Professional Documents
Culture Documents
The normal operating cycle of ScanMarker system is described by the following step and
procedures:
Scanning Cycle:
1. Place the clear tip of the ScanMarker approximately in the middle of the the two sharp
ends of the clear tip. Get a little bit distance before the beginning of the line you wish to
2. Press slightly the transparent tip of the device as light click can be hear and light will
activate. Slide smoothly and lithely along the line you desire to scan. It can be seen from
avoid errors. For better results, slide the ScanMarker slightly faster. It can be seen from
4. Avoid Pressing the ScanMarker too hard on page during scanning. Just simply click and
slide.
5. End your scanning movement after a line by releasing the pressed pressure while sliding.