POWER JOHN PETRUCCIS SETTINGS SETUP INSTRUCTIONS SPECIFICATIONS
The John Petrucci Signature Cry Baby Wah Run an instrument cable from your Rotate Q ADJ control clockwise for a Filter Parameter is powered by one 9-volt battery (accessed guitar to the JP95s INSTRUMENT jack narrower bandpass to emphasize higher Heel Down Low Pass 200Hz - 240Hz via bottom of pedal), an AC adapter such VOLUME Q ADJ and another instrument cable from end harmonics or counterclockwise for Toe Down High Pass 1.2KHz - 1.5KHz as the Dunlop ECB003/ECB003EU, or the the JP95s AMPLIFIER jack to your a wider bandpass that emphasizes lower Nominal Input -8 dBV DC Brick and Iso-Brick power supplies. amplifiers input. end harmonics. Max Output +6 dBV To turn the pedal on/off, push the toe of The six internal EQ controlslabeled Noise Floor* < -94 dBV 100Hz 200Hz 400Hz 800Hz 1.6Khz 3.2Khz the pedal down until you feel a click. from 100Hz to 3.2Khzcan be used to Input Impedance 800K INTERNAL CONTROLS The JP95 ships with John Petruccis boost or cut the indicated frequency by Output Impedance 5K Q ADJ trimpot adjusts width of control settings by default (see JOHN +/-18 dBV. Rotate clockwise to boost or Output Gain JP95s bandpass PETRUCCIS SETTINGS). Use a trimpot counterclockwise to cut. Toe Down +33 dBV VOLUME trimpot sets overall adjustment tool to change the settings to Rock your foot back and forth on the Heel Down +19 dBV effect volume your own preference. pedal to hear the vocal, expressive tones Bypass Configuration True Hardwire Rotate VOLUME control clockwise that the Cry Baby Wah is famous for. EQ trimpots boost or cut indicated Power Requirements 13mA @ 9VDC frequency (100Hz3.2Khz) to increase effect volume or Note: Internal TEST/NORM switch is for *A weighted counterclockwise to decrease it. production testing only. Always leave it set to the NORM position for full functionality of all controls. DUNLOP MANUFACTURING, INC. P.O. BOX 846, BENICIA, CA 94510 U.S.A. TEL: 1-707-745-2722 FAX: 1-707-745-2658