You are on page 1of 1

Safety features of your vehicle

If the rear seat belt is disconnected when


you drive over 20km/h, the correspon-
ding seat belt warning light will blink for
35 seconds.
But, if the rear passenger's seat belt
is/are connected and disconnected twice
within 9 seconds after the belt is fas-
tened, the corresponding seat belt warn-
ing light will not operate.

OJC030017 B180A01NF-1
Rear seat Lap/shoulder belt
If the ignition switch is turned ON (engine To fasten your seat belt:
is not running) when the rear passen- To fasten your seat belt, pull it out of the
ger's seat belt is not fastened, the corre- retractor and insert the metal tab (1) into
sponding seat belt warning light will illu- the buckle (2). There will be an audible
minate until the belt is fastened. "click" when the tab locks into the buckle.
And then, the rear corresponding seat The seat belt automatically adjusts to the
belt warning light will illuminate for proper length only after the lap belt por-
approximately 35 seconds, if any of the tion is adjusted manually so that it fits
following occurs: snugly around your hips. If you lean for-
- You start the engine when the rear belt ward in a slow, easy motion, the belt will
is not fastened. extend and let you move around. If there
- You drive over 9km/h when the rear belt is a sudden stop or impact, however, the
is not fastened. belt will lock into position. It will also lock
- The rear belt is disconnected when you if you try to lean forward too quickly.
driver under 20km/h.
If the rear seat belt is fastened, the warn-
ing light will turn off immediately.

3 17

You might also like