Professional Documents
Culture Documents
router for the initial configuration? (Choose three.) CCNA3 v4.0 download
straight-through cable. CCNA4 v4.0 download(updated
terminal emulation software. 21/7/2008)
rollover cable. CCNA 3:Module 7
RJ-45 to DB-9 connector. CCNA 3:Module 6
V.35 cable. CCNA 3:Module 5
6.Terminal emulation software, such as HyperTerminal, CCNA 3:Module 4
can be used to configure a router. Which of the
CCNA 3:Module 3
following HyperTerminal options shown in the graphic
CCNA 3:Module 2
are correctly set to allow configuration of a Cisco
CCNA 3:Module 1
router? (Choose three.)
CCNA 2:Final Set 3
bits per second.
data bits. CCNA 2:Final Set 2
parity. CCNA 2:Module 11
stop bits. CCNA 2:Module 10
flow control. CCNA 2:Module 9
7. Which of the following devices are used in the CCNA 2:Module 8
construction of a WAN? (Choose three.) CCNA 2:Module 7
hubs.
CCNA 2:Module 6
routers.
CCNA 2:Module 5
communication servers.
CCNA 2:Module 4
transceivers.
CCNA 2:Module 3
modems.
multi-port repeaters. CCNA 2:Module 2
8. Which of the following are functions of RAM? CCNA 2:Module 1
(Choose three.) CCNA 1:Final
contains startup configuration file. CCNA 1:Module 11
stores routing table. CCNA 1:Module 10
holds fast switching cache. CCNA 1:Module 9
retains contents when power is removed.
CCNA 1:Module 8
stores running configuration file.
CCNA 1:Module 7
9. Why is a console connection to a router or switch
CCNA 1:Module 6
preferred when troubleshooting? (Choose two.)
CCNA 1:Module 5
can be accessed remotely.
does not depend on network services. CCNA 1:Module 4
displays startup and error messages by default. CCNA 1:Module 3
does not require special components. CCNA 1:Module 2
10. Which basic components do a router and a standard CCNA 1:Module 1
desktop PC have in common? (Choose three.)
► July (13)
CPU.
hard drive. ► June (13)
input/output interfaces.
► May (27)
keyboard.
monitor.
system bus.
LABELS
11. During the initial configuration of a 2600 series
CCNA 1 UPDATED (12)
Cisco router, which cable is required for connecting a
PC to the console port? CCNA 2 UPDATED (12)
connect the router to the network for packet entry and exit.
can be on the motherboard or a separate module.
hold the IOS image.
connect the router to LANs and WANs.
0 COMMENTS:
Post a Comment