Professional Documents
Culture Documents
QUESTION 1
The determination of system design requirements of electricity supply either single phase or
three phase is subjected to a few factors. Two of them are type of building and estimated value of
the electric current by counting the total expenses used for connected load and maximum load
(maximum load demand). As an electrical power engineer, you have to know all of the
requirements needed as long as its follow the guidelines and does not violate professional ethics
set. State a design requirements of electrical supply systems for residential and business premises
as well as explain to the consumer one of the types of three-phase system connection.
[refer to http://www.bem.org.my/v3/codes_conduct.html for engineers act and regulations]
QUESTION 2
Mr. Afnan is an employee of the company "S" has come to meet you. He was commissioned to
calculate the reluctance, flux and flux density of the base material for cast iron in his company.
After the expiration of making measurements, he must get approval from the engineers involved.
Based on the measurement reports that have been made, check whether it is correct or incorrect.
If incorrect, as an engineer registered with the Board of Engineers Malaysia, what action should
be taken. Please include with your calculations.
[refer to http://www.bem.org.my/v3/codes_conduct.html for engineers act and regulations]
A magnetic circuit is made of cast iron and arrange as in Fig. 2. An exciter coil of 200 turn is
wound at the centre limb. The cast iron has a square cross sectional 3 cm x 3 cm and relative
permeability of 500. Determine:
i) The reluctance for each limb (centre, left, right) and total reluctance.( Mr. Afnan measure as
centre= 6.25 , left= , right= )
ii) Flux in each limb (centre, left, right) if the centre limb carries a current, I of 2.5 A. (Mr.
Afnan measure as centre= , left= , right= )
iii) Flux density for the air gap in the magnetic circuit.(Mr. Afnan measure as
Fig. 2
QUESTION 3
ASSIGNMENT
NAME : ...
STUDENT ID : ...
PROGRAMME : RK 23 / RK 45 / RK 96
LECTURER :