You are on page 1of 1

OA 6542

Permastic Vinyl Acrylic Emulsion


Product Data (Exterior/Interior)

Description Physical Data

This is a high quality vinyl acrylic emulsion. It is a water borne Volume Solids .................. 29.0% (ASTM D 2697)
thixotropic decorative wall paint for interior and exterior use. It
has a flat finish with a slight sheen. The coating is fully washable Finish ............................... Flat
and can be used in moist areas ie. bath rooms, kitchens,wash
rooms etc. it is a truly attractive finish. Colour .............................. As per colour card

Recommended uses Spreading rate


@ 25 microns DFT........... 11.788 m2 /Lt
Permastic Can be applied with or without primer to plaster,
cementitious surfaces, asbestos, hardboard or over existing Drying time .......................
paint systems, that are in a sound condition To Touch ...................... 30 minutes
To re-coat..................... 2 hours

Principal Properties : Depending on ambient conditions, surface


porosity etc.
1. Water vapour permeable.
2. Alkaline resistant Thinners ........................... Sweet water
3. Fully washable/weather resistant
4. Exceptional flexibility Flash Point ....................... Non Flammable
5. Excellent covering power
6. Almost odour free Application method .......... Brush,Spray/Roller
7. Easy to apply
8. Good colour retention properties. Packing size ..................... 18 Ltr
9. Complies with SASSO standards.
10. Glood flow and spraying properties. Shelf life ........................... 12 months
11. Good adhesive properties.
Storage ............................ Out of sun light
Application methods : Brush ,Roller & Spray
Storage Temp .................. 5C upto 40C
Dilute as required with sweet water to allow for porosity & to
achieve good workability. Note : Allow for application losses. ie.
conditions, surface irregularity, surface porosity
Dilution rate with sweet water : Up to 30% depending on ambient and application method.
conditions, method of application, surface porosity etc.
Volume solids is measured in accordance with ASTM-
D-2697. Slight variations may occur due to colour and
Surface Preparation : testing variances.

For primed surfaces : Clean & degrease. Remove all surface


contamination., de dust.
For Unprimed surfaces : Neutralize if required. Clean & de-
grease. De-dust and remove all surface contamination.

PM181000.doc - PD 1/97

You might also like