHz, 11641253


MHz

1.5:1/ 2.0:1

3 dB

5 / L1 333 dB
4 / L2 333 dB

as above

L1 2.8 dB
L2 2.8 dB

4.515 V DC

90 mA @ 5 V

-45 to +85

nr

Y/nr

Y/N

TNC

RG58/3 m

Threaded 5/8-11; 1in-14;


4 holes

nr

GPS/GLONASS/GALILEO/
QZSS/SBAS; opt. Snow Cone;
opt. N-type connector

GrAnt-G3T

2008

GDLMNRVPO

140 x 140 x 62mm

515g

15551610 MHz, 11641253


MHz

1.5:1/ 2.0:1

3 dB

5 / L1 322 dB
4 / L2 322 dB

as above

L1 1.7 dB
L2 1.7 dB

315 V DC

45 mA @ 5 V

-45 to +85

nr

Y/nr

Y/N

TNC

RG58/3 m

Threaded 5/8-11; 1in-14;


4 holes

nr

GPS/GLONASS/GALILEO/
BeiDOU/QZSS/SBAS; opt. Snow
Cone; opt. N-type connector

GrAnt-G3

2008

GDLMNRVPO

140 x 140 x 62mm

450g

15551610 MHz

1.5:1/ 2.0:1

3 dB

5 / L1 32 2 dB

as above

L1 1.7 dB

315 V DC

25 mA @ 5 V

-45 to +85

nr

Y/nr

Y/N

TNC

RG58/3 m

Threaded 5/8-11; 1in-14;


4 holes

nr

GPS/GLONASS/GALILEO/
BeiDOU/QZSS/SBAS; opt. Snow
Cone; opt. N-type connector

RingAnt-G5T

2014

GDLMNRVPO

326 x 88mm

2.7kg

15551610 MHz, 11641300


MHz

1.5:1/ 2.0:1

3 dB

5 / L1 322 dB
4 / L2 322 dB

as above

L1 1.7 dB
L2 1.7 dB

315 V DC

45 mA @ 5 V

-45 to +85

nr

Y/nr

Y/N

TNC

RG58/3 m

Threaded 5/8-11; 1in-14;


4 holes

nr

GPS/GLONASS/GALILEO/
BeiDOU/QZSS/SBAS; opt. Snow
Cone; opt. N-type connector

RingAnt-G3T-JS

2012

GDLMNRVPO

326 x 88mm

2.7kg

15651610 MHz, 11641253


MHz

1.5:1/ 2.0:1

3 dB

5 / L1 333 dB
4 / L2 333 dB

as above

L1 2.8 dB
L2 2.8 dB

4.515 V DC

90 mA @ 5 V

-45 to +85

nr

Y/nr

Y/N

TNC

RG58/3 m

Threaded 5/8-11; 1in-14;


4 holes

nr

GPS/GLONASS/GALILEO/
QZSS/SBAS; opt. Snow Cone;
opt. N-type connector

RingAnt-G3T

2008

GDLMNRVPO

326 x 88mm

2.7kg

15551610 MHz, 11641253


MHz

1.5:1/ 2.0:1

3 dB

5 / L1 322 dB
4 / L2 322 dB

as above

L1 1.7 dB
L2 1.7 dB

315 V DC

45 mA @ 5 V

-45 to +85

nr

Y/nr

Y/N

TNC

RG58/3 m

Threaded 5/8-11; 1in-14;


4 holes

nr

GPS/GLONASS/GALILEO/
BeiDOU/QZSS/SBAS; opt. Snow
Cone; opt. N-type connector

RingAnt-DM

2008

GDLMNRVPO

380 x 138mm

4.4kg

15551610 MHz, 11641300


MHz

1.5:1/ 2.0:1

3 dB

6 / L1 322 dB
5 / L2 322 dB

as above

L1 2.2 dB
L2 1.7 dB

315 V DC

45 mA @ 5 V

-45 to +85

nr

Y/nr

Y/N

TNC

RG58/3 m

Threaded 5/8-11; 1in-14;


4 holes

nr

GPS/GLONASS/GALILEO/
BeiDOU/QZSS/SBAS; opt. Snow
Cone; opt. N-type connector

AirAnt-G3T

2008

ADNVPO

120 x 74 x 44.5mm

320g

15591610 MHz, 11641253


MHz

1.5:1/ 2.0:1

3 dB

4 / L1 303 dB
3 / L2 303 dB

as above

L1 2.5 dB
L2 2.0 dB

4.712 V DC

85 mA @ 5 V

-45 to +85

nr

Y/nr

Y/Y

TNC

RG58/3 m

4 holes

nr

GPS/GLONASS/GALILEO/
BeiDOU/QZSS/SBAS; opt. Snow
Cone; opt. N-type connector

GyrAnt

2008

GDLMNRVPO

140 x 140 x 62mm

570g

15551610 MHz, 11641253


MHz

1.5:1/ 2.0:1

3 dB

5 / L1 322 dB
4 / L2 322 dB

as above

L1 1.7 dB
L2 1.7 dB

Antenna 315 V DC
IMU 9-35 V DC

Antenna 45 mA
@5V
IMU 100 mA
@9V

-45 to +85

nr

Y/nr

Y/Y

TNC; M12

RG58/3 m, M12 Connector

Threaded 5/8-11; 1in-14;


4 holes

nr

Combined Antenna with IMU

TriAnt

2008

GDLMNRVPO

128 x 128 x 54mm

425g

15551610 MHz, 11641253


MHz

1.5:1/ 2.0:1

3 dB

5 / L1 322 dB
4 / L2 322 dB

as above

L1 1.7 dB
L2 1.7 dB

315 V DC

45 mA @ 5 V

-45 to +85

nr

Y/nr

Y/Y

TNC

RG58/3 m

Threaded 1in-14; 3 hole

nr

GPS/GLONASS/GALILEO/
BeiDOU/QZSS/SBAS; opt. Snow
Cone; opt. N-type connector

TyrAnt-G2T

2008

GDLMNRVPO

140 x 140 x 62mm

600g

15551610 MHz, 11641253


MHz

1.5:1/ 2.0:1

3 dB

5 / L1 322 dB
4 / L2 322 dB

as above

L1 1.7 dB
L2 1.7 dB

9-35 V DC

170 mA @ 9 V

-45 to +85

nr

Y/nr

Y/Y

M12

M12 Connector

Threaded 5/8-11; 1in-14;


4 holes

nr

Smart Antenna, integrated with


Receiver TR-G2T

TyrAnt-G3

2008

GDLMNRVPO

140 x 140 x 62mm

600g

15551610 MHz

1.5:1/ 2.0:1

3 dB

5 / L1 32 2 dB

as above

L1 1.7 dB

9-35 V DC

130 mA @ 9 V

-45 to +85

nr

Y/nr

Y/Y

M12

M12 Connector

Threaded 5/8-11; 1in-14;


4 holes

nr

Smart Antenna, integrated with


Receiver TR-G3

GPS/GLONASS Antenna JCA002

2014

Tracking, navigation,
automative car, pnd
and so on

48 x 39 x 14mm

100g

1575.42/1602/1561 MHz

1.5:1

28

RHCP

1.5

3-5V

5-15 mA

-45 to +85

TP67

SMA/MCX/FAKRA and so on

RG174, LMR195,RG58
and so on

Magnet/3M adhesive

1.5-5USD

GPS/GLONASS/COMPASS

Timing reciver JCSS005

2015

94 x 135mm

450g

1575.42 MHz

1.5:1

20

RHCP

<2.0

8-36V

<100 mA

-45 to +85

IP67

SMA/MCX/FAKRA and so on

RG174, LMR195,RG58
and so on

Screw

10-100USD

Choke antenna

2015

base station

300 x 200mm

5000g

1207/1227/1252/1268/1561/1
575/1602 MHz

2.0:1

45

RHCP

<2.0

3-5.5V

<40 mA

-45 to +85

IP67

tnc-k

Screw

1000USD

Surveying antenna

2015

surverying devices

146 x 63mm

350g

1207/1227/1252/1268/1561/1
575/1602 MHz

2.0:1

40

RHCP

<2.0

3-5.5V

<40 mA

-45 to +85

ip67

tnc-k

Screw

1000USD

GPS/GLONASS/4G/WIFI
Combonation antenna JCE058

2015

Tracking, navigation,
automative car, pnd
and so on

50 x 48mm

300g

1575.42/1602/1561/6982700/2400 MHz

2.0:1

28

RHCP

<2.0

3-5V

5-15 mA

-45 to +85

ip67

SMA/MCX/FAKRA and so on

RG174, LMR195,RG58
and so on

Screw

5-15USD

PAT152
JAVAD GNSS
www.javad.com

Jiashan Jinchang Electron


Co., Ltd
www.jinchanggps.com

Leica Geosystems AG
www.leica-geosystems.com

sponsored by

Model

VSWR 3

Axial Ratio
(dB)

$5.00

4G antenna JCG017L

2015

communication
devices

115 x 22 x 6.4mm

55g

698-2700 MHz

1.5:1

RHCP

<2.0

3-5V

5-15 mA

-45 to +85

ip67

SMA/MCX/FAKRA and so on

RG174, LMR195,RG58
and so on

3M adhesive

0.5-2USD

433MHZ antenna jcg411

2015

home alarm system

10 x 53mm

15g

433 MHz

1.5:1

RHCP

<2.0

3-5V

5-15 mA

-45 to +85

ip67

SMA

SMA

0.5-1.5USD

868MHZ antenna JCG410

2015

home alarm system

13 x 195mm

20g

868 MHz

1.5:1

RHCP

<2.0

3-5V

5-15 mA

-45 to +85

ip67

SMA

SMA

0.5-1.5USD

GPS/COMPASS Antenna jca057

2015

Tracking, navigation,
automative car, pnd
and so on

59 x 52 x 15mm

150g

1575.42/1602/1561 MHz

1.5:1

28

RHCP

<2.0

3-5V

5-15 mA

-45 to +85

IP68

SMA/MCX/FAKRA and so on

RG174, LMR195,RG58
and so on

Magnet/3M adhesive

1.5-5USD

AS05

2009

DGLMNRV

62 x 170mm

0.44kg

1565.5-1611.5 MHz

<2.0:1

na

-/27 dB typ

Omni-Directional

<2 dB

4.518 V DC

35 mA max

-40 to +70

MIL-STD-810G method
514.6-cat.24

Y/IP68

N/N

TNC female

diff. type & length from


1.2m-70m available

5/8 Threaded

nr

GPS, GLONASS, SBAS

AS10

2009

DGLMNRV

62 x 170mm

0.44kg

1552.0-1609.0 MHz, 1165.01255.0 MHz

<2.0:1

na

-/29 dB typ

Omni-Directional

<2 dB

4.518 V DC

35 mA max

-40 to +70

MIL-STD-810G method
514.6-cat.24

Y/IP68

N/N

TNC female

diff. type & length from


1.2m-70m available

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS, QZSS, L-band

AR10

2010

EGLMNORST

136 x 240mm

1.12kg

1525.0-1612.0 MHz, 1164.01301.0 MHz

<2.0:1

<1.4dB @ zenith

-/29 dB +/- 3dB typ

Omni-Directional;
RHCP

<1.8 dB

3.312 V DC

100 mA max

-40 to +70

MIL-STD-810F /
ISO9022-36-05

Y/IP67

N/N

TNC female

diff. type & length from


1.2m-70m available

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS, QZSS, L-band

AR20

2012

EGLMNORST

163 x 320mm

5.9kg

1525.0-1612.0 MHz, 1164.01301.0 MHz

<1.8:2

<1.2dB @ zenith

-/29 dB +/- 3dB typ

Omni-Directional;
RHCP

<2.0 dB

3.312 V DC

100 mA max

-55 to +85

MIL-STD-810F /
ISO9022-36-05

Y/IP67

N/N

N female with TNC adapter supplied

diff. type & length from


1.2m-70m available

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS, QZSS, L-band

AR20-LHCP

2013

EGLMOP

163 x 320mm

5.9kg

1525.0-1612.0 MHz, 1164.01301.0 MHz

<1.8:2

<1.2dB @ zenith

-/29 dB +/- 3dB typ

Omni-Directional; LHCP

<2.0 dB

3.312 V DC

100 mA max

-55 to +85

MIL-STD-810F /
ISO9022-36-05

Y/IP67

N/N

N female with TNC adapter supplied

diff. type & length from


1.2m-70m available

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS, QZSS, L-band

AR25

2008

EGLMNORST

200 x 380mm

7.6kg

1513.5-1623.5 MHz, 1152.01312.0 MHz

<1.5:1

2 dB @ zenith

-/ 40 dB +/- 3dB typ

Omni-Directional;
RHCP

<1.2 dB

3.312 V DC

100 mA max

-55 to +85

MIL-STD-810F /
ISO9022-36-05

Y/IP67

Y/Y

N female with TNC adapter supplied

diff. type & length from


1.2m-70m available

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS, QZSS, L-band

GS08plus

2012

DGLMNRV

71 x 186mm

0.70kg

1558.4-1616.0 MHz, 1215.61259.7 MHz

<2.0:1

na

-/37 dB typ

Omni-Directional

<3 dB

na

na

-40 to +65

MIL-STD-810G method
514.6-cat.24

Y/IP68

Y/Y

8-pin LEMO-1 / Bluetooth

na

5/8 Threaded

nr

GPS , GLONASS, SBAS

GS14

2012

DGLMNRV

90 x 190mm

0.93kg

1552.0-1609.0 MHz, 1165.01255.0 MHz

<2.0:1

na

-/27 dB typ

Omni-Directional

<2 dB

na

na

-40 to +65

MIL-STD-810G method
514.6-cat.24

Y/IP68

Y/Y

8-pin LEMO-1 / Bluetooth

na

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS

GS12

2010

DGLMNRV

89 x 186mm

0.95kg

1552.0-1609.0 MHz, 1165.01255.0 MHz

<2.0:1

na

-/27 dB typ

Omni-Directional

<2 dB

na

na

-40 to +65

MIL-STD-810G method
514.6-cat.24

Y/IP68

Y/Y

8-pin LEMO-1 / Bluetooth

na

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS

GS15

2009

DGLMNRV

198 x 196mm

1.34kg

1552.0-1609.0 MHz, 1165.01255.0 MHz

<2.0:1

na

-/27 dB typ

Omni-Directional

<2 dB

na

na

-40 to +65

MIL-STD-810G method
514.6-cat.24

Y/IP68

Y/Y

2 * 8-pin LEMO-1 / UART / Bluetooth

na

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS, QZSS, L-band

GMX901plus

2013

DGLMNRV

71 x 186mm

0.7kg

1558.4-1616.0 MHz, 1215.61259.7 MHz

<2.0:1

na

-/37 dB typ

Omni-Directional

<3 dB

na

na

-40 to +65

MIL-STD-810F /
ISO9022-36-05

Y/IP68

Y/Y

8-pin LEMO-1

na

5/8 Threaded

nr

GPS, GLONASS

GG03

2012

DGLMNRV

71 x 186mm

0.7kg

1558.4-1616.0 MHz, 1215.61259.7 MHz

<2.0:1

na

-/37 dB typ

Omni-Directional

<3 dB

na

na

-40 to +65

MIL-STD-810F /
ISO9022-36-05

Y/IP68

Y/Y

8-pin LEMO-1 / Bluetooth

na

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS, QZSS

S8 G P S W O R L D

WWW.GPSWORLD.COM

FEBRUARY 2016

FEBRUARY 2016

WWW.GPSWORLD.COM

G P S W O R L D S9

ANTENNA SURVEY 2016

Manufacturer

MARUWA Co., Ltd.


www.maruwa-g.com

Maxtena, Inc.
www.maxtena.com

sponsored by

Model

Intro. Date

User Environment 1

Size: Length x Width


x Height

Weight

Frequency/Bandwidth 2

VSWR 3

Axial Ratio
(dB)

Gain/Gain with
Amplifier (dB)

Pattern

Noise Figure
(dB) 4

Amplifier DC Voltage Amplifier Current


(mA)

Operating Temperature
(C)

Vibration

Environmentally
Sealed (Y/N)/Type

L/D 5

Connectors

Cable Type/Length

Mounting Configuration

List Price in U.S. Dollars

Integration

ICG60

2012

DGLMNPRV

130 x 197mm

1.45kg

1552.0-1609.0 MHz, 1165.01255.0 MHz

<2.0:1

na

-/27 dB typ

Omni-Directional

<2 dB

4.518 V DC

50 mA max

-40 to +65

MIL810F, Fig. 514.5C-3

Y/IP67

Y/Y

8-pin LEMO-1 / Bluetooth / USB


Host/QN Female /TNC Female/
UART

na

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS, QZSS, L-band

CGA60

2014

DGLMNRV

<2 dB

4.518 V DC

35 mA max

-40 to +70

MIL-STD-810F method
514.5-cat.24

Y/IP68

N/N

62 x 170mm

0.44kg

1552.0-1609.0 MHz, 1165.01255.0 MHz

<2.0:1

na

-/29 dB typ

Omni-Directional

MWSL-1203C

33 x 19mm

14g

1575 MHz

<2.0:1

<1.5dB

passive

RHCP

TNC female

diff. type & length from


1.2m-70m available

5/8 Threaded

nr

GPS, GLONASS, GALILEO,


BEIDOU, SBAS, QZSS, L-band

-40+85

SMA(male)

na

SMA

Inquire

Screw mount

MWSL-1203D

33 x 15mm

14g

1575 MHz

<2.0:1

<1.5dB

passive

RHCP

MWSL-1204

34 x 13mm

7g

1575 MHz

<2.0:1

<2.0dB

+16 dBic

RHCP

0.8 dB

1.8-3.6V

3.4 mA

MWSL-1206

45 x 15mm

8.4g

1575 MHz

<2.0:1

<2.0dB

+25 dBic

RHCP

1.0 dB

2.8-3.6V

13.0 mA

-40+85

SMA(male)

na

SMA

Inquire

Screw mount

-40+85

PCB

na

PCB

Inquire

PCB

-40+85

PCB

na

PCB

Inquire

MWSL-1208

22 x 10mm

7g

1575 MHz

<2.0:1

<2.0dB

passive

PCB

RHCP

-40+85

3-pin

na

3-pin connector

Inquire

MWSL-1251

23 x 10mm

7g

1575 MHz

<2.0:1

<2.0dB

3-pin

passive

RHCP

-40+85

PCB

na

PCB

Inquire

MWSL-1252

24 x 13mm

7g

1575 MHz

<2.0:1

PCB

<2.0dB

passive

RHCP

-40+85

PCB

na

PCB

Inquire

MWSL-1300

16 x 8mm

3g

1575 MHz

PCB

<2.0:1

<1.5dB

passive

RHCP

-40+85

3-pin

na

3-pin connector

Inquire

MWSL-1350

16 x 8mm

3g

MWSL-3105

43 x 19mm

29g

3-pin

1575 MHz

<2.0:1

<1.5dB

passive

RHCP

-40+85

PCB

na

PCB

Inquire

PCB

1616-1626 MHz

<2.0:1

<1.5dB

+2 dBic

RHCP

-40+85

SMA(male)

na

SMA

Inquire

Screw mount

M1621HCT-P-SMA (Passive Iridium)


p/n: 100-00003-02 - IRIDIUM
CERTIFIED

2013

48 x 18.5mm

11g (typical)

1616-1626 MHz

1.5 (max)

0.2dB (typical) /
0.5dB (max)

passive

M1516HCT-P-SMA (Passive GPS/


GLONASS) p/n: 100-00002-02

2013

48 x 18.5mm

11g (typical)

1575 MHz/1602 MHz

1.5 (max)

0.5dB (typical) / 1
dB (max)

passive

M1227HCT-A2-SMA (Active L1/L2,


GLONASS) p/n: 100-00004-02

2014

51 x 30mm

24g (typical)

1217-1250 MHz (L2) / 15651610 MHz (L1)

<1.5

0.5dB (typical) / 1
dB (max)

30 dBic @ 1227
Mhz / 28 dBic @
1575 MHz / 28 dBic
@ 1602 MHz

M1575HCT-22P-MR (Passive GPS


L1) p/n: 100-00042-01

2013

41.65 x 19.30mm

10g (typical)

1575 MHz

1.5 (max)

1dB (typical) /
1.5dB (max)

M1575HCT-22P-SMA (Passive GPS


L1) p/n: 100-00043-01

2013

38 x 18.5mm

10g (typical)

1575 MHz

1.5 (max)

1dB (typical) /
1.5dB (max)

M1575HCT-15A-SMA (Active GPS


L1) p/n: 100-00028-07

2015

41.85 x 18.50 mm

10g (typical)

1575 MHz

1.5 (max)

1dB (typical) /
1.5dB (max)

28 dBic (typical)
@ 3.3 V

M1600HCT-P-SMA (Passive Iridium/


GPS) p/n: 100-00050-01

2013

48 x 18.5mm

11g (typical)

1616-1626 MHz / 1575


MHz (GPS)

1.5 (max)

0.5dB (typical) / 1
dB (max)

passive

SATFleet (Iridium/GPS Active)


p/n: 100-00045-01 - IRIDIUM
CERTIFIED

2014

61 x 116 x 50mm

117g

1621 MHz / 1575 MHz

2 (max)

1.5dB (typical)
Iridium / 1.5dB
(typical) / 2.5dB
(max) GPS

1.5 dBic (typical) @


Broadside Iridium /
5.5 dBic GPS

M1621HCT-EXT (Passive Iridium)


p/n: 100-00044-02 - IRIDIUM
CERTIFIED

2014

52.20 x 36mm

52g (typical)

1616-1626 MHz

1.5 (max)

2dB (max)

passive

M1575HCT-22-P (Passive GPS L1)


p/n: TBD (custom)

2013

24.3 x 12.85mm

2g (typical)

MULTIBAND-HELIX-1539
OMNISTAR-GPS-GLONASS-BDS
ANTENNA 100-00049-01

-40 - +85C

(Y) IP67/68

SMA/U.FL or other

no cable standard

SMA

screw-on standard

-40 - +85C

(Y) IP67/68

SMA/U.FL or other

no cable standard

SMA

screw-on standard

-40 - +85C

(Y) IP67/68

SMA/U.FL or other

no cable standard

SMA

screw-on standard

passive

-40 - +85C

(Y) IP67/68

SMA/U.Fl or other

no cable standard

SMA

screw-on standard

passive

-40 - +85C

(Y) IP67/68

SMA/U.Fl or other

no cable standard

SMA

screw-on standard

-40 - +85C

(Y) IP67/68

SMA/U.Fl or other

no cable standard

SMA

screw-on standard

-40 - +85C

(Y) IP67/68

SMA/U.Fl or other

no cable standard

SMA

screw-on standard

-40 - +85C

(Y) IP67 and UV


Stable

SMA Plug (M) standard customization on demand

508 mm standard customization on demand

Screw mount w/ cable and


connector

Screw mount

-40 - +85C

(Y) IP67/68

TNC, SMA, SMB, MCX

1500 mm

Mag mount w/ cable and


connector

Mag mount w/ cable

Integrated 3 pin connector

3 pin

1.5 dB
(typical)

0.8 dB
(typical) LNA
chain only

3-12 V

25 mA (typical)

30 mA (typical)
@ 3.3 V

2.5 to 5 V

7 mA @ 2.5 V / 11
mA @ 3.5 V

1575 MHz

1.5 (max)

1dB (typical) /
1.5dB (max)

passive

-40 - +85C

(N) (embedded)

3 pin, U.FL or other

no cable standard

29.99 x 17mm

1539 MHz-1610 MHz

2.0:1 (max) @ 50
Ohm U.FL connector

2.0 dB (typical) @
bore-sight

Peak bore-sight gain


0.2 dBic (typical)
@1575 MHz

-40 - +85C

(N) (embedded)

U.FL or other

no cable standard

MPA-104 (Passive) L1 GPS


10mm Patch

2012

10 x 10 x 4mm

1575 MHz

1.3:1

1.5 dB (typical) /
2.5 dB (max)

passive

-40 - +85C

(N) (embedded)

Pin connector

no cable standard

adhesive/embedded

embedded

MPA-124 (Passive) L1 GPS


12mm Patch

2012

12 x 12 x 4mm

1575 MHz

1.3:1

1.5 dB (typical) /
2.5 dB (max)

passive

-40 - +85C

(N) (embedded)

Pin connector

no cable standard

adhesive/embedded

embedded

MPA-154 (Passive) L1 GPS


15mm Patch

2012

15 x 15 x 4mm

1575 MHz

1.3:1

1.5 dB (typical) /
2.5 dB (max)

passive

-40 - +85C

(N) (embedded)

Pin connector

no cable standard

adhesive/embedded

embedded

MPA-184 (Passive) L1 GPS


18mm Patch

2012

18 x 18 x 4mm

1575 MHz

1.3:1

1.5 dB (typical) /
2.5 dB (max)

passive

-40 - +85C

(N) (embedded)

Pin connector

no cable standard

adhesive/embedded

embedded

MPA-254 (Passive) L1 GPS


25mm Patch

2012

25 x 25 x 4mm

1575 MHz

1.3:1

1.5 dB (typical) /
2.5 dB (max)

passive

-40 - +85C

(N) (embedded)

Pin connector

no cable standard

adhesive/embedded

embedded

MIA-GPS-10 (Active) L1 GPS


10mm Patch

2012

10.2 x 10.2 x 6.7mm

1575 MHz

1.3

1.5 dB (typical) /
2.5 dB (max)

25.5 dB @ 2.5 V /
28.5 dB @ 3.5 V

2.5 to 3.5 V

9 mA @ 2.5 V / 15
mA @ 3.5 V

-40 - +85C

(N) (embedded)

U.FL or other

no cable standard

adhesive/embedded

embedded

MIA-GPS-12 (Active) L1 GPS


12mm Patch

2012

12 x 12 x 5.9mm

1575 MHz

1.3

1.5 dB (typical) /
2.5 dB (max)

20 dB @ 2.5 V / 24
dB @ 3.5 V

2.5 to 3.5 V

4 mA @ 2.5 V / 7
mA @ 3.5 V

-40 - +85C

(N) (embedded)

U.FL or other

no cable standard

adhesive/embedded

embedded

MIA-GPS-15 (Active) L1 GPS


15mm Patch

2012

16.38 x 16.38 x
4.89mm

1575 MHz

1.3

1.5 dB (typical) /
2.5 dB (max)

16 dB @ 2.5 V / 16
dB @ 3.5 V

2.5 to 3.5 V

4 mA @ 2.5 V / 7
mA @ 3.5 V

-40 - +85C

(N) (embedded)

U.FL or other

no cable standard

adhesive/embedded

embedded

MIA-GPS-18 (Active) L1 GPS


18mm Patch

2012

18.42 x 18.42 x
5.59mm

1575 MHz

1.3

1.5 dB (typical) /
2.5 dB (max)

24 dB @ 2.5 V / 28
dB @ 3.5 V

2.5 to 3.5 V

5 mA @ 2.5 V / 7
mA @ 3.5 V

-40 - +85C

(N) (embedded)

U.FL or other

no cable standard

adhesive/embedded

embedded

MIA-GPS-25 (Active) L1 GPS


25mm Patch

2012

25.27 x 25.27 x
9.13mm

1575 MHz

1.3

1.5 dB (typical) /
2.5 dB (max)

34 dB @ 2.5 V / 34
dB @ 3.5 V

2.5 to 5 V

7 mA @ 2.5 V / 11
mA @ 3.5 V

-40 - +85C

(N) (embedded)

U.FL or other

no cable standard

adhesive/embedded

embedded

MPA-D254-1621 (Passive) Iridium


25mm - IRIDIUM CERTIFIED

2012

25 x 25mm antenna
w/ 45 x 45mm ground
plane

1616-1626 MHz

1.3:1

4 dB (typical)

Passive

-40 - +85C

(N) (embedded)

U.FL or other

100 mm cable with custom


connector

adhesive/embedded

embedded

MPA-1618 (Passive) Globalstar


25mm

2012

25 x 25 x 4mm

1618 MHz

1.3:1

2.5 dB (typical) / 5
dB (max)

Passive

-40 - +85C

(N) (embedded)

U.FL or other

no cable standard

adhesive/embedded

embedded

MPA-1516 (Passive) GPS/


GLONASS 25mm

2012

25 x 25 x 4mm

1590 MHz

(N) (embedded)

U.FL or other

no cable standard

adhesive/embedded

embedded

MPA-1516 (Active) GPS/GLONASS


25mm

2012

25 x 25 x 9.13mm

14g

1590 MHz

1.5:1

(N) (embedded)

U.FL or other

no cable standard

embedded

Microwave Photonic Systems


www.b2bphotonics.com

OFW-3478, Fiber Optic Antenna


Link, Multidrop

2002

DELMOT

6in D

500g

L1, L2

1.5:1

TNC Femle

up to 10km

Multiple

12,000.00

Fiber Optic Antenna Link

NavCom Technology, Inc.


www.navcomtech.com

ANT-3001R

2009

DGLMN

5.75 x 2.46in

1.1lb

1570 45 & 1164-1260 MHz

2.0:1

ANT-3001A

2009

DGLMN

5.75 x 2.46in

1.1lb

1570 45 & 1164-1260 MHz

2.0:1

ANT-3001BR

2009

14.82 x 13.83in

10.5lb

1570 45 & 1164-1260 MHz

GNSS-501

2015

LNOPRV

45 x 155 mm

450g

GNSS-502

2015

LNOPRV

45 x 155 mm

GPS-703-GGG

2009

DGLMNOPRV

GPS-703-GGG-HV

2014

DGLMNOPRV

NovAtel, Inc.
www.novatel.ca

S10 G P S W O R L D

WWW.GPSWORLD.COM

Passive
1 dB (min)

30 dB @ 2.5 V / 32
dB @ 5 V

2.5 to 5V

11 mA (max)

-40 - +85C

embedded

35 dB

Omni-Directional

<2 dB

+5V to +18V DC

<50 mA

-40 to +85

Random & Sinusoidal


Certified

Yes, MIL-STD-810F

3 dB Max @
Boresight

39 dB

RHCP

2.6 dB Max

+4.2 +15 VDC

65 mA

-55C TO +85C

nr

TNC Female

Antenna Cable / 12ft

Pole Mount

nr

nr

3 dB Max @
Boresight

39 dB

RHCP

2.6 dB Max

+4.2 +15 VDC

65 mA

-55C TO +85C

nr

TNC Female

Antenna Cable / 12ft

Fuselage/Vehicle Flush Mount


(FAA Certified)

nr

nr

2.0:1

3 dB Max @
Boresight

38 dB

RHCP

2.6 dB Max

+4.2 +15 VDC

65 mA

-55C TO +85C

nr

TNC Female

Antenna Cable / 12ft

Roof Mount

nr

nr

1588.5 23.0 MHz


1545.0 20.0 MHz

2.0:1

3 dB max

L1/B1/E1/G1:
4.0 dBic min / 29
dB typ

RHCP

2.5 dB typ

3.3 - 18 VDC

20 mA typ

-40 to +85

MIL-STD-810G(CH1),
514.7 Annex E;
Procedure 1,
Category 24

Y/Water Resitant to
IP67, IP69K

N/N

TNC

na

2 magnetic mounts
2 M4 screw inserts

Inquire

nr

450g

1588.5 23.0 MHz


1220.0 31.0 MHz
1545.0 20.0 MHz

2.0:1

3 dB max

L1/B1/E1/G1:
4.0 dBic min / 29
dB typ

RHCP

2.5 dB typ

3.3 - 18 VDC

20 mA typ

-40 to +85

MIL-STD-810G(CH1),
514.7 Annex E;
Procedure 1,
Category 24

Y/Water Resitant to
IP67, IP69K

N/N

TNC

na

2 magnetic mounts
2 M4 screw inserts

Inquire

nr

69 x 185mm

500g

1580.5 28.5 MHz


1210.0 45 MHz

2.0:1

3 dB max

L1: 5 dBic / 29 dB
typ; L2: 3 dBic / 29
dB typ; L5: 3 dBic /
29 dB typ

RHCP

2.0 dB typ

4.5 - 18 V DC

36 mA typ

-40 to +85

MIL-STD-810F method
514.5; ASAE EP455
Section 5.15.2 Level 1

Y/Water Resistant
to IPX7

Y/Y

TNC

na

Threaded

Inquire

nr

69 x 185mm

530g

1580.5 28.5 MHz


1210.0 45 MHz

2.0:1

3 dB max

L1: 5 dBic / 29 dB
typ; L2: 3 dBic / 29
dB typ; L5: 3 dBic /
29 dB typ

RHCP

2.0 dB typ

4.5 - 18 V DC

36 mA typ

-40 to +85

MIL-STD-810G
514.6E-1, Category
24; MIL-STD-810G
514.6C-3, Category 4;
ASAE EP455 Section
5.15.2 Level 1; ISO
9022-3 Method 36

Y/Water Resistant
to IPX7

Y/Y

TNC

na

Threaded

Inquire

nr

FEBRUARY 2016

FEBRUARY 2016

WWW.GPSWORLD.COM

G P S W O R L D S11

ANTENNA SURVEY 2016

Manufacturer

OriginGPS LTD.
www.origingps.com

Parsec Technologies, Inc.


www.parsec-t.com

sponsored by

Model

Intro. Date

User Environment 1

Size: Length x Width


x Height

Weight

Frequency/Bandwidth 2

VSWR 3

Axial Ratio
(dB)

Gain/Gain with
Amplifier (dB)

Pattern

Noise Figure
(dB) 4

Amplifier DC Voltage Amplifier Current


(mA)

Operating Temperature
(C)

Vibration

Environmentally
Sealed (Y/N)/Type

L/D 5

Connectors

Cable Type/Length

Mounting Configuration

List Price in U.S. Dollars

Integration

GPS-702-GG

2006

DGLMNOPRV

69 x 185mm

500g

1588.5 23 MHz
1236.0 18.3 MHz

2.0:1

3 dB max

L1: 5 dBic / 29
dB typ
L2: 2 dBic / 29
dB typ

RHCP

2.5 dB typ

4.5 - 18 V DC

35 mA typ

-40 to +85

MIL-STD-202F
method 214

Y/Water Resistant
to IPX7

Y/Y

TNC, N

na

Threaded

Inquire

nr

GPS-702-GG-HV

2014

DGLMNOPRV

69 x 185mm

530g

1588.5 23 MHz
1236.0 18.3 MHz

2.0:1

3 dB max

L1: 5 dBic / 29
dB typ
L2: 2 dBic / 29
dB typ

RHCP

2.5 dB typ

4.5 - 18 V DC

35 mA typ

-40 to +85

MIL-STD-810G
514.6E-1, Category
24; MIL-STD-810G
514.6C-3, Category 4;
ASAE EP455 Section
5.15.2 Level; ISO
9022-3 Method 36

Y/Water Resistant
to IPX7

Y/Y

TNC

na

Threaded

Inquire

nr

GPS-702L

2005

DGLMNOPRV

69 x 185mm

500g

1575.4 20 MHz
1227.6 20 MHz
1543 20 MHz

2.0:1

3 dB max

L1: 5 dBic / 27
dB typ
L2: 1.5 dBic / 27
dB typ
L: 5 dBic / 27
dB typ

RHCP

2.5 dB typ

4.5 - 18 V DC

35 mA typ

-40 to +85

MIL-STD-810F method
514.5; ASAE EP455
Section 5.15.2 Level 1

Y/Water Resistant
to IPX7

Y/Y

TNC

na

Threaded

Inquire

nr

GPS-701-GGL

2007

DGLMNOPRV

69 x 185mm

500g

1588.5 23 MHz
1545 20 MHz

2.0:1

3 dB max

L1, L: 5 dBic / 29
dB typ

RHCP

2.5 dB typ

4.5 - 18 V DC

35 mA typ

-40 to +85

MIL-STD-202F method
214; SAEJ1211
section 4.7

Y/Water Resistant
to IPX7

Y/Y

TNC

na

Threaded

Inquire

nr

GPS-701-GG

2006

DGLMNOPRV

69 x 185mm

500g

1575.4 -10/+36 MHz

2.0:1

3 dB max

L1, L: 5 dBic / 29
dB typ

RHCP

2.5 dB typ

4.5 - 18 V DC

35 mA typ

-40 to +85

MIL-STD-202F method
214; SAEJ1211
section 4.7

Y/Water Resistant
to IPX7

Y/Y

TNC

na

Threaded

Inquire

nr

GPS-704X

2006

DGLMNOPRV

69 x 185mm

468g

1.15GHz -1.65 GHz

2.0:1

3 dB max

L1, L: +6 dBic
L2, L5: +2 dBic

RHCP

nr

nr

Passive

-40 to +85

nr

Y/nr

Y/Y

TNC

na

Threaded

Inquire

nr

Pinwheel OEM

2013

DGLMNOPRV

30 x 143mm

120g

1525-1611 MHz
1164-1254 MHz

2.0:1

3 dB max

L1/L: 3 dBic / 23
dB typ
L2: 2 dBic / 23
dB typ
E5b/B2: 0 dBic / 23
dB typ

RHCP

2.0 dB typ

5 V DC

35 mA typ

-40 to +85

MIL-STD-202F;
SAEJ1211 Section 4.7

Y/Y

R/A MMCX

na

Screw Flange

Inquire

Required

ANT-26C1GA-TBW-N

2006

ALGMV

18 x 66mm

113g

1575.4 12 MHz

1.5:1

2 dB typ

33 dB typ

RHCP

2.4 dB typ

2.5 - 24 V DC

<30 mA typ

-55 to +85

>30 Gs

Y/nr

Y/Y

TNC

na

4-hole back mount, surface

Inquire

nr

ANT-26C1GOA-196MNSB

2012

LGMOV

19 x 63mm

184g

1575.4 15 MHz
1609.0 7 MHz
1542.0 14 MHz

1.5:1

2 dB typ

33 dB typ

RHCP

3 dB typ

2.5 - 24 V DC

<40 mA typ

-55 to +85

>30 Gs

Y/nr

Y/Y

SMA Male

7.7 m/RG-316

4-hole back mount, flush


magnetic

Inquire

nr

3GOXX16A4-XTR-1-2-CERT

2013

ALGMV

18 x 89mm

184g

1575.4 12 MHz

1.5:1

2 dB typ

33 dB typ

RHCP

2.2 dB typ

2.5 - 24 V DC

<30 mA typ

-55 to +85

>30 Gs

Y/nr

Y/Y

TNC

na

4-hole, surface

Inquire

nr

3GOXX16A4-XTR-1-1-CERT

2013

ALGMV

19 x 89mm

191g

1575.4 15 MHz
1227.6 15 MHz

1.5:1

2 dB typ

33 dB typ

RHCP

3.0 dB typ

2.5 - 24 V DC

<50 mA typ

-55 to +85

>30 Gs

Y/nr

Y/Y

TNC

na

4-hole, surface

Inquire

nr

42G1215A-XT-1-CERT

2013

ALGMV

119 x 76 x 18mm
(ARINC 743A)

198g

1575.4 12 MHz
1227.6 12 MHz

1.5:1

2 dB typ

33 dB typ

RHCP

3.0 dB typ

2.5 - 24 V DC

<35 mA typ

-55 to +85

>30 Gs

Y/nr

Y/Y

TNC

na

4-hole, surface

Inquire

nr

42GO16A4-XT-1-CERT

2013

ALGMV

119 x 76 x 20mm
(ARINC 743A)

191g

1525-1595 MHz
1602-1626 MHz

1.5:1

2 dB typ

40 dB typ

RHCP

3.0 dB typ

2.5 - 24 V DC

<39 mA typ

-55 to +85

>30 Gs

Y/nr

Y/Y

TNC

na

4-hole, surface

Inquire

nr

42G1215A-XT-1-2-CERT

2013

ALGMV

119 x 76 x 20mm
(ARINC 743A)

191g

1575.4 12 MHz
1227.6 12 MHz
1542.5 17.5 MHz

1.5:1

2 dB typ

33 dB typ

RHCP

1.9 dB typ

2.5 - 24 V DC

<35 mA typ

-55 to +85

>30 Gs

Y/nr

Y/Y

TNC

na

4-hole, surface

Inquire

nr

42G1215A-XT-1-3-CERT

2013

ALGMV

119 x 76 x 20mm
(ARINC 743A)

191g

1575.4 12 MHz
1227.6 12 MHz
1542.5 17.5 MHz

1.5:1

2 dB typ

40 dB typ

RHCP

1.9 dB typ

2.5 - 24 V DC

<35 mA typ

-55 to +85

>30 Gs

Y/nr

Y/Y

TNC

na

4-hole, surface

Inquire

nr

42GOXX16A4-XT-1-1-CERT

2013

ALGMV

119 x 76 x 23mm
(ARINC 743A)

227g

1575.4 15 MHz
1609 7 MHz
1227.6 12 MHz
1252.5 7.5 MHz
1542.5 14 MHz

2.0:1

2 dB typ

33 dB typ

RHCP

3.0 dB typ

2.5 - 24 V DC

35 mA @ 3.3V typ

-55 to +85

>30 Gs

Y/nr

Y/Y

TNC

na

4-hole, surface

Inquire

nr

ANT-C2GA-TW-N

2006

GLR

223 x 308mm

4.1kg

1575.4 13 MHz
1227.6 13 MHz

1.5:1

nr

32 dB typ

RHCP

3.0 dB typ

2.5 - 24 V DC

<35 mA typ

-55 to +85

>30 Gs

Y/nr

Y/Y

TNC

na

Threaded

Inquire

nr

GNSS-750

2008

GLR

380 x 200mm

7.6kg

1525-1612 MHz
1164-1301 MHz

1.5:1

2 dB @ zenith

5 dBic / 43 dB typ

RHCP

2.0 dB typ

3.3 -12 V DC

70 mA typ

-55 to +85

ISO 9022-3 Method 36

Y/MIL-STD-810F
IEC-60529

Y/Y

N-Type with TNC adaptor supplied

na

Threaded

Inquire

nr

Micro Hornet (ORG1410)

2012

DLMNTV

10 x 10 x 5.8mm

2.5g

GPS L1, SBAS (WAAS,


EGNOS), QZSS

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
Receiver

Hemispheric, RHCP

na, Integrated
Receiver

1.8V or 2 - 5.5V

8 (low power
tracking)

-40C to +85C

na

na

SMD LGA10

Contact Distributor

GPS Receiver Module With


Integrated Antenna

Nano Hornet (ORG1411)

2014

DLMNTV

10 x 10 x 3.8mm

1.6g

GPS L1, SBAS (WAAS,


EGNOS), QZSS

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
Receiver

Hemispheric, RHCP

na, Integrated
Receiver

1.8V or 2 - 5.5V

8 (low power
tracking)

-40C to +85C

na

na

SMD LGA10

Contact Distributor

GPS Receiver Module With


Integrated Antenna

Hornet (ORG1415)

2010

LMNTV

17 x 17 x 4.8mm

3.5g

GPS L1, SBAS (WAAS,


EGNOS), QZSS

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
R+A4:J4eceiver

Hemispheric, RHCP

na, Integrated
Receiver

2 - 5.5V

10 (low power
tracking)

-40C to +85C

na

na

SMD LGA22

Contact Distributor

GPS Receiver Module With


Integrated Antenna

AB1 Hornet (ORG1415-AB1)

2011

ELMNTV

18 x 20 x 5.6mm

4.2g

GPS L1, SBAS (WAAS,


EGNOS), QZSS

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
Receiver

Hemispheric, RHCP

na, Integrated
Receiver

2 - 5.5V

10 (low power
tracking)

-40C to +85C

na

5 position hole array

na

Through Hole

Contact Distributor

GPS Receiver Module With


Integrated Antenna

Ultra Sensitive Hornet (ORG1418)

2010

LMNTV

18 x 18 x 4.8mm

4.8g

GPS L1, SBAS (WAAS,


EGNOS), QZSS

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
Receiver

Hemispheric, RHCP

na, Integrated
Receiver

1.8V or 2 - 5.5V

10 (low power
tracking)

-40C to +85C

na

na

SMD LGA22

Contact Distributor

GPS Receiver Module With


Integrated Antenna

Snap-In Snap-Out Hornet


(ORG4502)

2015

ELMNTV

18.5 x 28 x 7mm

8g

GPS L1, GLONASS L1,


SBAS (WAAS, EGNOS),
QZSS

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
Receiver

Hemispheric, RHCP

na, Integrated
Receiver

2 - 6V

10 (low power
tracking)

-40C to +85C

na

10 position ZIF connector

na

FPC cable

Contact Distributor

GPS Receiver Module With


Integrated Antenna

Multi Hornet (ORG1218)

2013

LMNTV

17 x 17 x 6mm

8g

GPS L1, GLONASS L1,


SBAS (WAAS, EGNOS),
QZSS, Galileo and Beidou
Ready

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
Receiver

Hemispheric, RHCP

na, Integrated
Receiver

3 - 3.6V

40 (full power
tracking)

-40C to +85C

na

na

SMD LGA22

Contact Distributor

GNSS Receiver Module With


Integrated Antenna

Multi Micro Hornet (ORG1510-R01)

2015

DLMNTV

10 x 10 x 5.9mm

2.5g

GPS L1, GLONASS L1,


SBAS (WAAS, EGNOS),
QZSS, Galileo and Beidou
Ready

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
Receiver

Hemispheric, RHCP

na, Integrated
Receiver

3 - 3.6V

10 (low power
tracking)

-40C to +85C

na

na

SMD LGA10

Contact Distributor

GPS Receiver Module With


Integrated Antenna

Multi Micro Hornet (ORG1510MK04)

2015

DLMNTV

10 x 10 x 6.1mm

2.4g

GPS L1, GLONASS L1,


SBAS (WAAS, EGNOS),
QZSS, Galileo and Beidou
Ready

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
Receiver

Hemispheric, RHCP

na, Integrated
Receiver

1.8V

10 (low power
tracking)

-40C to +85C

na

na

SMD LGA10

Contact Distributor

GNSS Receiver Module With


Integrated Antenna

ORG9805

2012

LMNTV

49 x 39 x 15mm

106g including cable


and connector

1575 / 20MHz

1.5 :1

2.0 (max)

4dBic (min) /
27dB (typ)

Hemispheric, RHCP

1.5 (max)

3 - 5V

8.5 (typ)

-40C to +85C

Sine sweep 5 55 5
Hz, 1 octave/min

Y / IP66

SMA plug

RG-174 / 5m

Magnetic base

Contact Distributor

GPS Active Antenna

ORG9802

2011

LMNTV

13.4 x 13.4 x 6.5mm

4g / 6.3g including
150mm cable and
connector

1575 / 10MHz

1.5 :1

2.5 (max)

-1dBic / na

Hemispheric, RHCP

na, Passive
Antenna

na, Passive Antenna

na, Passive
Antenna

-40C to +85C

na

Hirose W.FL / I-pex MHFIII plug

AWG36 / 43mm or 150mm

na

Contact Distributor

GPS Passive Antenna

ORG12-4T GPS

2011

LMNTV

12 x 12 x 4mm

3.4g

1575 / 10MHz

1.5 :1

3.0 (max)

-1.3dBic / na

Hemispheric, RHCP

na, Passive
Element

na, Passive Element

na, Passive
Element

-40C to +85C

Sine sweep 5 55 5
Hz, 1 octave/min

na

Manual Soldering

Contact Distributor

GPS Antenna Element

ORG12-4T GNSS

2014

LMNTV

12 x 12 x 4mm

3.4g

GPS L1 / GLONASS L1

1.5 :1

3.0 (max)

-1.3dBic / na

Hemispheric, RHCP

na, Passive
Element

na, Passive Element

na, Passive
Element

-40C to +85C

Sine sweep 5 55 5
Hz, 1 octave/min

na

Manual Soldering

Contact Distributor

GPS/GLONASS Antenna
Element

ORG18-4T

2012

LMNTV

18 x 18 x 4mm

6.5g

GPS L1 / GLONASS L1

1.5 :1

3.0 (max)

0.3dBic / na

Hemispheric, RHCP

na, Passive
Element

na, Passive Element

na, Passive
Element

-40C to +85C

Sine sweep 5 55 5
Hz, 1 octave/min

na

Manual Soldering

Contact Distributor

GPS/GLONASS Antenna
Element

PTA1.5-9 - Antenna

13-Dec

ALMNOPTV

9 x 7.0 x 0.8mm

.5g

1560 -1610 MHz

1.5:1

na

0.9dB max- No LNA

LP

No LNA

na

na

na

na

na

na

na

na

SMT

call

GPS/GNSS

PTA1.5-16- Antenna

13-Dec

ALMNOPTV

16.25 x 7.0 x 0.8mm

.5g

1560 -1610 MHz

1.5:1

na

2.1dB max No LNA

LP

No LNA

na

na

na

na

na

na

na

na

SMT

call

GPS/GNSS

PTA1.5-V- Antenna

13-Dec

ALMNOPTV

14.25 x 6.0 x 0.8mm

.5g

1560 -1610 MHz

1.5:1

na

2.1dB max No LNA

LP

No LNA

na

na

na

na

na

na

na

na

SMT

call

GPS/GNSS

PTA1.5M-9 - Active Antenna

13-Dec

ALMNOPTV

9 x 9.175 x 1.3mm

1.5g

1560 -1610 MHz

1.5:1

na

15dB

LP

1.25dB

1.8 -6v

4mA-50mA

0-85

na

na

na

na

na

SMT

call

GPS/GNSS

PTA1.5M-16- Active Antenna

13-Dec

ALMNOPTV

16.25 x 9.175 x 1.3mm

1.5g

1560 -1610 MHz

1.5:1

na

15dB

LP

1.25dB

1.8-6v

4mA-50mA

0-85

na

na

na

na

na

SMT

call

GPS/GNSS

PTA020

15-Jul

ALMNOPTV

45 x 17 x 3mm

14.5g

1560MHz-1610MHz

1.5:1

na

1.5dBi

LP

0.65dB

1.0-5v

2.5mA-50mA

0-85

na

na

na

na

na

U.FL

call

GPS/GNSS

PTA070

15-Jul

ALMNOPTV

36.5 x 29.5 x 3mm

18.5g

1560MHz-1610MHz

1.5:1

na

na

LP

0.65dB

1.0-5v

2.5mA-50mA

0-85

na

na

na

na

na

U.FL

call

GPS/GNSS

PTA 1600

15-Dec

ALMNOPTV

65.4 x 17.15 x2.5mm

16.5g

1560MHz-1610MHz

1.5:1

na

6.2dBi

LP

0.65dB

1.0-5v

2.5mA-50mA

0-85

na

na

na

na

na

U.FL

call

GPS/GNSS

S12 G P S W O R L D

WWW.GPSWORLD.COM

FEBRUARY 2016

FEBRUARY 2016

WWW.GPSWORLD.COM

G P S W O R L D S13

ANTENNA SURVEY 2016

Manufacturer

Model

PCTEL
www.antenna.com

Raytheon UK
www.raytheon.co.uk

Intro. Date

sponsored by

User Environment 1

Size: Length x Width


x Height

Weight

Frequency/Bandwidth 2

VSWR 3

Axial Ratio
(dB)

Gain/Gain with
Amplifier (dB)

Pattern

Noise Figure
(dB) 4

Amplifier DC Voltage Amplifier Current


(mA)

Operating Temperature
(C)

Vibration

Environmentally
Sealed (Y/N)/Type

L/D 5

Connectors

Cable Type/Length

Mounting Configuration

List Price in U.S. Dollars

Integration

8111D-HR

DLMNOPTV

1.77 x 2.01 x 0.47in

0.26lb

GPS L1, GLONASS L1 /


1574-1610MHz

1.5:1

nr

3 dBic / 26 dB

RHCP

< 2.0 dB
(typ.)

2.8-6 VDC

< 25 mA (typ.)

-40 to +85

3 axis, sweep=15
min 10-200 Hz log
sweep:3G

SMA Male, options available

RG174 / 3M

Magnetic (5lb lift-off) or


screw mount

62.35

High Rejection Magnet Mount


Antenna

GPS-L1L2-28MAG

ADLMNOPTV

2.75 D x 0.95in H

5.7oz

GPS L1 (+/-10MHz), GPS L2


(+/-10MHz)

<2.0:1

< 4 dB @ 30
elevation; < 3 dB
@ 45 elevation;
< 2 dB @ 70
elevation

>3 dBic @ 10
elevation; 4 dBic @
90 elevation / 33
dB @ GPS L1; 35
dB @ GPS L2

RHCP

2.5 dB

2.5-5.5 VDC

37mA (typ.), 50mA


(maximum)

-40 to +85

Mil Std 810F, Method


514.5, Procedure II,
Category 5

SMA Female

na

Magnetic > 20lb pull force

425

Precision Guidance, MIL-Grade


L1/L2 Active Magnet Mount
Antenna

GPSGL-TMG-RCVR422

LOPT2

3.2 D x 5.0in H

0.6lb

GPS L1, GALILEO E1,


GLONASS L1

<2.0:1

nr

4 dBic / 28 dB`

RHCP

< 2.5 dB
(typ.)

nr

nr

-40 to +85

0.008 g2/Hz 5 to 20
Hz, 0.05 g2/Hz 20 to
100 Hz

12-pin circular connector conforming


IEC 60130-9.v3.0

na

Medium duty mount with


grounding screw

773.5

GPS/GLONASS Integrated
Receiver + Timing Antenna

GEO-GNSS-AC-S1

DHLMNOPTV

0.8 D x 3.4in H

1.23oz

GPS L1, GLONASS L1 /


1574-1610MHz

1.5:1 (typ.)

nr

-2.0dBic / 26.5dB
(typ.)

RHCP

<2.0 dB

2.5-5.5V (operating)
12.0V (survivability)

20mA

-40 to +85

nr

SMA Male, SMA Female

na

Panel Mount, Direct Connect or


Cable Connection

95.77

Handheld GNSS, Helical,


High Rejection, Rugged Active
Antenna

GLHPDM3-SF

12/31/2015

DLMNOPV

5.1 x 3.6in; (130 x


92mm)

GPS L1, GLONASS L1 /


1574-1610MHz; 698-960
MHz; 1710-2170 MHz;
2300-2700 MHz; 2.4-2.5 GHz;
4.9-5.9 GHz

< 2.0:1

nr

2.5 dBi (4G LTE),


3-4 dBi (Wi-Fi) / 26
dB +/- 3 dBic

Vertical, linear
(Comms), RHCP
(GPS)

< 2.0 dB
(typ.)

2.8-6.0 V (operating)
12.0 V (survivability)

25 mA (typical)

-40 to +85

nr

Y / IP67

Two (2) SMA Male (4G LTE); Three


(3) Reverse Polarity SMA Male
(Wi-Fi); One (1) SMA Male (GNSS
GPS/Glonass)

Two (2) 17 ft. Pro-Flex Plus


195; (4G LTE Elements);
Three (3) 17 ft. Pro-Flex Plus
195; (Wi-Fi Elements); One
(1) 17 ft. RG-174/U; (GNSS
Element)

1-inch hole, 3/4-inch; long (.75)


zinc stud; mount with jam nut

399

Multiband LTE MIMO, 802.11ac


MIMO and high rejection GNSS
(GPS L1/Glonass) Antenna

GPSDLTEMIMO-LTB

12/31/2015

DLMNOPV

4.05 x 3.46in

GPS L1, 4G LTE 698-960


MHz; 1710-2170 MHz;
2300-2700 MHz); Wi-Fi (2.42.5GHz, 4.9-5.9GHz)

< 2.0:1

nr

2.5 dBi (4G LTE),


3-4 dBi (Wi-Fi) / 26
dB +/- 3 dBic

Vertical, linear
(Comms), RHCP
(GPS)

1.8 dB (typ.)

2.8-6.0 V (operating)
12.0 V (survivability)

20 mA (nominal)

-40 to +85

nr

Y / IP67

MSMA (4G LTE), RP-MSMA (Wi-Fi),


MSMA (GPS L1)

Two-17 feet Pro-Flex Plus


195; (4G LTE Elements);
Two-17 feet Pro-Flex Plus 195;
(802.11n Wi-Fi Elements);
One-17 feet RG-174/U (GPS
Element)

1-inch hole, 3/4-inch long (.75);


zinc stud mount with jam nut

375

Multiband LTE MIMO, 802.11ac


MIMO and high rejection GPS
L1 Antenna

GPS-TMG-HR-26N

LOPT

5.0 H x 3.2in D

0.6lb

GPS L1 (+/-10MHz)

1.5:1

nr

3.5 dBic / 26.5 dB

RHCP

4.0 dB
(typ.)

3.3-12V

40 mA

-40 to +85

0.008 g2/Hz 5 to 20
Hz, 0.05 g2/Hz 20 to
100 Hz

N Female

na

Mounting Options to pipes


1-1.45

225

High Rejection Timing Antenna

GNSS1-TMG-26N

LOPT

5.0 H x 3.2in D

0.6lb

GPS L1, GALILEO E1,


GLONASS L1, BEIDOU B1

< 2.0:1

nr

3 dBic / 26.5 dB
3 dB @ GPS
L1/GALILEO E1;
24.5 dB 3 dB
@ GLONASS L1/
BEIDOU B1

RHCP

< 2.5 dB
(typ.)

3.3-9.0 V

< 35 mA

-40 to +85

0.008 g2/Hz 5 to 20
Hz, 0.05 g2/Hz 20 to
100 Hz

N Female

na

Mounting Options to pipes


1-1.45

260

Global GNSS Timing Antenna

8171D-HR-NDH-W

DLMNOPTV

2.36 x 2.80in

0.15lb

GPS L1, GLONASS L1 /


1574-1610MHz

< 2.0:1

nr

2 dBic / 26 dB (typ.)

RHCP

< 2.0 dB
(typ.)

2.8-6.0 V

< 25 mA (typ.)

-40 to +85

3 axis, sweep = 15
min 10-200 Hz log
sweep:3G

N Male

na

Panel mount or bracket mount

98.5

High Rejection, Small Cell


Timing Antenna

GPS-LB12GL-MAG

ADGLNOPV

4.71 x 3.17 x 1.10in

6.8oz

GPS L1, GPS L2, L-Band,


GLONASS G1

< 2.0:1

45 elevation:
9 dB(GPS
L1, L-Band, &
GLONASS), 6dB
(GPS L2)

33 dB +/- 4dB (GPS


L1/L2, GLONASS,
L-BAND)

RHCP

2.5 dB (typ.)

3.3-12.0 VDC

42 mA (typ.)

-40 to +85

Mil Std 810F, Method


514.5, Procedure II,
Category 5

SMA Female

na

Magnetic > 20lb pull force

535

Precision Guidance, MIL-Grade


L1/L2/GLONASS/L-BAND Active
Magnet Mount Antenna

GAS-1 7 Element Anti-Jam

1998

ADLMNOTV

CRPA=350mm
AE=220x60x330mm

CRPA 3.8Kg, AE 4kg

GPS L1/GPS L2
Simultaneous

nr

nr

7-40dB

nr

nr

nr

nr

nr

nr

nr

nr

TNC

nr

nr

nr

ADAP 7 Element Anti-Jam

2005

ADLMNOTV

CRPA=350mm
AE=220x60x330mm

CRPA 3.4Kg, AE 4.5kg

GPS L1/GPS L2
Simultaneous

nr

nr

7-40dB

nr

nr

nr

nr

nr

nr

nr

nr

TNC

nr

nr

nr

Mini-GAS 4 Element Anti-Jam


(Integrated CRPA & AE)

2012

ADLMNOTV

125 x 100mm

1.5kg

GPS L1/GPS L2
Simultaneous

nr

nr

7-28dB

nr

nr

nr

nr

nr

nr

nr

nr

SMA

nr

nr

nr

Landshield 4 Element Anti-Jam


(Integrated CRPA & AE)

2015

ADLMNOTV

115 x 62mm

1kg

GPS L1/GPS L2
Simultaneous

nr

nr

7-38dB

nr

nr

nr

nr

nr

nr

nr

nr

SMA

nr

nr

nr

SAS 5 Element Anti-Jam (AE)

2009

ADLMNOTV

144 x 115 x 76mm

1.5kg

GPS L1/GPS L2
Simultaneous

nr

nr

7-38dB

nr

nr

nr

nr

nr

nr

nr

nr

TNC

nr

nr

nr

MicroGAS 2 Element Anti-Jam,


DAGR & Non DAGR (Integrated
CRPA & AE)

2015

ADLMNOTV

35 x 35 x 70mm

260g

GPS L1/GPS L2
Simultaneous

nr

nr

7-30dB

nr

nr

nr

nr

nr

nr

nr

nr

SMA

nr

nr

nr

MaxiNav

2000

DGLMV

110 x 18mm

150g

1575 5 MHz

<1.5:1

3 dB

6/36 dB

Omni-Directional

1.2 dB

330 V DC

25 mA

-40 to +60c

na

Y/IP68

DC ground

N preferred but all available

As applicable

Magnetic/Pole/ Screw

nr

nr

GPSA9-wide

2004

DLMNRV

115 x 30mm

220g

1535-1576 MHz DGPS-GPS

<1.5:1

3 dB

6/36 dB

Omni-Directional

<1.0 dB

530 V DC

80 mA

-40 to +60c

na

Y/IP68

DC ground

N preferred but all available

As applicable

magnetic/Pole/ Screw

nr

nr

A-GEN-RTA-REVD-3M-CS

2015

DGLMV

134 x 134 x 24mm

150g

GPS L1, Galileo, SBAS

na, Integrated
Receiver

na, Integrated
Receiver

na / Integrated
Receiver

Omni-Directional

na, Integrated
Receiver

5-28VDC

50-60mA

-40 to +85c

na

Y/IP68

dc ground

serial/usb output as required

up to 8 meters

Magnetic/Pole/ Screw

nr

GPS Receiver Module with


Integrated Antenna

A-IGPS-GSM-SMA

2015

DGLMV

135 x 135 x 98mm

200g

GPS L1, Iridium, GSM

<1.5:1

3 dB

6/30,3,0 dB

Omni-Directional

1.2dB

5VDC

30 mA typ.

-40 to +60c

na

Y/IP68

dc ground

SMA/N/TNC

As applicable

Magnetic/Pole/ Screw

nr

nr

A-GPSA56-TRI

2015

DGLMV

134 x 134 x 22mm

170g

1575 5 MHz; 820 to


960 MHz

<1.5:1

3 dB

6/32, 0,2 dB

Omni-Directional

0.6 dB typ.

3.3-20 V DC

30 mA typ.

-40 to +60c

na

Y/IP68

dc ground

SMA/SMA RP

As applicable

Magnetic/Pole/ Screw

nr

nr

L1/L2

2004

DR

154 x 154 x 41mm

730g

1535-1576 MHz; 12201230 MHz

<1.5:1

3 dB

6/36 dB

Omni-Directional

<1.0dB

530 V DC

80 mA

-40 to +60c

na

Y/IP68

DC ground

N preferred but all available

As applicable

Magnetic/Pole/ Screw

nr

nr

A-GPSA80NS

2012

DGLMVT

135 x 135 x 98mm

235g

1575 5 MHz

<1.5:1

3 dB

6/35 dB

Omni-Directional

1.2 dB

315 V DC

35 mA

-40 to +65c

na

Y/IP68

DC ground

N preferred but all available

As applicable

Magnetic/Pole/ Screw

nr

nr

ASH-661 (L1/L2/L5 GNSS Antenna)

2010

GLMNORT

190.5 x 73.15mm
7.50 x 2.88in

0.53kg; 1.12lb

L1/L2/L5 GPS; L1/L2


GLONASS; GALILEO E1/E5a

<2.0:1

3 dB max @
BORESIGHT

38 dB 2 dB

nr

2.5 dB max

+4.2 to +15 VDC

nr

-40 to +70

DO-160D

nr

N/N

TNC (f) coaxial conn. 50 ohms

nr

5/8-11 UNC-2B

nr

nr

ASH-660 (L1 GNSS Antenna)

2010

GLMNORT

190.5 x 73.15mm
7.50 x 2.88in

0.45kg; 1lb

L1 GPS; L1 GLONASS

<2.0:1

3 dB max @
BORESIGHT

38 dB 2 dB

nr

2.5 dB max

+4.2 to +15 VDC

nr

-40 to +70

DO-160D

nr

N/N

TNC (f) coaxial conn. 50 ohms

nr

5/8-11 UNC-2B

nr

nr

GNSS Machine/Marine Antenna

2009

GLMNORT

143 x 38.8 (+9.6)mm


5.755 x 1.53
(+0.38)in

0.45kg; 1lb

L1/L2 GPS; L1/L2 GLONASS;


L-Band

<2.0:1

3 dB max

38 dB 2 dB

nr

2.6 dB max

+4.2 to +15 VDC

60 mA

-55 to +85

D0-160D; ENV CAT:


E1-ABB [CLMY]
XSFDFSZAAACPH
[A3] [2A] CA

nr

N/N

TNC (f) coaxial conn. 50 ohms

nr

8X .213 THRU
82 CSINK x .365

nr

nr

GNSS Choke Ring Antenna

2009

GLOR

376 x 351.2mm
14.82 x 13.83in

4.7kg
10.5lb

L1/L2/L5 GPS
L1/L2 GLONASS
GALILEO E1/E5a
L-Band

<2.0:1

3 dB max @
BORESIGHT

39 dB 2 dB

nr

2.6 dB max

+4.2 to +15 VDC

65 mA

-55 to +85

D0-160D; ENV CAT:


E1-ABB [CLMY]
XSFDFSZAAACPH
[A3] [2A] CA

nr

N/N

TNC (f) coaxial conn. 50 ohms

nr

1-14 UNS-2B THREAD


3X 3/8-16UNC-2B INSERTS
ON A B.C. 12.70

nr

nr

Surrey Satellite Technology


Ltd.
www.sstl.co.uk

SGR Patch Antenna


ASY-00741-04

2000

45 x 50 x 20mm

50g

1574.5 - 1576.5MHz

<2:1

24dB

RHCP

2.5dB

2.7 - 5 VDC

24mA typ

-35 to +60

> 10g

N / outgassing
allowance

N/N

SMA

2m K02252D

4 Screw

Synergy Systems, LLC


www.synergy-gps.com

ART-10S

2006

2.36 x 1.49in

1lb

1575.42MHz/2 MHz min

2 dB

3 dB

28 dB

1.5 dB

2.5 to 5.5 Vdc

12 mA

-30C to +85C

TNC

16ft

3/4in pipe

$41.50

SSA-5

2011

NDV

3.40 D x 1.2in H

10.3oz

1575.42 MHz

1.5 max

3 dB

28 dB

2.0 dB

3.0 Vdc to 6.0 Vdc

11 mA typ; 13
mA max

-40C to +85C

IEC 61373 (1999)

TNC

bulkhead

1-14 Marine Mnt; or bulkhead

$127.50 - $144.50

VP 6000 All GNSS Frequencies +


L-Band Geodetic Antenna

2015

DEGLMNOR

167 D x 124.5mm

700g

GPS L1/L2/L5 + GLONASS


G1/G2/G3 + Galileo E1/
E5/E6 + BeiDou B1/B2/B3
+ L-Band

<1.5:1

< 0.5 @ zenith,


<2.0 @ horizon

5-7 dBic/35 or 50 dB

Hemispherical

<1.5

2.7 to 24

<40

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

TNC or N-Type

5/8 x 11 tpi

Contact distributor or
Tallysman

Room for customer provided


circuitry

TW1421 / TW4421- GPS L1+


GLONASS G1, Dual Feed, Patch
Antenna

2012

ADLNOPTV

35 D x 7.25mm

30g

GPS L1+GLONASS L1/1574


to 1606 MHz

<1.5:1

< 3.5

4.5 dBic/28 dB

Hemispherical

1.25

2.5 to 16

15

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

15 KV ESD
Protection

SMA Male, MCX, MMCX, SMB,


MCX right angle, H.FL., U.FL., SMA
right angle, SSMA

1.5mm dia. CO-6F.FH-SB


cable/custom

Screw or adhesive

Contact distributor or
Tallysman

Custom Tuning available

TW2406 / TW2410 - GPS L1+


GLONASS G1, Dual Feed Antenna

2010

ADLGNOPTV

50 D x 7.8mm

100g

GPS L1+GLONASS L1/1574


to 1606 MHz

<1.5:1

<3

4 dBic/ 28 dB

Hemispherical

2.5 to 16

10

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

15 KV ESD
Protection

MMCX, MCX, SMB, SMC, SMA,


U.FL., SMA Right Angle, Waterproof
SMA, SSMA, Reverse Polarity SMA,
SMA on bulkhead, H.FL.

1.5mm dia. CO-6F.FH-SB


cable/custom

Screw or adhesive

Contact distributor or
Tallysman

Custom Tuning available

TW4721 - Dual Feed GPS/


GLONASS/Galileo/BeiDou L1

2013

DGLMNOPTV

38 x 38 x 14.3mm

50g

1559 - 1606 MHz

<1.5:1

<2

4.5 dBic / 26 dB

Hemispherical

2.5 to 16

10

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

SMA, MMCX, MCX, SMB, SMC,


SMA, SMB, SMA Right Angle,
Waterproof SMA, SSMA, Reverse
Polarity SMA

RG174/ Custom

magnetic or adhesive

Contact distributor or
Tallysman

TW2710 - GPS + GLONASS +


Galileo + BeiDou, Magnet/Screw
Mount, Dual Feed Antenna

2013

ADLGNOPTV

57 D x 15mm

150g

1557 to 1606 MHz

<1.5:1

<2

4.75 dBic / 28 dB

Hemispherical

<1

2.5 to 16

15

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

MMCX, MCX, SMB, SMC, SMA,


U.FL., SMA Right Angle, Waterproof
SMA, SSMA, Reverse Polarity SMA,
SMA on bulkhead, H.FL.

RG174/ Custom

Magnet, screw or adhesive

Contact distributor or
Tallysman

Rojone
www.rojone.com

Spectra Precision
www.spectraprecision.com

Tallysman
www.tallysman.com

S14 G P S W O R L D

WWW.GPSWORLD.COM

FEBRUARY 2016

FEBRUARY 2016

WWW.GPSWORLD.COM

Custom labelling available

G P S W O R L D S15

ANTENNA SURVEY 2016

Manufacturer

Taoglas
www.taoglas.com

Topcon Positioning
Systems, Inc.
www.topconpositioning.com

sponsored by

Model

Intro. Date

User Environment 1

Size: Length x Width


x Height

Weight

Frequency/Bandwidth 2

VSWR 3

Axial Ratio
(dB)

Gain/Gain with
Amplifier (dB)

Pattern

Noise Figure
(dB) 4

Amplifier DC Voltage Amplifier Current


(mA)

Operating Temperature
(C)

Vibration

Environmentally
Sealed (Y/N)/Type

L/D 5

Connectors

Cable Type/Length

Mounting Configuration

List Price in U.S. Dollars

Integration

TW1721 - GPS L1 + GLONASS


G1 + Galileo E1 + BeiDou B1
(Embedded)

2013

ADELMNSV

35 D x 8.75mm

30g

1559 to 1606 MHz

<1.5:1

<2

4.5 dBic / 28 dB

Hemispherical

<1.5

2.5 to 16

10

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

15 KV ESD
Protection

Full range

RG174 or Micro-Coax

Screw

Contact distributor or
Tallysman

Custom Tuning available

TW1430 - GPS L1 + GLONASS


G1 + Galileo E1 + BeiDou B1
(embedded)

2015

ADELMNSV

35 D x 8.75mm

30g

1559 to 1606 MHz

<1.5:1

<2

4.5 dBic / 32 dB

Hemispherical

<1.5

2.5 to 16

10

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

15 KV ESD
Protection

Full range

TW3152 - GPS L1

2015

TL

66.5 x 21mm

150g

1565 - 1585 MHz

<1.5:2

<1

4.5 dBic / 50 dB

Hemispherical

1.5

2.5 to 17

25

-40 to +86

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

TNC or N-Type

TW3870E - GPS L1/L2 + GLONASS


G1/G2 + Galileo E1 + BeiDou B1
(Embedded)

2015

ADMGLMNOSTV

60 D x 15.7mm

75g

1213 to 1261 MHz + 1559 to


1610 MHz

<1.5:1

<2

4.5 dBic and 3dBic


/ 35 dB

Hemispherical

2.5 to 18

25

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

15 KV ESD
Protection

Full range

RG174 or Micro-Coax

Screw

Contact distributor or
Tallysman

Custom Tuning available

TW2920 - GPS L1 + GLONASS G1


+ Galileo E1 + BeiDou B1 + L-band

2015

DGLMNOPTV

57 D x 15mm

100g

1525 - 1610 MHz

<1.5:1

4.25 dBic / 35 dB

Hemispherical

<2.5

2.5 to 19

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

15 KV ESD
Protection

Full range

RG174

Screw, Magnetic or Adhesive

Contact distributor or
Tallysman

TW3970 - GPS L1/L2/L5 +


GLONASS G1/G2/G3 + Galileo E1/
E5 + BeiDou B1/B2 + L-band

2016

DGLMNOPTV

66.5 x 21mm

185g

1164 to 1254 MHz + 1525 1610 MHz

<1.5:1

<2

L1: 3.5dBic / 35dB


L2: 4.5dBic / 35dB
L5: 0dBic / 35dB

Hemispherical

2.5

2.5 to 20

20

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

TNC or N-Type

3/4in (19mm) thru-hole with


option L-bracket or mast mount

Contact distributor or
Tallysman

Conical or low profile radome in


White or Grey

TW3740 - Dual Feed High Gain


GPS/GLONASS/Galileo/BeiDou

2014

DGLMNOPTV

66.5 D x 21mm

150g

1559 to 1606 MHz

<1.5:1

<2

4.25 dBic / 40 dB

Hemispherical

2.5 to 16

15

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

TNC female or N Type on bottom


of base, or MMCX, MCX, SMB,
SMC, SMA, SMB, SMA Right Angle,
Waterproof SMA, SSMA, Reverse
Polarity SMA,

RG174/ Custom

3/4in (19mm) thru-hole with


option L-bracket or mast mount

Contact distributor or
Tallysman

Conical or low profile radome in


White or Grey

TW3400 - GPS L1+ GLONASS,


Thru-hole Mount Antenna - Low
Profile

2010

DGLMNOPTV

66.5 D x 21mm

150g

1574 to 1606 MHz

<1.5:1

4.25 dBic/ 28 dB

Hemispherical

2.5 to 16

10

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

TNC female or N Type on bottom of


base, or MMCX, MCX, SMB, SMC,
SMA, SMB, U.FL., SMA Right Angle,
Waterproof SMA, SSMA, Reverse
Polarity SMA, H.FL.

RG174/ Custom

3/4in (19mm) thru-hole with


option L-bracket or mast mount

Contact distributor or
Tallysman

Conical or low profile radome in


White or Grey

TW3440 - GPS L1+ GLONASS,


Timing Antenna

2012

DGLMNOPTV

66.5 D x 21mm

150g

1574 to 1606 MHz

<1.5:1

4.25 dBic / 40 dB

Hemispherical

2.5 to 16

10

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

TNC female or N Type on bottom of


base, or MMCX, MCX, SMB, SMC,
SMA, SMB, U.FL., SMA Right Angle,
Waterproof SMA, SSMA, Reverse
Polarity SMA, H.FL.

RG174/ Custom

3/4in (19mm) thru-hole with


option L-bracket or mast mount

Contact distributor or
Tallysman

Conical or low profile radome in


White or Grey

TW3710 - GPS + GLONASS +


Galileo + BeiDou, Thru-hole mount,
Dual Feed Antenna

2013

DGLMNOPTV

66.5 D x 21mm

150g

1557 to 1606 MHz

<1.5:1

<2

4.75 dBic / 28 dB

Hemispherical

2.5 to 16

15

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

TNC female or N Type on bottom of


base, or MMCX, MCX, SMB, SMC,
SMA, SMB, U.FL., SMA Right Angle,
Waterproof SMA, SSMA, Reverse
Polarity SMA, H.FL.

RG174/ Custom

3/4in (19mm) thru-hole with


option L-bracket or mast mount

Contact distributor or
Tallysman

Conical or low profile radome in


White or Grey

TW3870 -GPS L1/L2 + GLONASS


G1/G2 + Galileo E1 + BeiDou B1

2015

DGLMNOPTV

66.5 x 21mm

185g

1213 to 1261 MHz + 1559 to


1610 MHz

<1.5:1

<2

4.5 dBic + 3dBic


/ 35 dB

Hemispherical

2.5 to 16

25

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

TNC female or N Type on bottom of


base, or MMCX, MCX, SMB, SMC,
SMA, SMB, U.FL., SMA Right Angle,
Waterproof SMA, SSMA, Reverse
Polarity SMA, H.FL.

RG174/ Custom

3/4in (19mm) thru-hole with


option L-bracket or mast mount

Contact distributor or
Tallysman

Conical or low profile radome in


White or Grey

TW2600 - Iridium Certified Magnet/


Screw Mount, Dual Feed Antenna

2011

DMNV

57 D x 15mm

150g

1616 to 1626.5 MHz

<1.5:1

<3

4.25 dBic / --

Hemispherical

1 (GPS)

na

na

-40 to +85

3g (3 axis, 15min, 10 to
200Hz sweep)

Y/ IP67

15 KV ESD
Protection

MMCX, MCX, SMB, SMC, SMA,


U.FL., SMA Right Angle, Waterproof
SMA, SSMA, Reverse Polarity SMA,
SMA on bulkhead, H.FL.

RG174/ Custom

Magnet, screw or adhesive


mount

Contact distributor or
Tallysman

Custom labelling available

GP.1575.25.2.A.02

May 11

LNOV

25 x 25 x 2mm

na

1575.42

1.5max

3.0 dBi max

2.0dBi typ.

RHCP

na

na

na

-40C to 85C

na

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA , SSMA, Reverse Polarity
SMA, SMA on bulkhead

na

Pin and adhesive tape

Contact Taoglas

Taoglas provides GPS internal


and external antennas suitable
for very small environments to
large automotive and outdoor
applications to many M2M and
IoT brands worldwide. Particular
focus is spend on optimising
axial ratio . We provide GPS
integration testing and tuning
optimisation, including, gain,
efficiency, axial ratio, receive
strength, noise figure, desense
testing for all our customers
worldwide in our own RF
facilities

CGGBP.35.6.A.02

March 14

LNOV

35 x 35 x 6.5mm

na

1561 - 1602 MHz

2.5 max

0-1dBi

3.85dBi typ.

RHCP

na

na

na

-40C to 85C

na

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA , SSMA, Reverse Polarity
SMA, SMA on bulkhead

na

Pin and adhesive tape

Contact Taoglas

AGGBP.25B.07.0060A

April 15

LNOV

25.1 x 25.1 x 7.9mm

11.46g

1561 - 1602 MHz

2.0 max

na

28dBi typ.

RHCP

2.8dBi

1.8-5.5v

10mA typ.

-40C to 85C

na

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA , SSMA, Reverse Polarity
SMA, SMA on bulkhead

coaxial cable 1.13/60mm

Adhesive tape

Contact Taoglas

Cloud FXP611

January 13

LNOV

38 x 37 x 0.15mm

neg.

1559 - 1610 MHz

1.2 max

na

3dBi typ.

linear

na

5.0V

na

-40C to 85C

na

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA , SSMA, Reverse Polarity
SMA, SMA on bulkhead

na

Surface mount

Contact Taoglas

GGBLA.01

March 14

LNOV

3.2 x 1.6 x 0.5mm

neg.

1575.42 - 1608 MHz

2.0 max

na

2.8dBi typ.

linear

na

2.5-5.5V typ.

na

-40C to 85C

na

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA , SSMA, Reverse Polarity
SMA, SMA on bulkhead

na

Surface mount

Contact Taoglas

A.41.A.301111 Hercules Gen II

October 14

LNOV

47.8 x 47.8 x 28.5mm

157g

1575.42 MHz

3.26

3dBi typ.

28dBi typ.

RHCP

2.8 dBi

3.0V typ.

10mA

-40C to 85C

na

Y - IP67 & IP69K

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA , SSMA, Reverse Polarity
SMA, SMA on bulkhead

RG174/3m

Screw Mount

Contact Taoglas

AA.171.301111 MagmaX

January 15

LNOV

53 x 50 x 17mm

92g

1561 - 1602 MHz

<3dBi

28dBi typ.

RHCP

2.4 dBi typ.

3.0V typ.

7.3mA

-40C to 85C

na

Y - IP65

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA , SSMA, Reverse Polarity
SMA, SMA on bulkhead

RG174/3m

Magnetic mount

Contact Taoglas

AA.107.301111 Stingray

February 13

LNOV

55 x 51.7 x 10.8mm

na

1575.42/1602 MHz

na

28dBi typ.

RHCP

2.2 dBi typ.

3.3V typ.

10mA

-40C to 85C

na

Y - IP65

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA , SSMA, Reverse Polarity
SMA, SMA on bulkhead

RG174/3m

Adhesive mount

Contact Taoglas

AA.108.301111 Titan

February 13

LNOV

25 x 25 x 4mm

na

1575.42

1.92 Max

3dB typ.

28dBi typ.

RHCP

1.3dBi typ.

2.5-5.5V typ.

7mA typ.

-40C to 85C

na

Y - IP67

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA, SSMA, Reverse Polarity SMA,
SMA on bulkhead

RG174/3m

Adhesive mount

Contact Taoglas

A.30.A.301111 Ultima

September 15

LNOV

55.23 x 55.23 x
19.6mm

89g

1575-1606

2.0 Max

na

27dBi typ.

RHCP

1.3dBi typ.

2.5-5.5V typ.

10mA

-40C to 85C

na

Y - IP67 and IP69K

na

MMCX, MCX, SMB, SMC, SMA,


U.FL, SMA Right angle, waterproof
SMA, SSMA, Reverse Polarity SMA,
SMA on bulkhead

RG174/3m

Screw Mount

Contact Taoglas

PL-S1

2012

GL

14.2 x 14.2 x 5.4cm


w/o GP, 20.0 x
5.4cm w GP

.430kg

1586.5 25 MHz ; 1236


20 MHz; L-Band 1535
10 MHz

2.0:1

4.5/33

Symmetrical

1.5

3-18

55 (typ)

50C to +85C

IEC 60068-2-34, Test


Fd; IEC 60068-2-6,
Test Fc

Y/IP67

Y/Y

TNC

RG-58/Variable Length

5/8-11 UNC-2B Threaded

Contact distributor

< 1cm centering

PG-S1

2012

GLR

14.2 x 14.2 x 5.4cm


w/o GP, 20.0 x
5.4cm w GP

.430kg w/o GP, 0.615kg


w/GP

1586.5 25MHz; 1236


20 MHz; L-Band 1535
10 MHz

2.0:1

4.5/33

Symmetrical

1.5

3-18

55 (typ)

50C to +85C

IEC 60068-2-34, Test


Fd; IEC 60068-2-6,
Test Fc

Y/IP67

Y/Y

TNC

RG-58/Variable Length

5/8-11 UNC-2B Threaded

Contact distributor

<1mm, microcentered antenna

PG-F1

2015

GLR

14.2 x 14.2 x 6.7cm


w/o GP, 20.0 x
6.7cm w GP

.490kg w/o GP, 0.675kg


w/GP

Lower band 1230 MHz70


MHz; Upper band 1565
MHz50 MHz

2.0:1

5.5/35

Symetrical

1.5

3-15

60 (typ)

50C to +85C

MIL-STD-810G

Y/IP65

Y/Y

TNC

Variable

5/8-11 UNC-2B Threaded

Contact distributor

na

MG-A8

2012

MN

8.9cm D x Height w/o


adapter 10.2cm or w/
adapter 20.5cm

0.280kg w/o adapter

Upper band 1520 - 1590


MHz; Lower Band 1215 1260 MHz

2.0:1

5.5/35

Symmetrical

1.5

3-18

60(typ)

-40C to +70C

Y/IP67

Y/Y

TNC

Variable

5/8-11 Threaded

Contact distibutor

na

S16 G P S W O R L D

WWW.GPSWORLD.COM

FEBRUARY 2016

FEBRUARY 2016

WWW.GPSWORLD.COM

G P S W O R L D S17

ANTENNA SURVEY 2016

Manufacturer

Trimble
www.trimble.com

u-blox AG
www.u-blox.com

Wang Electro-Opto
Corporation
www.weo.com

sponsored by

Model

Intro. Date

User Environment 1

Size: Length x Width


x Height

Weight

Frequency/Bandwidth 2

VSWR 3

Axial Ratio
(dB)

Gain/Gain with
Amplifier (dB)

Pattern

Noise Figure
(dB) 4

Amplifier DC Voltage Amplifier Current


(mA)

Operating Temperature
(C)

Vibration

Environmentally
Sealed (Y/N)/Type

L/D 5

Connectors

Cable Type/Length

Mounting Configuration

List Price in U.S. Dollars

Integration

CR-G5

2011

GLR

30.8 x 15.5cm (w/o


dome)

4.9kg (w/o dome)

Lower band 1230 MHz70


MHz; Upper band 1565
MHz50 MHz

1.5:1

5/43 typical

Symmetrical

1.0

3-12

100

-50C to +85C

MIL-STD-810G

Y/IP67

Y/Y

RG-58/Variable Length

Threaded

Contact distributor

na

PN-A5

2011

GLR

41.5 x 29.2cm (dome


included)

7.8kg (dome included)

Lower band 1230 MHz70


MHz; Upper band 1565
MHz50 MHz

1.5:1

5/43 typical

Symmetrical

1.0

3-12

100

-50C to +85C

MIL-STD-810G

Y/IP67

Y/Y

RG-58/Variable Length

Threaded

Contact distributor

na

G5-A1

2015

GLR

29.8 x 7.5cm

1.3kg

Lower band 1230 MHz70


MHz; Upper band 1570
MHz40 MHz

2.0:1

10/35 typical

Symmetrical

1.0

3-16

65

-40C to +75C

MIL-STD-810G

Y/IP67

Y/Y

TNC

Variable

5/8-11 Threaded

Contact distributor

< 1mm

G3-A1

2005

GLR

14.2 x 14.2 x 5.8cm


w/o GP, 20.0 x
5.4cm w GP

.515kg w/o GP, .685kg


w/ GP

1586 25 MHz / 1236 20


MHz / 1176 12 MHz

<1.8:1

5/30

Symmetrical

1.0

3-18

30

50C to +70C

MIL-STD-810F

Y/IP65

Y/Y

TNC

RG-58/Variable Length

5/8-11 Threaded

Contact distributor

na

CR-G5-C

2015

GLR

30.8 x 15.5cm (w/o


dome)

6.4kg (w/o dome)

Lower 3dB Pass Band:


1160...1300 MHz; Upper 3dB
Pass Band: 15401610 MHz

1.5:1

5/43 typical

Symmetrical

1.0

3.3-12

100

-50C to +85C

MIL-STD-810G

Y/IP67

Y/Y

RG-58/Variable Length

Threaded

Contact distributor

< 1mm

Magnetic Mount 3 V Antenna,MCX,


SMA connectors

2001

LNPVY

37.4 x 34 x 12.9mm

25g (without cable)


cable length 5m

1575 MHz

2.0 max

4 dB @ 90

27 dBi 3 dBi
typ temp

Upper hemispherical

1.8 (+25C)
/2.3(+85C)

3 V DC

20 max

40 to +85

as above

Y/waterproof
JISD0203 S2

nr

SMB, SMA

1.5DS-QEHV/5 m

Magnetic mount

OEM pricing; inquire

nr

Magnetic Mount 5V Antenna. SMB,


SMA connectors

2001

LNPVY

37.4 x 34 x 12.9mm

25g (without cable)


cable length 5m

1575 MHz

2.0 max

4 dB @ 90

27 dBi 3 dBi
typ temp

Upper hemispherical

1.8 (+25C)
/2.3(+85C)

5 V DC

30 max

40 to +85

as above

Y/waterproof
JISD0203 S2

nr

MCX, SMA

1.5DS-QEHV/5 m

Magnetic mount

OEM pricing; inquire

nr

Unpackaged Embedded 3.V

2001

LNPVY

22 x 21 x 7.5mm

20g (cable length


85mm

1575 MHz

2.0 max

4d B @ 90

27 dBi 3 dBi
typ temp

Upper hemispherical

1.5 (+25C)
/2.0(+85C)

3 V DC

13 max

40 to +85

as above

nr

nr

H.FL

0.8 D/8 cm

Mounting holes

OEM pricing; inquire

nr

Bulkhead

2001

LNPVY

64.5 x 40mm

150g

1575 MHz

2.0 max

4d B @ 90

27 dBi 3 dBi
typ temp

Upper hemispherical

1.8 (+25C)
/2.3(+85C)

5 V or 3 V

35 max

40 to +86

as above

nr

nr

TNC

na

Threaded

OEM pricing; inquire

nr

GPS/GLONASS Magnetic Mount 3


V Antenna, MCX, SMA connectors

2011

LNPVY

49.14 x 46.14 x
15.94mm

25g (without cable)


cable length 5 m

1575 to 1615 MHz

2.0 max

4 dB @ 90

30 dBi typ

Upper hemispherical

2.0 typ

3 V DC

8 typ

40 to +85

as above

Y/waterproof
JISD0203 S2

nr

MCX, SMA

1.5DS-QEHV/5 m

Magnetic mount

OEM pricing; inquire

nr

GPS/Beidou Magnetic Mount 3V


Antenna, MCX, SMA connectors

2016

LNPVY

49.14 x 46.14 x
15.94mm

25g (without cable)


cable length 5 m

1558 to 1615 MHz

2.0 max

5 dB max @ Zenith

30 dBi typ

Upper hemispherical

2.7 max

3 V DC

10 typ

40 to +85

10Hz - 200Hz, log


sweep 3G

Y/waterproof
JISD0203 S2

nr

MCX, SMA

RG-174/5 m

Magnetic mount

OEM pricing; inquire

nr

GPS/Beidou Magnetic Mount 5V


Antenna, SMA connector

2016

LNPVY

49.14 x 46.14 x
15.94mm

25g (without cable)


cable length 5 m

1558 to 1615 MHz

2.0 max

5 dB max @ Zenith

30 dBi typ

Upper hemispherical

2.6 max

5 VDC

17 typ

40 to +85

10Hz - 200Hz, log


sweep 3G

Y/waterproof
JISD0203 S2

nr

SMA

RG-174/5 m

Magnetic mount

OEM pricing; inquire

nr

GPS/GLONASS Bulkhead

2011

LNPVY

64.5 x 40mm

150g

1575 to 1615 MHz

2.0 max

4d B @ 90

30 dBi typ

Upper hemispherical

2.0 typ

5 V or 3 V

6.5 typ @ 3V 13
typ @ 3V

40 to +85

as above

nr

nr

TNC

na

Threaded

OEM pricing; inquire

nr

Trimble A3

2005

DGLMNRV

16 x 6.2cm

0.39kg

1575 MHz

2.0 max

nr

42 dB

Upper hemispherical

nr

2.9511.5 V DC

nr

50 to +85

MIL-STD-810-F

as above

nr

TNC-type

Any with up to 10 dB loss

Tripod, tribrach

Contact Distributor

nr

Zephyr 2 Antenna

2006

DGLMNRV

34.3 x 7.6cm

0.60kg

L1/L2/L3/L5/G1/G2/B1/
B2/E1/E2/E5ab/E6/RTX/
OmniSTAR/SBAS

2.0 max

2 dB @ Zenith

50 dB 2.0

Upper hemispherical

2.0 dB

3.3-20 V DC

125

40 to +70

as above

as above

nr

TNC female

Any with up to 10 dB loss

Tripod, tribrach, pole

Contact Distributor

nr

Zephyr 2 Rugged

2008

DGLMNR

25.4 x 11.1cm

1.8kg

L1/L2/L3/L5/G1/G2/B1/
B2/E1/E2/E5ab/E6/RTX/
OmniSTAR/SBAS

2.0 max

2 dB @ Zenith

50 dB 2.0

Upper hemispherical

2.0 dB

3.3-20 V DC

125

40 to +70

Designed for extreme


shock and vibration
installations. Bouyant

+/- 5 psi sealing.


Rain and spray per
IEC 60945

nr

TNC female

Any with up to 10 dB loss

Rugged 4 point mount to pole,


or 5/8in thread to pole

Contact Distributor

nr

Zephyr Geodetic 2 Antenna

2006

DGLMnrV

34.3cm x 8.5cm

1.36kg

L1/L2/L5/G1/G2/G3/E1/E2/
E5ab/E6/Compass

2.0 max

2 dB @ Zenith

50 dB 2.0

Upper hemispherical

2.0 dB

3.3-20 V DC

125

55 to +85

MIL-STD-810-F

Rated to IP67

nr

TNC female

Any with up to 10 dB loss

Tripod, tribrach, pole

Contact Distributor

nr

Trimble GNSS Choke Ring

2008

DEGLR

38cm x 12.7cm

4.3kg

L1/L2/L5/G1/G2/G3/E1/E2/
E5ab/E6/Compass

2.0 max

2 dB @ Zenith

50 dB 2.0

Upper hemispherical

2.0 dB

3.3-20 V DC

125

55 to +85

4.3 GRMS

Rated to IP67

nr

N-Type female

Any with up to 10 dB loss

Tripod, tribrach, monument

Contact Distributor

nr

Trimble GNSS-Ti Choke Ring

2011

DEGLR

38cm x 14.6cm

4.3kg

L1/L2/L5/G1/G2/G3/E1/E2/
E5ab/E6/Compass

2.0 max

2 dB @ Zenith

50 dB 2.0

Upper hemispherical

2.0 dB

3.3-20 V DC

125

55 to +85

4.3 GRMS

Rated to IP67

nr

N-Type female

Any with up to 10 dB loss

Tripod, tribrach, monument

Contact Distributor

nr

Bullet III GPS Antenna

1990

LMNOPTV

77.5 mm x 66.2mm

0.2kg

GPS L1

2.0 max

4d B max @ 90

30 dB 3.0 (5 V)

Upper hemispherical

3.0 dB typ

3.3 V or 5.0 V dc
options

30 max (5 V)

-40 to +90

10Hz - 200Hz, log


sweep 3g, 3-axis

Y / up to IP67

nr

TNC (F option for 5 V antenna)

depends upon use case

1 - 14 UNF or 3/4 NPT

OEM or System
Integrator pricing contact:
technology@trimble.com

nr

Bullet GG (GPS & GLONASS)


Antenna

2014

LMNOPTV

77.5 mm x 66.2mm

0.2kg

GPS L1 / GLONASS L1

2.0 max

4d B max @ 90

32 dB 3.0 (5 V)

Upper hemispherical

3.3 dB max

3.3 V or 5.0 V dc
options

30 max (5 V)

-40 to +90

10Hz - 200Hz, log


sweep 3g, 3-axis

Y / up to IP67

nr

TNC (F option for 5 V antenna)

depends upon use case

1 - 14 UNF or 3/4 NPT

OEM or System
Integrator pricing contact:
technology@trimble.com

nr

Bullet L1 L2 Antenna

2015

LMNOPTV

77.5 mm x 66.2mm

0.2kg

GPS L1 / GPS L2

2.0 max

<3 dB

36 dB 3.0 (5 V)

Upper hemispherical

3.3 dB max

3.3 V or 5.0 V dc
options

35 max (5 V)

-40 to +90

10Hz - 200Hz, log


sweep 3g, 3-axis

Y / up to IP67

nr

TNC (F option for 5 V antenna)

Up to 75 ft RG-58 or RG-59

1 - 14 UNF or 3/4 NPT

OEM or System
Integrator pricing contact:
technology@trimble.com

nr

Bullet 360 Antenna

2015

LMNOPTV

77.5 mm x 66.2mm

0.2kg

GPS L1 / BeiDou B1 /
GLONASS G1 / Galileo E1

2.0 max

<5 dB GPS

28 dB 3.0

Upper hemispherical

2.0 dB typ

3.3 V or 5.0 V dc
options

20 max (5 V)

-40 to +90

10Hz - 200Hz, log


sweep 3g, 3-axis

Y / up to IP67

nr

TNC (F option for 5 V antenna)

depends upon use case

1 - 14 UNF or 3/4 NPT

OEM or System
Integrator pricing contact:
technology@trimble.com

nr

Bullet 40dB Antenna

2015

LMNOPTV

77.5 mm x 66.2mm

0.2kg

GPS L1

2.0 max

<3 dB

40 dB 3.0 (5 V)

Upper hemispherical

2.0 dB typ

3.3 V or 5.0 V dc
options

35 max (5 V)

-40 to +90

10Hz - 200Hz, log


sweep 3g, 3-axis

Y / up to IP67

nr

TNC (F option for 5 V antenna)

depends upon use case

1 - 14 UNF or 3/4 NPT

OEM or System
Integrator pricing contact:
technology@trimble.com

nr

Bullet GB Antenna

2015

LMNOPTV

77.5 mm x 66.2mm

0.2kg

GPS L1 / Beidou B1

2.0 max

< 5 dB GPS

28 dB 3.0 (5.0 V)

Upper hemispherical

2.0 dB typ

3.3 V or 5.0 V dc
options

20 max (5 V)

-40 to +90

10Hz - 200Hz, log


sweep 3g, 3-axis

Y / up to IP67

nr

TNC (F option for 5 V antenna)

depends upon use case

1 - 14 UNF or 3/4 NPT

OEM or System
Integrator pricing contact:
technology@trimble.com

nr

PAM-7Q GPS antenna module

2014

DMNTV

22.0 x 22.0 x 8.0mm

9g

GPS / QZSS L1 C/A


SBAS: WAAS, EGNOS,
MSAS

na, Integrated
Receiver

na, Integrated
Receiver

na, Integrated
Receiver

Hemispherical, RHCP

na, Integrated
Receiver

2.7V...3.6V

-40C...+85C

8-pin contact header

na

Pin contact

contact u-blox

GPS receiver modules with


integrated patch antenna

CAM-M8Q GNSS antenna module

2014

DMNTV

9.6 x 14.0 x 1.95mm

0.5g

GPS/QZSS L1 C/A,
GLONASS L10F; BeiDou B1
SBAS L1 C/A: WAAS,
EGNOS, MSAS

na, Integrated
Receiver

na, Integrated
Receiver

na, Integrated
Receiver

Hemispherical,
Linear pol.

na, Integrated
Receiver

2.7V...3.6V

-40C...+85C

31 contact LCC

na

SMD

contact u-blox

Extremely sensitive module


with integrated chip antenna.
Concurrent reception of GPS
with GLONASS or BeiDou.

CAM-M8C GNSS antenna module

2015

DMNTV

9.6 x 14.0 x 1.95mm

0.5g

GPS/QZSS L1 C/A,
GLONASS L10F; BeiDou
B1; SBAS L1 C/A: WAAS,
EGNOS, MSAS

na, Integrated
Receiver

na, Integrated
Receiver

na, Integrated
Receiver

Hemispherical,
Linear pol.

na, Integrated
Receiver

1.65V...3.6V

-40C...+85C

31 contact LCC

na

SMD

contact u-blox

Extremely sensitive module


with integrated chip antenna.
Concurrent reception of GPS
with GLONASS or BeiDou.

ANN-MS

2003

LMNVT

48 x 40 x 13mm

42ggg (without gcable);


<105gg (with gcable)

GPS L1,10 MHz

2.0 max

3 dB typ

4 dB/27 dB

nr

1.8 dB typ

2.7 - 6.0V

Typ. 8.5 mA,


+/- 4.5 mA

-40 to +80

Sine sweep 1 G (o-p)


10-150-10 Hz ea axis

Y/rubber sealed

N/N

Choice: SMA, SMB, MCX, FAKRA

RG-174, 5 m

Magnetic

contact u-blox

nr

GNSS-D060-L-P0900

2011

LNVT

60 x 15mm

180g

1150 - 1620 MHz

<2.0:1

<4dB

4dBi typ

RHCP

2 dB typ

3-5 VDC

na

- 30 to +60

MIL-STD-810F

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery

Cover all GNSS bands; thin and


conformal

GNSS-D060-L-P0900-LNA

2011

LNVT

60 x 15mm

182g

1150 - 1620 MHz

<2.0:1

<4dB

4dBi / 20dBi typ

RHCP

2/2.5 dB typ

3-5 VDC

4 mA

- 30 to +60

MIL-STD-810F

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery

Cover all GNSS bands; thin and


conformal

GNSS-D060-L-P0500

2011

LNVT

60 x 15mm

180g

1150 - 1620 MHz

<2.0:1

<4dB

4dBi typ

RHCP

2 dB typ

3-5 VDC

na

- 30 to +60

MIL-STD-810F

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery

Cover all GNSS bands; thin and


conformal

GNSS-D060-L-P0100

2011

LNVT

60 x 15mm

180g

1150 - 1620 MHz

<2.0:1

<4dB

4dBi typ

RHCP

2 dB typ

3-5 VDC

na

- 30 to +60

MIL-STD-810F

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery

Cover all GNSS bands; thin and


conformal

GNSS-D060-L-P0100-LNA

2011

LNVT

60 x 15mm

182g

1150 - 1620 MHz

<2.0:1

<4dB

4dBi / 20dBi typ

RHCP

2/2.5 dB typ

3-5 VDC

4 mA

- 30 to +60

MIL-STD-810F

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery

Cover all GNSS bands; thin and


conformal

GNSS-D115-L-P0100

2011

DGLNVT

115 x 30mm

250g

1100 - 2000 MHz

<2.0:1

<3 dB

5dBi typ

RHCP

1.7 dB typ

na

na

- 45 to +70

MIL-STD-810F,
DO-160E

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery

Cover all GNSS bands and


some cell bands; thin and
conformal

GNSS-D115-L-P0010

2011

DLNVT

115 x 30mm

250g

1100 - 2000 MHz

<2.0:1

<3 dB

5dBi typ

RHCP

1.7 dB typ

na

na

- 45 to +70

MIL-STD-810F,
DO-160E

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery
schdule

Cover all GNSS bands and


some cell bands; thin and
conformal

GNSS-D115-L-P0010-LNA

2011

DLNVT

115 x 30mm

252g

1100 - 2000 MHz

<2.0:1

<3 dB

5dBi / 21-43dBi typ

RHCP

1.7/2 dB typ

3-5 VDC

4-20 mA

- 45 to +70

MIL-STD-810F,
DO-160E

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery
schdule

Cover all GNSS bands and


some cell bands; thin and
conformal

GNSS-D200-L-P0010

2011

DGLNVT

200 x 30mm

360g

1100 - 2000 MHz

<2.0:1

<3 dB

5dBi typ

RHCP

1.5 dB typ

na

na

- 45 to +70

MIL-STD-810F,
DO-160E

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery
schdule

Cover all GNSS bands and


some cell bands; thin and
conformal

GNSS-D200-L-P0010-LSQ

2012

DGLNVT

200 x 30mm

362g

1100 - 2000 MHz

<2.0:1

<3 dB

5dBi typ

RHCP

1.5 dB typ

na

na

- 45 to +70

MIL-STD-810F,
DO-160E

Y/Rubber Sealed

N/N

SMA/other available

na

Side or bottom feed

Low cost; inquiry with


quantity and delivery
schdule

Cover all GNSS bands and


some cell bands; LightSquared
compatible

S18 G P S W O R L D

WWW.GPSWORLD.COM

FEBRUARY 2016

FEBRUARY 2016

WWW.GPSWORLD.COM

G P S W O R L D S19

You might also like