You are on page 1of 19

[Troubleshooting] Caterpillar excavator

fault code fault code


Sep 6, 2014 | Repair Manual How to | 0 comments

CAT 3 2 0 B repair the fault diagnostic error codes:


1301 engine oil pressure is too low
1302 engine coolant temperature is too high
1303 hydraulic oil temperature is too high
1304 intake filter blockage
1305 Battery voltage is abnormal

2201 connected to the battery voltage governor actuator feedback sensor open or short
2202 is connected to the body grounded governor actuator feedback sensor short circuit
2301 governor actuator feedback signal instability
2302 governor actuator feedback signal deviation
2303 governor actuator does not move
2304 calibration data error
3201 RAM monitor abnormal

Excessive power supply controller 4101 pairs (43 V)


4102 PRV current is too large
4103 PRV open
4104 Monitor Power (digital output) over current
4105 digital output over-current (ditching solenoid valves)
4106 digital output over-current (fine control solenoid valve)
4107 digital output over-current (driving speed change solenoid valves)
4108 digital output over-current (lane siren)
4109 spare solenoid a (digital output) over current
410A digital output over-current (turntable brake solenoid valve)
410B spare solenoid 2 (digital output) over current
4201 engine speed anomalies
4202 is connected to the body grounded engine coolant temperature sensor short circuit
4203 is connected to the body ground hydraulic oil temperature sensor short circuit
4204 is connected to the body ground pumping pressure sensor short circuit PWM
4205 is connected to a ground spare body sensor a short circuit PWM
4206 is connected to the body ground spare PWM sensor 2 short-circuit
4207 PWM power pump delivery pressure sensor open
420A is connected to the body open ground fuel sensor
420B connected to the battery voltage sensor is open or shorted fuel
420C power supply is too low (less than 23 volts)
420D power supply is too high (greater than 32 volts)
420E engine speed dial position 10 is not one of the specified
4301 alternator and speed sensor data does not match the one (alternator exception)
4302 alternator and speed sensor data does not match the two (speed sensor malfunction)
4303 engine stall
A201 monitor communication error
A202 monitor controller signal response time is too long
A203 controller communication error
A20D ADEM communication interruption

CAT320D fault code:

1.320D module identification


Fault Code Description
39 engine and pump controller

2.320D failure mode identification (FMI)


Fault Code Description
OO data is valid, but higher than the normal operating value
Ol data is valid, but less than the normal operating value
02 signal error (data instability, intermittent or there is an error)
03 voltage is higher than normal
04 voltage is lower than normal
05 Current below normal
06 current higher than normal
07 mechanical system response is not normal
08 signal abnormalities (frequency, pulse width or cycle abnormalities)
09 update anomalies
10 abnormal rate of change
11 does not recognize failure modes
12 damage to equipment or components
13 calibration failure
14 parallel measurement failure
15 parallel measurement failure
16 parallel measurement is invalid
17 modules (program) did not respond
18 Sensor power failure
19 receive network data errors
20 parallel measurement failure

3.320D part identification (CID)


Fault Code Description
0041 8V Power
0096 fuel level sensor
Oll0 engine coolant temperature sensor
0167 alternator
0168 System Power
0190 engine speed sensor
0246 CAN data line
0247 SAE J1939 data lines
0248 Caterpillar data lines
0254 electronic control module (ECM)
0262 sv sensor supply
0271 alarm device
0291 engine cooling fan solenoid valve
0362 engine variable speed fan control solenoid valve
0374 Rotary brake solenoid valve
0485 recovery solenoid valve engine fan

4.320D part identification (CID)


Fault Code Description
0544 engine cooling fan speed solenoid valve
0581 power shift pressure proportional solenoid valve
0586 engine throttle plate
0588 instrument display system
0590 ECM
0598 walking speed converter solenoid valve
0600 hydraulic oil temperature sensor
0735 heavy duty lifting solenoid valve
1129 right accessories pedal sensor
1130 on the left pedal sensor attachment
1160 hydraulic lock solenoid
1178 mechanical overload alarm pressure sensor
1522 the 2nd relief check valve solenoid valve
1523 on the 1st relief check valve solenoid valve
1525 linear solenoid valve travel
1590 main hydraulic pump output pressure limiting valve
1593 on the 1st Affiliated extended pressure solenoid valve
1594 the 2nd Affiliated extended pressure solenoid valve
1595 on the 3rd Affiliated pressure solenoid valve
In 1596 the 1st Affiliated recover pressure solenoid valve
1597 the 2nd Affiliated back pressure solenoid valve
1598 on the 3rd Affiliated cancel pressure solenoid valve
1609 F2 mode feedback loop pressure sensor valve
1657 Top Left joystick button
1658 top right button on the joystick
1665 on the 1st adjustable pressure relief valve
1666 the 2nd adjustable pressure relief valve
1931 optional loop
2265 pump output pressure sensor l
2266 pump output pressure sensor 2
2275 Hammer oil return line control (direct tank) solenoid valve
2280 Walking alarm relay
2300 switch panel

Caterpillar C-Series engine fault code table


Flash Code SPN (1) / FMI Code Diagnostic Code
or
Event Code Description of Code
13 174-03 174-03 Fuel Temperature open / short to + batt
Fuel temperature sensor or circuit failure
174-04 174-04 Fuel Temperature short to ground
Fuel temperature sensor or circuit failure
16 626-05 2417-05 Ether Injection Control Solenoid open / short to + batt
Ether injection control solenoid valve or line failure
626-06 2417-06 Ether Injection Control Solenoid short to ground
Ether injection control solenoid valve or line failure
21 678-03 41-03 8 Volt DC Supply short to + batt
8V DC power failure
678-04 41-04 8 Volt DC Supply short to ground
8V DC power failure
620-03 262-03 5 Volt Sensor DC Power Supply short to + batt
5V DC power failure
1079-03
620-04 262-04 5 Volt Sensor DC Power Supply short to ground
5V DC power failure
1079-04
24 100-03 100-03 Engine Oil Pressure open / short to + batt
Oil pressure sensor or circuit failure
100-04 100-04 Engine Oil Pressure short to ground
Oil pressure sensor or circuit failure
100-10 100-10 Engine Oil Pressure abnormal rate of change
Oil Pressure update rate is not normal
25 102-03 102-03 Boost Pressure Sensor short to + batt
Supercharging pressure sensor or line failure
102-04 102-04 Boost Pressure Sensor short to ground
Supercharging pressure sensor or line failure
102-10 102-10 Boost Pressure Sensor abnormal rate of change
Boost pressure is not normal update rate
102-03 1785-03 Intake Manifold Pressure Sensor voltage above normal
Intake air pressure sensor voltage higher than normal
102-04 1785-04 Intake Manifold Pressure Sensor voltage below normal
Intake air pressure sensor voltage is lower than normal
102-10 1785-10 Intake Manifold Pressure Sensor abnormal rate of change
Intake pressure is not properly update rate
26 108-03 274-03 Atmospheric Pressure open / short to + batt
Atmospheric pressure sensor or circuit failure
108-04 274-04 Atmospheric Pressure short to ground
Atmospheric pressure sensor or circuit failure
27 110-03 110-03 Engine Coolant Temperature open / short to + batt
Coolant temperature sensor or circuit failure
110-04 110-04 Engine Coolant Temperature short to ground
Coolant temperature sensor or circuit capacity
28 91-13 91-13 Throttle Position calibration required
Throttle needs to be calibrated
32 91-08 91-08 Throttle Position signal abnormal
Throttle signal is not normal
34 190-08 190-08 Engine Speed signal abnormal
The engine speed signal is not normal
723-08 342-08 Secondary Engine Speed signal abnormal
Spare engine speed signal is not normal
35 190-15 E362 (1) Engine Overspeed Warning
Engine overspeed alarm
190-00 E362 (3) Engine Overspeed Shutdown
Engine overspeed shutdown
37 94-03 94-03 Fuel Pressure open / short to + batt
Fuel pressure sensor or circuit failure
94-04 94-04 Fuel Pressure short to ground
Fuel pressure sensor or circuit failure
38 105-03 172-03 Intake Manifold Air Temp open / short to + batt
Intake air temperature sensor or circuit failure
105-04 172-04 Intake Manifold Air Temp short to ground
Intake air temperature sensor or circuit failure
42 637-13 261-13 Engine Timing calibration required
Engine timing calibration required
46 100-17 E360 (1) Low Engine Oil Pressure Warning
Low oil pressure alarm
100-18 E360 (2) Low Engine Oil Pressure Derate
Low Oil Pressure derating
100-01 E360 (3) Low Engine Oil Pressure Shutdown
Low Oil Pressure Shutdown
51 168-00 168-00 System Voltage high
System Voltage High
168-01 168-01 System Voltage low
System voltage low
168-02 168-02 System Voltage intermittent / erratic
System voltage is not normal
56 630-02 268-02 Check Programmable Parameters
Engine parameter settings to be checked
58 639-09 247-09 J1939 Data Link communications
J1939 data link failure
61 110-15 E361 (1) High Engine Coolant Temperature Warning
Coolant temperature high alarm
110-16 E361 (2) High Engine Coolant Temperature Derate
High coolant temperature derating
110-00 E361 (3) High Engine Coolant Temperature Shutdown
High coolant temperature shutdown
62 111-17 E2143 (1) Low Engine Coolant Level Warning
Low coolant level alarm
111-18 E2143 (2) Low Engine Coolant Level Derate
Low coolant level load shedding
111-01 E2143 (3) Low Engine Coolant Level Shutdown
Low coolant level shutdown
63 94-15 E096 (1) High Fuel Pressure Warning
Fuel pressure high alarm
64 1636-15 E539 (1) High Inlet Air Temperature Warning
Intake air temperature and high alarm
1636-00 E539 (3) High Inlet Air Temperature Shutdown
High inlet temperature shutdown
65 174-15 E363 (1) High Fuel Temperature Warning
Fuel temperature high alarm
174-16 E363 (2) High Fuel Temperature Derate
High fuel temperature derating
174-00 E363 (3) High Fuel Temperature Shutdown
High fuel temperature shutdown
67 0441-15 E445 (1) High Auxiliary Temperature Warning
Auxiliary high temperature alarm
0441-16 E445 (2) High Auxiliary Temperature Derate
Auxiliary high temperature derating
0441-00 E445 (3) High Auxiliary Temperature Shutdown
Auxiliary high temperature shutdown
0441-03 1836-03 Auxiliary Temperature Sensor open / short to + batt
Auxiliary temperature sensor or line failure
0441-04 1836-04 Auxiliary Temperature Sensor short to ground
Auxiliary temperature sensor or line failure
68 1387-15 E443 (1) High Auxiliary Pressure Warning
Auxiliary high pressure alarm
1387-16 E443 (2) High Auxiliary Pressure Derate
Auxiliary high pressure load shedding
1387-00 E443 (3) High Auxiliary Pressure Shutdown
Auxiliary high pressure shutdown
1387-03 1835-03 Auxiliary Pressure Sensor open / short to + batt
A pressure sensor or an auxiliary line failure
1387-04 1835-04 Auxiliary Pressure Sensor short to ground
A pressure sensor or an auxiliary line failure
71 651-05 001-05 Cylinder # 1 Injector open circuit
A cylinder injector fault
651-06 001-06 Cylinder # 1 Injector short
A cylinder injector fault
72 652-05 002-05 Cylinder # 2 Injector open circuit
2 cylinder injector fault
652-06 002-06 Cylinder # 2 Injector short
2 cylinder injector fault
73 653-05 003-05 Cylinder # 3 Injector open circuit
3 cylinder injector fault
653-06 003-06 Cylinder # 3 Injector short
3 cylinder injector fault
74 654-05 004-05 Cylinder # 4 Injector open circuit
4 cylinder injector fault
654-06 004-06 Cylinder # 4 Injector short
4 cylinder injector fault
75 655-05 005-05 Cylinder # 5 Injector open circuit
5-cylinder injector fault
655-06 005-06 Cylinder # 5 Injector short
5-cylinder injector fault
76 656-05 006-05 Cylinder # 6 Injector open circuit
6 cylinder injector fault
656-06 006-06 Cylinder # 6 Injector short

Caterpillar 320D fault code

A Caterpillar 320D module identification

Fault Code Description


39 engine and pump controller

2 Caterpillar 320D failure mode identification (FMI)

Fault Code Description

OO data is valid, but higher than the normal operating value

Ol data is valid, but less than the normal operating value

02 signal error (data instability, intermittent or there is an error)

03 voltage is higher than normal

04 voltage is lower than normal

05 Current below normal

06 current higher than normal

07 mechanical system response is not normal

08 signal abnormalities (frequency, pulse width or cycle abnormalities)

09 update anomalies

10 abnormal rate of change

11 does not recognize failure modes

12 damage to equipment or components

13 calibration failure

14 parallel measurement failure

15 parallel measurement failure

16 parallel measurement is invalid

17 modules (program) did not respond

18 Sensor power failure

19 receive network data errors

20 parallel measurement failure

3 Caterpillar 320D parts identification (CID)


Fault Code Description

0041 8V Power

0096 fuel level sensor

Oll0 engine coolant temperature sensor

0167 alternator

0168 System Power

0190 engine speed sensor

0246 CAN data line

0247 SAE J1939 data lines

0248 Caterpillar data lines

0254 electronic control module (ECM)

0262 sv sensor supply

0271 alarm device

0291 engine cooling fan solenoid valve

0362 engine variable speed fan control solenoid valve

0374 Rotary brake solenoid valve

0485 recovery solenoid valve engine fan

4 Caterpillar 320D parts identification (CID)

Fault Code Description

0544 engine cooling fan speed solenoid valve

0581 power shift pressure proportional solenoid valve

0586 engine throttle plate

0588 instrument display system

0590 ECM

0598 walking speed converter solenoid valve


0600 hydraulic oil temperature sensor

0735 heavy duty lifting solenoid valve

1129 right accessories pedal sensor

1130 on the left pedal sensor attachment

1160 hydraulic lock solenoid

1178 mechanical overload alarm pressure sensor

1522 the 2nd relief check valve solenoid valve

1523 on the 1st relief check valve solenoid valve

1525 linear solenoid valve travel

1590 main hydraulic pump output pressure limiting valve

1593 on the 1st Affiliated extended pressure solenoid valve

1594 the 2nd Affiliated extended pressure solenoid valve

1595 on the 3rd Affiliated pressure solenoid valve

In 1596 the 1st Affiliated recover pressure solenoid valve

1597 the 2nd Affiliated back pressure solenoid valve

1598 on the 3rd Affiliated cancel pressure solenoid valve

1609 F2 mode feedback loop pressure sensor valve

1657 Top Left joystick button

1658 top right button on the joystick

1665 on the 1st adjustable pressure relief valve

1666 the 2nd adjustable pressure relief valve

1931 optional loop

2265 pump output pressure sensor l

2266 pump output pressure sensor 2

2275 Hammer oil return line control (direct tank) solenoid valve
2280 Walking alarm relay

2300 switch panel


CAT320 excavator Fault code details are as follows:

Code No. Description


E0 - no fault
E1 - engine oil pressure is too low
E2 - engine water temperature is too high
E3 - hydraulic oil temperature is too high
E4 - battery voltage is too high
E5 - generator P or W contacts open
E6 - speed sensor is installed incorrectly or circuit breaker
E7 - engine speed is not normal
E9 - throttle motor feedback voltage is too low
El0 throttle feedback sensor circuit shorted or open circuit on the power
E11 throttle feedback sensor shorted to ground
E12 feedback throttle sensor voltage instability
E13 throttle motor circuit shorted to ground
E14 throttle without motor or motor circuit short to power
E15 spare throttle position switch is in standby or throttle motor circuit breaker
E16 proportional valve shorted to ground
E17 proportional valve circuit short to power
E18 proportional valve circuit breaker
E25 water temperature sensor shorted to ground
E27 hydraulic oil temperature sensor short circuit to ground
E31 different controller 10 receives the set engine speed signal and the throttle disc
E32 throttle plate setpoint and actual speed difference over lOOr / min
E33 data output circuit short to power
E34 throttle motor action lags behind the throttle plate 2.5s
E36 monitor reads the signal from the controller for more than Is
E37 Monitor RAM is not normal
E38 controller error signal obtained from a monitor at
E39 controller itself generates an error signal
E40 controller memory error
E41 inconsistent controller and mechanical models
E48 engine stalling

CAT320B Carter excavator


1301 1302 engine oil pressure is too low engine coolant temperature hydraulic oil
temperature is too high 1303 1304 1305 intake filter clogging battery voltage is abnormal
2201 connected to the battery voltage governor actuator feedback sensor open or short
Caterpillar 320C excavator run-time fault code

Code number
MID resolved
69
Engine and pump controller
6A
Tool controller
1E
Monitoring System
Serial number
CID Name
96
Fuel oil level sensor
110
Engine coolant temperature sensor
167
Alternator
168
Supply voltage (key switch)
190
Speed Sensor
248
Caterpillar automatic data transmission device
374
Wheel brake solenoid
376
Driving Sirens
581
Power shift pressure proportional valve
586
Engine speed knob
587
Governor brake feedback sensor
598
Travel speed solenoid
600
Hydraulic oil temperature sensor
1161
Pump output pressure sensor (1)
1162
Pump output pressure sensor (2)
1525
Straight ahead solenoid
2002
Failure alarm
Serial number
FMI name
00
Above the normal range
(Data is valid, but higher than the normal range)
01
Below the normal range
(Data is valid, but less than the normal range)
02
Error signal
03
Voltage higher than normal
(Voltage higher than normal or slightly higher)
04
Voltage is lower than normal
(Voltage lower than normal or less)
05
Current below normal
(Current lower than normal, or circuit disconnect)
06
Current higher than normal
(Current is higher than normal, or circuit ground)
07
Abnormal mechanical response (no reaction to normal mechanical systems)
08
Anomaly signal (abnormal frequency, pulse width or period)
09
Update anomalies (abnormal update rate)
10
Abnormal rate of change (change rate abnormality)
11
Failure mode does not recognize (failure mode does not recognize)
12
Faulty (damaged equipment or parts)
13
Calibration failure (calibration failure)
Record event mode (fault history) into the maintenance mode. Use the arrow keys to select
LOGGED EVENT option (see below).
Carter excavator CAT320C fault code history
This option is to record the history of the machine running the fault code, the third line is a
historical record of the total number of fault error (see below)
Carter excavator CAT320C fault code history

Historical and real-time fault code fault codes differ, shows the MID and EID, MID and the
same data in Table 1, EID data in the following table

Table IV
Serial number
EID resolved
17
Coolant overheat
43
Battery charging abnormal (supply voltage is too low)
50
Battery charging abnormal (supply voltage too high)
59
Coolant level is too low
95
Fuel filter clogged
100
Engine oil pressure drops
119
Fuel oil level is too low
171
Engine oil level is too low
179
Abnormal battery charging (charge anomalies)
232
Water separator discharge points requirements
235
Hydraulic oil level is too low
236
Hydraulic oil filter clogging
237
Overload warning
272
Air filter clogged
600
Hydraulic oil overheating
862
Special filter clogging
863
Automatic Oiler failure

CAT320B Carter excavator repair the fault diagnostic error codes Carter excavator repair
intelligent real-time monitoring, real-time fault error code is displayed in the computer
instrumentation, view the fault code in machine maintenance overhaul excavator which is
conducive to rapid fault, the fault code into the excavator monitor view a password is
required, please view the tutorial, the following is Carter 320B monitoring project option
item 18, the description of the meaning of the fault code 1301 1302 engine oil pressure is too
low engine coolant temperature hydraulic oil temperature is too high 1303 1304 1305 battery
intake filter blockage 2201 is connected to the battery voltage is abnormal voltage governor
actuator feedback sensor open or shorted to ground the body connected to the 2202 governor
actuator feedback sensor shorted 2301 governor actuator feedback signal instability caused
2302 governor the feedback signal has a deviation of the actuator 2303 governor actuator
2304 Fixed error calibration data RAM 3201 monitors the power supply controller 4101 pairs
of abnormal excess (43 V) 4102 PRV open overcurrent 4103 PRV power monitor 4104
(digital output) 4105 digital output overcurrent overcurrent (ditching solenoid valves) 4106
digital output over-current (fine control solenoid valve) 4107 digital output over-current
(driving speed change solenoid valves) 4108 digital output over-current (traffic alert control)
4109 1 spare solenoid (digital output) through the digital output current 410A overcurrent
(wheel brake solenoid) 410B spare solenoid 2 (digital output) through the current engine
speed error 4201 of the body 4202 is connected to the ground of the engine coolant
temperature sensor short circuit 4203 is connected to the body ground hydraulic oil
temperature sensor short circuit 4204 is connected to the body grounded PWM pump delivery
pressure sensor short circuit 4205 is connected to the body ground spare PWM sensor 4206 is
connected to a short circuit to ground the body spare PWM sensor 2 short-circuit power in
4207 PWM pump delivery pressure sensor open circuit 420A is connected to the body open
ground fuel sensor 420B connected to the battery voltage, fuel sensor open or short
420C power supply is too low (less than 23 volts) 420D-powered high (greater than 32 volts)
420E engine speed knob 10 is not one of the specified location does not match 4301
alternator and speed sensor data 1 (alternator exception) 4302 AC generators and speed
sensor data does not match the two (speed sensor malfunction) 4303 engine stall abnormal
A202 A201 monitor communications controller monitors the response time is too long A203
controller signal communication error A20D ADEM communication interruption

Komatsu excavator fault code meaning:


E01, HYPER system in automatic mode systems.
E02, PC-EPC system
E03, Swing parking brake system
E04 + CALL, HYPER system joystick-bit systems
E05, governor motor system
E06 + CALL, HYPER system EPC solenoid valve drive system
E09, HYPER-GX system shutdown.
E101, fault history exception.
E102, clock data anomalies.
E103, buzzer output short circuit, buzzer driving harness contact with the 24V power cable.
E104, air filter clogging.
E108, the water temperature above 105 .
E112, wiper motor drive forward system shorted (new).
E113, reversing wiper motor drive system short-circuit (new).
E114, spray drive circuit shorted (new).
E202, LS select solenoid valve circuit.
E203, Swing parking brake solenoid valve circuit.
E204, pump confluence / bypass solenoid valve circuit.
E205, two overflow solenoid circuit.
E206, walking speed converter solenoid circuit.
E207, fast mode solenoid valve circuit.
E208, fast mode solenoid circuit breaker.
E213, Swing parking brake solenoid valve circuit breaker.
E214, pump confluence / diverter solenoid circuit breaker.
E215, two overflow solenoid circuit breaker.
E216, walking speed converter solenoid circuit.
E207, fast mode solenoid valve circuit.
E208, fast mode solenoid circuit breaker.
E213, Swing parking brake solenoid valve circuit breaker.
E214, pump confluence / diverter solenoid circuit breaker.
E215, two overflow solenoid circuit breaker.
E216, walking speed converter solenoid circuit breaker.
E217, mode selection input fault.
E218, the network in response to a timeout failure.
E222, LS-EPC solenoid circuit.
E223, LS-EPC solenoid circuit breaker.
E224, before the pump pressure sensor circuit is abnormal.
E225, the pump pressure sensor circuit is abnormal.
E226, pressure sensor circuit power anomalies.
E227, the engine speed sensor is abnormal.
E231, activation (rotary) solenoid circuit.
E232, before the pump TVC solenoid circuit shorted (old).
E233, before the pump TVC solenoid circuit breaker (old).
E225, the pump pressure sensor circuit is abnormal.
E226, pressure sensor circuit power anomalies.
E227, the engine speed sensor is abnormal.
E231, activation (rotary) solenoid circuit.
E232, before the pump TVC solenoid circuit shorted (old).
E233, before the pump TVC solenoid circuit breaker (old).
E235, activation (rotary) solenoid circuit breaker.
E236, the pump TVC solenoid circuit.
E237, the pump TVC solenoid circuit breaker.
E302, rotary stroke control solenoid circuit.
E303, rotary stroke control solenoid circuit breaker.
E306, feedback potentiometer circuit abnormalities.
E308, fuel dial input anomalies.
E313, Automatic for the fat controller failure (optional).
E315, the battery relay output circuit.
E316, governor motor disorders.
E317, governor motor circuit breaker.
E318, governor motor circuit.
Komatsu PC200-8 fault code:
PC200-8 using EFI engine, the user code and PC200-6 / 7 there is a big difference.
PC200-8 user code:
E02, PC-EPC system.
E03, Swing parking brake system.
E10, engine controller power failure, the engine control drive system circuit fault (this engine
is stopped.
E11, engine control system failure (reduction of output power, to protect the engine).
E14, feedback system abnormalities.
E15, engine sensors (temperature, fuel pressure, oil pressure) fault.
EOE, network failure.
Fault code:
989L00, engine controller lock warning (mode 1).
989M00, warning the engine controller lock (mode 2).
989N00, engine controller lock warning (mode 3).
CA111, engine controller internal fault.
CA115, engine speed sensor and backup speed sensor failure.
CA122, intake air pressure sensor feedback voltage is too high failure.
CA123, intake air pressure sensor feedback voltage is too low failure.
CA131, throttle plate sensor feedback voltage high failure.
CA132, throttle plate sensor feedback voltage low failure.
CA144, coolant temperature sensor feedback voltage is too high failure.
CA145, coolant temperature sensor feedback voltage is too low failure.
CA153, intake air temperature sensor feedback voltage is too high failure.
CA154, intake air temperature sensor feedback voltage is too low failure.
CA155, intake air temperature is too high (over limit).
CA187, sensor supply two high voltage fault.
CA221, the feedback voltage is too high ambient pressure sensor failure.
CA222, environmental pressure sensor feedback voltage is too low failure.
CA227, sensor supply two high voltage fault.
CA234, engine overspeed.
CA238, speed sensor supply voltage failure.
CA271, IMV / PCV1 short circuit.
CA272, IMV / PCV1 circuit.
CA322, nozzle 1 circuit, short-circuit faults.
CA323, nozzle 5 open circuit, short circuit faults.
CA324, nozzle 3 open circuit, short circuit faults.
CA325, nozzle 6 circuit, short-circuit faults.
CA331, nozzle 2 open circuit, short circuit faults.
CA332, nozzle 4 circuit, short-circuit faults.
CA342, the correction code is incorrect.
CA351, jet drive circuit failure.
CA352, sensor supply voltage is too low failure.
CA386, sensor supply voltage is too high failure.
CA428, fuel moisture sensor feedback voltage is too high failure.
CA429, fuel moisture sensor feedback voltage is too low failure.
CA435, engine oil pressure switch failure.
CA441, the battery voltage is too low failure.
CA442, the battery voltage is too high failure.
CA449, common rail high pressure failure.
CA451, rail pressure sensor feedback value is too high failure.
CA452, rail pressure sensor feedback value is too low failure.
CA488, intake air temperature is too high (torque reduction).
CA553, common rail high pressure failure.
CA559, common rail pressure is too low failure.
CA689, engine speed sensor fault.
CA731, spare engine speed sensor signal phase fault.
CA757, all data is lost.
CA778, spare engine speed sensor fault.
CA633, data transport suspend failure.
CA2185, throttle plate supply voltage is too high failure.
CA2186, throttle plate supply voltage is too low failure.
CA2249, common rail pressure is too low failure.
CA2311, IMV solenoid valve failure.
CA2555, intake air preheating voltage is too high failure.
CA2556, preheat intake low voltage fault.
D19JKZ, personalized transcoding exception.
D862KA, GPS antenna circuit.
DA22KK, pump solenoid valve power supply voltage is too low failure.
DA25KP, 5V sensor supply is abnormal.
DA29KQ, mode selection error.
DA2RMC, CAN circuit (monitor).
DGH2KB, hydraulic oil temperature sensor short circuit.
DHPAMA, before the pump pressure sensor is abnormal.
DHPBMA, the pump pressure sensor is abnormal.
DHS3MA, PPC stick back pressure sensor is abnormal.
DHS4MA, bucket involved in PPC pressure sensor anomaly.
DHS8MA, Boom PPC pressure sensor anomaly.
DHSAMA, turning right PPC pressure sensor anomaly.
DHSBMA, turning left PPC pressure sensor anomaly.
DHSDMA, bucket open PPC pressure sensor anomaly.
DHX1MA, load sensor is abnormal.
DW43KA, walking high and low conversion solenoid valve circuit.
DW43KB, walking high and low conversion solenoid shorted.
DW45KA, rotary solenoid valves keep breaking.
DW45KB, rotary holding solenoid valve is shorted.
DW91KA, two overflow solenoid valve circuit.
DW91KB, walking bus solenoid shorted.
DWA2KA, spare solenoid valve circuit.
DWA2KB, spare solenoid shorted.
DWK0KA, two overflow solenoid valve circuit.
DWK0KB, two overflow solenoid shorted.
DXA8KA, before the pump PC-EPC solenoid valve circuit.
DXA8KB, before the pump PC-EPC solenoid shorted.
DXA9KA, after the pump PC-EPC solenoid valve circuit.
DXA9KB, after the pump PC-EPC solenoid shorted.
DXE0KA, LS-EPC solenoid valve circuit.
DXE0KB, LS-EPC solenoid shorted.
DXE4KA, emergency EPC circuit breaker.
DXE4KB, emergency EPC circuit.
DXE5KA, pumps merging / diverging main solenoid valve circuit.
DXE5KB, pump confluence / diverging main solenoid valve is shorted.
DXE6KA, pump confluence / LS solenoid valve shunt circuit.
DXE6KB, pump confluence / shunt LS solenoid shorted.
DY20KA wiper not working.
DY20MA, wiper parked exception.
DY2CKA, spray motor circuit.
DY2CKB, spray motor shorted.
330C fault / event code
Fault code
Engine Control Engine Controller (MID No. 036)
CID Component element
0001 Injector Solenoid 1st Cylinder 1 # cylinder injector solenoid valve
0002 Injector Solenoid 2nd Cylinder 2 # cylinder injector solenoid valve
0003 Injector Solenoid 3rd Cylinder 3 # cylinder injector solenoid valve
0004 Injector Solenoid 4th Cylinder 4 # cylinder injector solenoid valve
0005 Injector Solenoid 5th Cylinder 5 # cylinder injector solenoid valve
0006 Injector Solenoid 6th Cylinder 6 # cylinder injector solenoid valve
0041 8V DC Supply 8V DC power supply
0042 Injection Actuation Control Valve injectors actuated control valve
0091 Throttle Position Signal throttle position signal
0094 Fuel Pressure Sensor Fuel Pressure Sensor country
0100 Engine Oil Pressure Sensor Engine Oil Pressure Sensor
0110 Engine Coolant Temperature Sensor Engine coolant temperature sensor
0164 Injector Actuation Pressure injector actuation pressure
0168 System Voltage System Voltage
0172 Intake Manifold Air Temperature intake manifold air temperature
0175 Engine Oil Temperature Sensor engine oil temperature sensor
0190 Engine Speed Sensor engine speed sensor
0253 Personality Module personality module
0261 Engine Timing Calibration engine timing verification
0262 5V Sensor DC Power Supply 5V DC power sensor
0268 Check Programable Parameters check programmable parameters
0273 Turbo Outlet Pressure Sensor turbocharger outlet pressure sensor
0274 Atmospheric Pressure Sensor atmospheric pressure sensor
0286 Oil Lamp machine lamp
0342 Secondary Engine Speed Sensor secondary engine speed sensor
0617 Air Inlet Heater Relay air intake heating relay
1627 Fuel Pump Relay fuel pump relay

Engine / Pump Control engine / pump controller (MID No. 105)


CID Component element
0091 Throttle Position Signal throttle position signal
0096 Fuel Level Sensor Fuel Level Sensor
0110 Engine Coolant Temperature Sensor Engine coolant temperature sensor
0167 Alternator Generator
0168 Voltage Of The Power Supply (Keyswitch) key gate voltage
0190 Speed Sensor Speed Sensor
0248 Cat Data Link CAT data lines
0286 Signal For Low Engine Oil Pressure low engine oil pressure signal
0374 Swing Brake Solenoid swing brake solenoid valve
0376 Travel Alarm travel alert
0581 Proportional Reducing Valve For The Powershift Pressure power shift proportional
valve
0586 Engine Speed Dial engine speed dial switch
0587 Feedback Sensor For The Governor Actuator regulator feedback signal transmission
0590 Engine Controller Engine Controller
0598 Travel Speed Solenoid walking speed solenoid valve
0600 Hydraulic Oil Temperature Sensor hydraulic oil temperature sensor
1161 Pump Delivery Pressure Pump pressure
1162 Pump Delivery Pressure Pump pressure
1524 Proportional Solenoid Valve For
Negative Flow Control negative flow control proportional solenoid valve
1525 Straight Travel Solenoid walk a straight line solenoid valve
1590 Proportional Solenoid Valve For
Negative Flow Control negative flow control proportional solenoid valve
2002 Action Alarm Alert

FMI fault description


0 Data valid but above normal operationl range data is correct, but higher than the normal
range
1 Data valid but below normal operationl range data is correct, but lower than the normal
range
2 Data erratic, intermittent, or incorrect data instability, intermittent or incorrect
3 Voltage above normal or shorted high voltage is higher than normal or sudden high
4 Voltage below normal or shorted low voltage is lower than normal or sudden low
5 Current below normal or open circuit current is below normal or open
6 Current above normal or grounded circuit or short circuit current is higher than normal
7 Mechanical system not responding properly. Machine system is not the correct response
8 Abnormal frequency, pulse width, or period. Abnormal frequency, pulse or cycle
9 Abnormal update. Abnormal update
10 Abnormal rate of change. Abnormal rate of change
11 Failure mode not identifiable. Failure mode can not be confirmed
12 Bad device or component. Bad equipment or components
13 Out of calibration. Beyond parity range
14-31 Reserved reserved

Event code
Event Codes Event Code
Engine / Pump Control engine / pump controller

Event Code Condition


017 Coolant Overheat coolant temperature
043 Abnormal Battery Charge
(Voltage To Power Supply Low) abnormal voltage (low voltage)
050 Abnormal Battery Charge
(Voltage To Power Supply High) abnormal voltage (high voltage)
059 Insufficient Level Of Coolant insufficient coolant
095 Fuel Filter Is Clogged fuel filter blockage
100 Engine Oil Pressure Is Low engine oil pressure is low
119 Fuel Level Is Low fuel level low
171 Engine Oil Level Is Low engine oil level is low
179 Abnormal Battery Charge
(Charging Is Abnormal) abnormal battery charge
232 Water Separator Draining Demand need to drain water separator
235 Hydraulic Oil Level Is Low hydraulic oil level is low
236 Hydraulic Oil Filter Is Clogged hydraulic oil filter clogging
237 Overload Warning overload alarm
272 Air Filter Is Clogged air filter clogged
600 Hydraulic Oil Overheat hydraulic oil temperature
862 Special Filter Is Clogged special filter blockage
863 Automatic Greasing Failure grease automatic oiling failure

Event Codes Event Code


Engine Control Engine Controller
Event Code Condition
005 Fuel Filter Restriction Derate fuel filter blockage derating
015 High Engine Coolant Temperature Derate coolant temperature derating
017 High Engine Coolant Temperature Warning coolant temperature alarm
025 High Inlet Air Temperature Derate high inlet temperature derating
027 High Inlet Air Temperature Warning intake air temperature is high alert
039 Low Engine Oil Pressure Derate Low Oil Pressure derating
096 High Fuel Pressure Fuel pressure high
100 Low Engine Oil Pressure Warning Low engine oil pressure alarm
190 Engine Overspeed Warning engine overspeed alarm
265 User Defined Shutdown user-defined flameout

You might also like