Professional Documents
Culture Documents
Consumers also want the character of the vehicle is adapted to the driver. This is why driving profiles marketed with the Golf 2013 have been constantly
developed and improved. This results in the multiplexing increasingly complex different vehicle systems.
The future of infotainment remains exciting. This brochure shows, as examples, the recent developments made in 2013 and the Golf GTI / GTD
2013.
s519_075
This Self-Study Programme presents the For current instructions control, adjustment and repair, please
design and operation of innovations refer to the documentation of Customer Service.
Warning
Recent techniques! Note
Its content is not updated.
2
At a glance
Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
What's up ?. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
multiplexing concept. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
MOST150 the data bus. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 The system of
antennas. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Service. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Diagnosis and interventions MOST150 data bus. . . . . . . . . . . . 26 Updating navigation data. .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Glossary. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28
3
Introduction
What's up ?
The MOST150 data bus
s519_059
MOST is the standardization of interfaces, that is to say the transmitting and receiving units (Fiber Optical Transmitter - FOT). These interfaces enable
the integration of multimedia devices the most diverse in the ring network structure. Compared to the previous model MOST25, the new MOST150 data
bus is distinguished by bandwidth transmission of data significantly higher. With 3072 bits per transmission unit (frame) bandwidth has increased
six-fold compared to MOST25. Further information on the data bus MOST150 see from page 6.
s519_060
Further information on the data bus MOST150 see from page 15.
4
mobile interfaces "Comfort" and
"Premium"
s519_061 vehicle antenna system without any physical connection. The mobile
interface "Premium" allows rSAP connection. For more information
about this, see from page 12.
s519_062
For the Golf GTI / GTD 2013, the selection of the driving profile has
been adapted to the specific character of the vehicles. The different
driving profiles allow eg to adapt to the driving situation the volume of
the noise actuator borne R214 connected in series. For the comparison
of driving profiles, see from page 18.
s519_058
5
Concept of multiplexing
Data bus
MOST150
electronic calculator
Information 1 J794 (optional) R78
processor computer
DSP sound field J525 TV tuner
s519_041
MOST stands for "Media Oriented Systems Transport". It is a serial bus At the launch of this model, the MOST data bus mounted on the Golf
system which transmits audio and video signals and voice signals and 2013 has the following characteristics:
data, preferably using a fiber optic cable.
- data transmission rate 150 Mbit / s
(3072 bits per transmission unit)
The MOST network has a ring structure that can include up to 64 - ring topology with up to three correspondents
MOST devices.
- Cyclic data transmission, event-controlled
The electronic control unit 1 J794 Information is responsible for system management and diagnosis of MOST150 data bus.
For more information on diagnosis, eg. diagnosis cut the ring network, see Self-Study Programme 473 "Infotainment Touareg 2011".
6
The multiplexing and infotainment data bus MOST150
The diagram below provides an overview of new multiplexing calculators infotainment of the Golf GTI / GTD 2013. All CAN data bus systems of the Golf
GTI / GTD 2013 have a rate of 500 kbit / s.
Legend
J412 electronic calculator control
J525 mobile phone surround processor
U31
calculator
DSP sound
For more information on the diagnostic cutoff the ring network and the new repair kit for fiber optic cables, see chapter "Service" from
page 26.
7
Concept of multiplexing
Data to be transmitted are divided into packets called frames. On the bus MOST150 data, each frame has a length of 3072 bits (on the MOST25 = 512
bits). The purely digital useful data length of 3040 bits (on the MOST25 = 480 bits). This means that the MOST150 transmit much more information per
data packet.
Data is transmitted via three channels (control channel, channel synchronous and asynchronous channel):
- control data for control channel
- synchronous channel for transmitting audio and video data (synchronous transmission in real time, without intermediate storage)
- asynchronous channel for quite large data volume, eg. audio file metadata
(Asynchronous transmission, event, with the possibility of intermediate storage)
Field data
to control data
(Control channel)
data field for administration
s519_042
8
The composition of the fiber optic cables
- The heart is the core part of the fiber optic cable. It is composed of Plexiglas specially conditioned. The heart transmits light received
virtually no losses.
eg outer sheath.
orange
front side
Heart
cladding
s519_043
For flawless data transmission, the front face of the fiber optic cable should have a cut at right angles, smooth and clean. Dirt or
scratches on the face can cause disruptions and losses in the data transmission and reduce the cable transmission capacity of
optical fiber.
9
Concept of multiplexing
10
The antenna system interface
mobile "Premium"
By inserting a SIM card into the reader, the functionality can thus
benefit from a landline to a mobile phone. When the SIM card is not
inserted, the mobile phone can also be connected to the electronic
computer information 1 J794 via three profiles rSAP Bluetooth, HFP or
A2DP. The integrated phone module in the electronic computer
information 1 J794 is designed for GSM and UMTS networks.
This allows the use with Wi-Fi enabled devices, the Internet connection
is established by inserting the SIM card or a mobile phone coupled
rSAP.
s519_048
Legend
J364 auxiliary heating calculator J685 Faceplate for block
calculator
display and control information for at the front
roof antenna 1
impedance converter FM / DAB 2
impedance converter FM / AM 3
FM / AM antenna in the rear window
4, 5 Filter FM 6 stop
Stop filter AM
Sensor cable
11
phone prep packages
F e a t u r e / F u n c t i o n B a s e d C o m f o Pr rt e m i u m
O p e r a t i o n a n d d i s p l a y v i a t h e m u l t i f u n c t i Xo n d i s Xp l a y PX l u s o r P
o r t h e i n t e g r a t e d r a d i o a n d n a v i g a t i o n s y s t e m o r v i a t h e o p t
H a n d s f r e e s p e a k e r X X X
E a s y P a i r i n g m o b i l e p h o n e t h r o u g h s i m p l e X a n d s a
X f e c oX u p l i n g ,
P a i r i n g ( S S P )
E a s y a c c e s s v i a t h e p h o n e b o o k d i r e c t o r y XA c c e s sX P r o f Xi l e , P h o
p h o n e c o n t a c t1 ) d i s p l a y w i t h p i c t u r e X X X
P o s s i b i l i t y t o u s e t h e a d dr e s s o f a t e l e p Xh o n e c o
X n t a c tX t o t h e
n a v i g a t i o2 n) d e s t i n a t i o n
W i r e l e s s c o m m u n i c a t i o n i n t e r f a c e B l u e t o o tX h A u d i Xo ( c o Xm p a t i b l e
D i s t r i b u t i o n P r o f i l e A d 1v ) a n c e d A u d i o D i s t r i b u t i o n P r o f i l e A 2 D P
a u d i o s e l e c t i o n s t o r e d o n t h e m o b i l e p h o nX e u s i nX g t h eX t o u c h s
V o i c e c o m m a n d X X
C o n n e c t i n g t o e x t e r n a l a n t e n n a v i a t h e c h a r g i n gX s t a n d l o c a t e
b o x )
T r a n s m i t t i n g u n i t a n d r e c e i v i n g G S M / U M T S o w n v e h i Xc l e w i t h
A d d i t i o n a l I n t e r f a c e B l u 3e )t o o t h r e m o t e S I M A c c e s s P r oX f i l e ( r S
A c c e s s P o i n t W i - F i X
S M S f u n c t4 i ) o
w, nr is t : i nr ge a ( d v i i n a g v o i c e c o m m a n d ) , r e a d i n g a l o u dX
S u i t a b l e f o r m o b i l e p h o n e s w
i t h B l u e t o o t hX H a n d sX F r e eX P r o f i l e
( H F P 1 . 5 ) a n d G S M 9 0 0 / 1 8 0 0 M H z
1 N
) o t i n c o m b i n a t i o n w i t h " C o m p o s i t i o n T o u c h " o r " C o m p o s i t i o n
2 O
) n l y i n c o m b i n a t i o n w i t h " D i s c o v e r M e d i a " o r " D i s c o v e r P r o "
3 )
I t i s i m p e r a t i v e t o c h e c k w h e t h e r t h e c o n c e r n e d m o b i l e p h o n
S I M A c c e s s P r o f i l e ( r S A P ) a n d i s s u i t a b l e f o r m o b i l e i n t e r f
M o r e d e t a i l e d i n
w fwo wr .m v a o t l i ko sn w ia s g ea nv -a zi ul ab be l h e o ea rt .: d e
4 V) i a t h e t o u c h s c r e e n T F T c a r r a d i o o r t h e i n t e g r a t e d r a d i o a
1 2
The mobile "Comfort" telephony interface
Architecture
On the architectural plan of the system, the mobile interface "Comfort" is distinguished by two special features:
1. The storage interface with mobile phone for R265 (connection box) in the center console with antenna amplifier 3 R112
The audio for hands-free data is transmitted directly to the electronic control unit 1 J794 information via Bluetooth, the Hands Free Profile (HFP), as
well as data for streaming audio, by e A2DP protocol.
Legend
J285 calculator in the instrument cluster J533 R265 storage with interface for mobile phone RX5
Diagnostic interface data bus J685 Faceplate for roof antenna
block calculator multifunction steering wheel (optional) b
display and control information for at the front Speaker of the vehicle c
Microphone vehicle
J794 electronic calculator information J984 1 Amplifier 2-way
Bluetooth mobile phone e
mobile phone R50
Eg. handheld
GPS antenna (Or handheld) f
Aerial amplifier R112 3 R182 backup heater Eg. MP3 player cable CAN data bus
Antenna R193 R205 USB port Support GSM
LIN databus cable actuator
Antenna
13
phone prep packages
The storage interface with mobile phone for R265 (connection box)
contains the antenna amplifier 3 R112 and R193 support for USB port.
System
architecture from
The antenna amplifier 3 R112 has an adapter plate for the wireless
the week
connection of the mobile phone to the vehicle antenna system using an
induction principle. The connection is made via two stretches coupling 46/2013
s519_049
antennas over the entire surface, on the upper and lower faces of the
antenna amplifier. In this way, the reception is possible in the whole Legend
space of the connection box. A strap provided on the adapter plate J794 electronic calculator Information 1 J984 Signal Amplifier 2-way
Via the connection box, the GSM or UMTS mobile phone antenna is Amplifier 2-channel signal
connected in addition to an RF amplifier which further optimizes the to mobile phone J984
14
The mobile interface "Premium"
If the vehicle is equipped with the infotainment system "Discover Pro", it also has the optional mobile interface "Premium".
Architecture
With the telephone module and SIM card slot, after inserting a SIM card, you can benefit from the features of a fixed phone. An inserted SIM card has
priority over the Bluetooth wireless connection.
When the SIM card is not inserted in the SIM card slot, a mobile phone can also be connected to the electronic computer information 1 J794 via three
profiles rSAP Bluetooth, HFP or A2DP.
The integrated phone module in the electronic computer information 1 J794 is designed for GSM and UMTS networks.
s519_046
s519_045
Legend
J285 calculator in the instrument cluster J533 at multifunction steering wheel (optional) b
Diagnostic interface data bus J685 Faceplate for Speaker of the vehicle c
block calculator Microphone vehicle
display and control information for at the front Other Bluetooth devices e
Mobile Phone Bluetooth CAN bus
J794 electronic calculator Information 1 R50
Cable Actuator Cable Bus LIN data
GPS antenna
15
phone prep packages
Wi-Fi is a set of wireless communication protocols that describe the characteristics of a wireless local area network ( "Wireless Local Area Network or
WLAN") constituting an access point (or hotspot) for the exchange of data. So far, the media devices and phones can be connected wirelessly as
through the Bluetooth interface of the infotainment system. Through the onboard Wi-Fi access point, it is now possible to connect eg. tablets or laptops
on the Internet via the mobile interface "Premium". The system then uses Integrated UMTS interface into the phone module.
Data transmission is via the GSM antenna R205 or by a compatible mobile phone connected via Bluetooth rSAP or by a SIM card for connecting to the
Internet, inserted into the SIM card slot of the electronic calculator of 1 information J794.
For data transmission, the system uses the UMTS 3G standard. It is then of the UMTS standard for the third generation with which the data
transmission rate can reach up to 42 Mbit / s. On this access point can be used simultaneously 8 devices at maximum. Use the access point by
unauthorized persons is limited by the low range of this access point outside the vehicle as well as the SSID (Service Set Identifier). This code is the
name and port of the board Wi-Fi and it also allows access to the network after entering a password. The access point is built into the phone module
and serves as an interface for wireless communication devices, the Wi-Fi network.
Up to 42 Mbit / s
s519_057
16
WiFi IEEE 802.11b and 802.11g
802.11 standard.
SSID to seven characters s519_065 When a device requests access to a WiFi network, all access points
that are within range emit their SSID. This gives a list from which you
can choose the wireless network on which you want to connect.
s519_066
17
driving profiles
Since the adoption of the modular transverse engine platform (MQB) on the Golf GTI / GTD 2013, new features and new systems were integrated into
the selection of the driving profile. This is for example the internal and external sound control and the regulation of front differential lock, which are
explained in this chapter.
engine management X X X
transmission management X X X
climate control X X X
directional lights X X X
regulation -- X X
front differential lock (VAQ)
18
Driving profiles of the Golf GTI / GTD 2013
For driving profiles of the Golf GTI / GTD 2013, in addition to configuring profiles specific to the vehicle, there are primarily three characteristics:
s519_051 -
s519_055
19
audio system
An innovation achieved with the DYNAUDIO sound system is that the subwoofer is installed in the spare wheel well. A two-way system comprising
respectively a treble speaker and a speaker of mediums at the front and rear of the vehicle produced a dynamic and well-balanced sound reproduction.
The subwoofer complements perfectly tuned sound reproduction with powerful bass and deep.
s519_063
Loud speaker Loud speaker
the amount left in the front left speaker in the left rear door
Legend
Speaker Cable CAN data bus fiber
20
Overview of the system
The DYNAUDIO Premium Sound system consists of a MOST amplifier 400 watt, 10-channel, 8 speakers and a subwoofer 10.5 liters, double coil,
arranged in the wheel well rescue. The audio "DYNAUDIO Excite" system is also optionally available for the infotainment systems "Composition Media",
"Discover Media" and "Discover Pro" on all Golf 2013.
J794 J685
J525
R20 R22
R21 R23
R14 R16
R15 R17
R211 s519_056
Legend
R14 Loudspeaker R15 Rear left treble
Speaker serious rear left R16
Speaker treble rear right R17
Speaker serious right rear R20
Speaker treble front left R21
serious loudspeaker R22 Front left
Speaker treble front right R23
serious speaker front right R211
Subwoofer
J525 processor calculator soundscape DSP
J685 Faceplate for faceplate computer and control for information, front J794 electronic calculator Information 1
speakers
21
audio system
Electrical components
The specific amplifier audio DYNAUDIO pack is mounted under the left
front seat and is integrated into the system of the MOST data bus.
s519_069
s519_068
s519_067
22
tone characteristics
An impressive feature of the DYNAUDIO sound system is its range of tone settings ( "soundsettings"). The user can vary the sound environment at
will. With digital signal processing capabilities, this innovation of DYNAUDIO facility has also been integrated into the audio system developed for the
Golf 2013. The driver of a Golf has five specific tone controls that define different sound characteristics:
- Authentic
- Soft
- Dynamic
- Speech
- Individual
Authentic
This setting ensures the faithful reproduction of music with the original
tone, without any modification.
s519_029
Soft
s519_030
Dynamic
s519_031
23
audio system
Speech
s519_032
Individual
s519_033
Through the tone control menu "Settings Tone", the user accesses the
possibilities of setting sound characteristics, spatial sound reproduction
as well as adjusting the subwoofer.
s519_034
24
spatial sound reproduction
The calculator DSP surround sound processor J525 sets the spatial sound reproduction. This is significantly more sophisticated than the simple
adjustments to the balance and fader. It does not only modulate the various sound output levels of each speaker. By performing a delay corresponding
channels and adapting in more frequencies, the system adjusts the dynamic sound so that the sound reproduction is centered on the seat position or
that its center may be individually determined using the characteristic tone "Individual".
The basic adaptation takes place depending on the specific form of the passenger and the vehicle dimensions.
s519_035 s519_036
s519_037 s519_038
individual setting
s519_039
25
Service
The procedure for the ring network failure diagnosis corresponds to a large extent, control plan Touareg 2011. For the Golf 2013, a modified tool,
optical spare computer VAS 6778 is however necessary because transmitting and receiving units faster.
s519_070
Repair Kit for optical fibers VAS 6223B enables the repair of cables
with integrated optical fibers infotainment system.
Since in the case of repair cables new optical fibers must be laid next
to the vehicle wiring harness, this results in a difference in length
compared to the original wiring harness. To ensure perfect operation,
s519_072
26
Update navigation data
Path to follow
The update navigation data requires an SD card with a capacity of at least 32GB for the "Discover Pro" and an SD-ADC card with a capacity of
at least 8GB for "Discover Media" .
Volkswagen recommends using SDHC Class 10 for "Discover Pro" and a special SD-CDA 8GB card for the "Discover Media". This card can be
supplied by the Volkswagen partner.
The volume of navigation data can reach more than 17 GB for the "Discover Pro" and more than 4 GB for the "Discover Media". Depending on the
country or the importer, different Internet addresses are available for downloading navigation data: areas www.volkswagen.de for the German market
and
www.navigation.com for other markets worldwide.
These pages contain, in the language concerned, detailed information for data download and installation.
For the installation of the navigation data, follow the instructions in the attached to the vehicle operating instructions. During the copying process the
data, the ignition must be; the navigation function is unavailable. Due to the large volume of data and depending on the SD card used, the process can
last up to 4 hours. This is why it is necessary to first check if the battery voltage is sufficient to ensure complete update. If necessary, connect a suitable
charger to the vehicle.
27
Glossary
AVRCP FOT
A2DP
GPS
(Advanced Audio Distribution Profile)
[Advanced Audio Distribution Profile] (Global Positioning System)
multi technology to send stereo audio signals to a receiver device via a [Global Positioning System]
Bluetooth wireless connection. This officially named NAVSTAR GPS is a global navigation system
using satellites for determining the coordinates and time measurement.
Bandwidth
Firewall HFP
A firewall is a security system designed to prevent unauthorized (Hands Free Profile) [handsfree profile]
access from the outside, at a computer software. A firewall can be a standard Bluetooth profile enabling communication between the
component of a personal computer system or being itself a particular mobile phone and the hands-free vehicle.
computer whose only function is to monitor access to non-public
network.
28
Hot spot Subwoofer
The term hot spot is often used to refer to a public Internet access [Subwoofer]
point. Via a hot spot, you can connect wirelessly to the internet. The subwoofers are special speakers used for the return of low
frequency sounds, that is to say, deep bass. A distinction is made
between active severe cases or liabilities. Serious assets of the boxes
MOST
have their own output stage (amplifier). By cons, passive subwoofers
(Media Oriented Systems Transport) do not have their own output stage and are connected to an amplifier
[Transportation Media Oriented Systems] output as an ordinary speaker.
It is a serial bus system which transmits audio and video signals and
voice signals and data. At Volkswagen, this bus system is currently
achieved using fiber optic cables.
UMTS (3G)
rSAP
(Universal Mobile Telecommunications System) [Universal Mobile
(Remote SIM Access Profile) Telecommunications System]
[Remote SIM Access Profile] Third generation mobile telecommunications standard that allows
Profile for reading the SIM card and resume access data via the significantly higher transmission rates.
universal mobile phone preparation (UHV).
USB
SD card
(Universal Serial Bus) [Universal Serial Bus]
(Secure Digital Card) standardized interface between various electronic devices such
[Secure Digital memory card] as computers, printers, scanners, televisions, etc.
Robust memory card and small used eg. in digital cameras.
WPA, WPA2
SIM card
(Wi-Fi Protected Access) [Wi-Fi Protected Access]
(Subscriber Identity Module) Encryption method for connection and transmission of data over
[Subscriber identity module] wireless networks.
A SIM card is a chip integrated processor inserted eg. in a mobile WPA2 developed from the WPA is considered a very secure
phone. It is used, among others, to authenticate the user of a mobile encryption method.
phone when it connects to a telecommunications network.
SSID
29
Check your knowledge
a) ... you must use an SD card of Class 10 with a capacity of at least 32GB.
b) ... you must use a SD card "VW brand" category 10 with a capacity of at least 32GB.
c) ... you can use a conventional SD card with a capacity of at least 16GB.
3. What are the special components necessary to perform the function of the telephony interface
Mobile comfort?
a) The electronic computer information J794 1 of "Composition Media", the "Discover Media" or the
"Discover Pro" storage interface with mobile phone for R265 (connection box) with
antenna amplifier 3 R112, the signal amplifier with two channels for mobile and J984
GSM antenna R205
b) The electronic calculator information J794 1 of "Composition Media" or the "Discover Media", the
Storage for mobile phone interface with R265 (connection box) with the amplifier
Antenna 3 R112 and R205 GSM antenna
c) The electronic computer information J794 1 of "Discover Media", with storage interface
Mobile phone R265 (connection box) with antenna amplifier and antenna 3 R112
GSM R205
thirty
4. How antenna amplifier 3 R112 (located under the center console) is it connected to the computer
Information electronics 1 J794?
a) Via the CAN data bus Infotainment and Bluetooth in the presence of a mobile telephone
connected
1 . at) ; 2 . b ) ; 3 . at) ; 4 . c )
se s :
R p o not
31
519
Volkswagen AG
Qualification After-Sales Service Training,
VSQ / 2 Brieffach 1995 D-38436 Wolfsburg