ry
[MLD DESIGN APPLICATION - PROJECT Wd
Canon Teer
Techie! conte Techie! conte
Project manager: Project manager:
ols Panne Materia: Project nite
Caves mol olga caves require
‘ycetine Molnar Mol inspection
Prodyeson nour 2nd oper Molin tra
Anal oroaucton: Inatrecar: Fstareie approval:
Target reduction ‘otal ose: Progucton star
PART AEQUREMENTS ‘ESIGN STANDARDS OUD REGUTREMENTS
‘General tlranc, Drawing: BANS! TisO ODN ‘Mold iene
‘ital tleranet) bis Oca 0. Pima ase
Temperate ange ansiasTo “Target
Max deen ox acelin
‘Max sre ne
crap resstance: cS
Fargueresstanee spec:
chemi rexstanee: Color ON RAL Nes
Comment Drenone D
color mate SP nh
‘DESIGN FOR MOLDING Surfs Tenure
Wel icknes
om ent PART MATERIAL SPECS
Tolerances ‘rade name:
No sharp comes: Generic race Gener gade
ctfective in design ites: ‘loys
ttfctve bos desig: cos: Density
rat spied etter Medal:
‘Gating known Density Fatigue lint ese
DESIGN FOR ASSEMBLY rut barnes Sine:
Minimze part: straint viel: ‘saint vee
Top down assembly: Modules Dens
Snap s/adnesives: veld ses Specie hast
‘Union astenes: ce ‘Thermal cont
Pat aay Shinage rate, Cutng speed
‘eeton/hanling Max shear: Fees pe tot:
Comments: “Comments ‘Comments
Zoooo00
oooogo
Figure 2.2 Mold application engineering worksheet
2.2.1 Application Engineering Information
‘The mold design engineer should understand the overall application and develop-
ment schedule, As indicated at the top of Fig. 2.2, the mold designer should know
the appropriate technical contact for questions related to the part design and its
requirements. Ideally, this contact should understand the critical requirements of
the molded part or be able to refer the mold designer to other, more knowledgeable