Professional Documents
Culture Documents
Items Required:
1. Baofeng UV-5r
2. IPhone (Does not need a cell service)
3. A custom made cable (A crossover cable with 3.5mm plugs)
4. IPhone App PocketPacket
Create Cable
1. Purchase a cable from store that would plug in your phone to your car stereo. (Something
like this http://www.radioshack.com/product/index.jsp?productId=19732556)
2. Purchase a packet of 3.5mm stereo plugs
(http://www.radioshack.com/product/index.jsp?productId=2104061&znt_campaign=Categ
ory_CMS&znt_source=CAT&znt_medium=RSCOM&znt_content=CT2032231)
3. Cutoff both ends of the cable you purchased and strip the black insulation away about 2-3
revealing a red wire, black wire, and bare wires (this is the ground)
4. Strip off about -1/2 of the red and black wire.
5. Twist each wire to tighten the wire.
6. Preheat solder gun
7. Tin some solder onto the end of the wires. (Basically melt some solder onto the tip of each
wire. This helps when you go to solder it to the connection on the plug)
8. Solder the bare wire to the long piece on both connectors. (This is the ground)
9. On one connector, solder the red and black wires to one connector each. (It doesnt matter
which one gets soldered where. We are creating a crossover cable, so it wont matter)
10. On the opposite connector you are going solder the red and black wires to the opposite
connectors. (This cross over the wires and allows you to not worry about which side is
plugged into where)
11. Button up your plugs and your wire is ready to go.
Setup IPhone
APRS.fi
If you have any questions, let me know and I will try to answer them the best I can.
1. Basically you are using the IPhone for its GPS chip, the app is transmitting this data, through
MIC port just as if you were using a VOX Microphone.
2. Do not touch the AUDIO MODEM section, this is if you were going to try and use the speakers
on the IPhone instead of the cable.