STANDARD SPECIFICATION NO. 6-79-0020 Glg a tiOtegmv INDIA UNITED Rev. 0 1011PFT 21R077 ttUatf 0 IA Govl of Yea Undetlicingi AND PROTECTIVE COATING PAGE 34 OF 59
SSPC SP-10; between
I coat of 1 coat of 60 - 120 C 15.3.4 401 to 600 Amercoat 738@ None Amercoat 738@ 250 125 it DFT/coat 125 g DFT/coat 15.4 Coating system for Cyclic Service of Carbon Steel, LTCS, Low Alloy Steel & Stainless Steel SSPC-SP-10 Apcothem EPN (15-25g surface 1 coat of F-15 1 coat of F-15 200 of M/s Asian 15.4.1 - 40 to 150 profile) intermediate coat finish coat @ 240 Paints Ltd 1 coat of F-15 @ @ 80g DFT/coat 80m DFT/coat; OR 80 p DFT/coat Equivalent For CS Products from SSPC SP-6 JOTUN or HI- Commercial Blast 1 coat of inert 2 coats of inert -180 to 650 TEMP coatings or 15.4.2 For SS polymeric matrix polymeric matrix 350-400 SK SSPC SP-1 with coating @ 125 g coating @ 125 g FORMULATIONS non-chloride are recommended. solvent 15.5 No painting is required for insulated Monel, Incoloy and Nickel lines.
NOTES
"Cyclic Service" is characterized by rapid temperature fluctuation.
The blast cleaning abrasives for SS and Alloy steel surfaces shall be Aluminium oxide grits/shots or garnet. 3. In case of overlapping of temperature ranges as mentioned in 15.4.1 and 15.4.2, clause 15.4.1 shall be followed.
TABLE 16.0 COATING SYSTEM FOR CARBON STEEL COMPONENTS OF COOLERS /
CONDENSERS (INTERNAL PROTECTION) FOR FRESH WATER SERVICE Fresh Water boxes, channels, partition plates, end covers and tube sheets etc.
Coating System Total
Surface Preparation Final DFT SI. Design (Post-erection / Field) & Pre-erection/Shop Remarks No. Temp. in .C in Microns Primer Primer Finish paint (min.) 1 coat of F-15 2 coats of F-15 @ 16.1 Up to 80 C SSPC-SP-10 240 @ 80 microns 80p DFT/coat; 1 coat of Glass Fibre Reinforced 16.2 80 to 140 SSPC-SP-10 1500 - Novolac epoxy of 1.5 mm DFT
Format No. 8-00-0001-Fl Rev. 0 Copyright EIL - All rights reserved