You are on page 1of 4

Sepam - ACE850TP / ACE850FO www.schneider-electric.

com

ACE850TP: 59658 DANGER


HAZARD OF ELECTRIC SHOCK, ELECTRIC ARC OR BURNS
b Only qualified personnel should install this equipment. Such work should be
performed only after reading this entire set of instructions and checking the
technical characteristics of the device.
ACE8
50TP b NEVER work alone.
b Turn off all power supplying this equipment before working on or inside it.

BBV35290+01+DP00000000
Consider all sources of power, including the possibility of backfeeding.
b Always use a properly rated voltage sensing device to confirm that all power
is off.
P1
P2 0
10/10-TX
m 0
10/10-TX BASE
Sepa

b Start by connecting the device to the protective earth and to the functional
F C0 BASE
S4
S80

earth.
b Screw tight all terminals, even those not in use.
Failure to follow these instructions will result in death or serious injury.

ACE850FO: 59659 DANGER


RISQUES DELECTROCUTION, DARC ELECTRIQUE OU DE BRULURES
b Linstallation de cet quipement doit tre confie exclusivement des
personnes qualifies, qui ont pris connaissance de toutes les notices
dinstallation et contrl les caractristiques techniques de lquipement.
ACE8
50FO
b Ne travaillez JAMAIS seul.
b Coupez toute alimentation avant de travailler sur cet quipement. Tenez
compte de toutes les sources dalimentation et en particulier aux possibilits
dalimentation extrieure la cellule o est install lquipement.
m
P2
P1
100 X
BASE
-F
b Utilisez toujours un dispositif de dtection de tension adquat pour vrifier
Sepa 100 X

que lalimentation est coupe.


-F Rx
F C0 BASE Tx
S4 Rx
S80 Tx

b Commencez par raccorder lquipement la terre de protection et la terre


fonctionnelle.
b Vissez fermement toutes les bornes, mme celles qui ne sont pas utilises.
Le non-respect de ces instructions provoquera la mort ou des blessures
graves.

CCA614
50 TP
ACE8

P1
P2
10/100
-TX
10/100 BASE
Sepam -TX
F C0 BASE
S4
S80

on I>51 I>>51 Io>51N Io>>51N ext 0 off I on trip

About Sepam
About Sepam
Type : S40
Type : S40
XXXXXXXXXXXX

Sepam Version MSA141 V0215


XXXXXXXXXXXX
UMI V0232 MET148 V0150

Sepam Version
Sepam V3.00 MSA141 V0215
clear reset
UMI V0232 MET148 V0150 ACE850 + ... Version OK OK
...Sepam series 40 V7.00 < V7.00
1 Base V6.00 < V6.00
2 ...Sepam series 80
Appli V6.00 < V6.00

BBV35290-01 1/4
A
ACE850TP: 59658 ACE850FO: 59659
1

2
ACE850TP ACE850FO

3
4

Sepam P2 P1
5 Sepam P2 P1
F C 10/100 10/100 F C 100 100
S80 S40 BASE- FX BASE- FX
S80 S40 BASE-TX BASE-TX
6 Tx Rx Tx Rx

1 ACE850 Interface status Etat de linterface ACE850


2 Communication status Etat de la communication
3 P2: 10Mbit/s or 100Mbit/s P2 : 10Mbit/s ou 100Mbit/s
4 P2: Activity link P2 : Activit ligne
5 P1: 10Mbit/s or 100Mbit/s P1 : 10Mbit/s ou 100Mbit/s
6 P1: Activity link P1 : Activit ligne

7 Power-supply terminal block Bornier dalimentation


8 Earthing terminal Borne de terre
9 Sepam port Port Sepam
10 P2 RJ45 P2 RJ45
11 P1 RJ45 P1 RJ45
12 P2 FO P2 FO
7 8 9 10 11 13 P1 FO P1 FO 7 8 9 12 13

CAUTION-RISK OF DESTRUC

B
Sepam P2 Ethernet P1
F C 10/100 10/100
S80 S40 BASE-TX BASE-TX

ACE850TP

1 2
CAUTION-RISK OF DESTRUC
CTION
Sepam P2 Ethernet P1
TRU
OF DES P1
ISK ernet
TION-R Eth
CAU P2
10/1
00
E-TX
F C 10/100 10/100
BAS
10/1
00
E-TX
S80 S40 BASE-TX BASE-TX
BAS
Sepam
C
F S40
S80

ACE850 ACE850TP ACE850FO

CCA614
CCA614 CCA614

3 3
Sepam series 40 Sepam series 80

C1 C2 F

CCA614 CCA614 D1

4 C D D2

4
BBV35290-01 2/4
C ACE850TP: Ethernet Port P1 / P2

CAUTION ATTENTION
RISK OF DAMAGE TO PORTS P1 AND P2. RISQUE DE DESTRUCTION DES PORTS P1 ET P2.
Never connect the ACE850 Ethernet ports P1 Ne raccordez jamais les ports Ethernet P1 et P2 de
and P2 ports to a Sepam. l'ACE850 au Sepam.
Failure to follow these instructions can result Le non-respect de ces instructions peut entraner
in equipment damage. des dommages matriels.

Pin number Signal


Numero broche Signal

1 RX+

P1
2 RX-

3 TX+

Reserved 1
4
Rserv
Reserved
5
Rserv
8
6 TX-

Reserved P2
7
Rserv

8 Reserved
Rserv

P1
Connector Type Data Port Media Maximum distance
Type de connecteur Donnes Media Distance maximale
P2
RJ45 10/100 Mbits/s Cat 5 STP, FTP, SFTP 100 m / 328 ft

D ACE850FO: Ethernet Port P1 / P2

P1

SC connector 100 FX
Connecteur SC 100 FX

Tx Rx Tx Rx
P2 P1
CAUTION P2
HAZARD OF BLINDING
Never look directly into the end of the fiber optic.
Failure to follow this instruction can cause
serious injury.

ATTENTION P1
RISQUE DAVEUGLEMENT
Ne regardez jamais directement lextrmit
de la fibre optique.
P2
Le non-respect de cette instruction peut
entraner des blessures graves.

Speed standard Mode / Connector Wavelength Fiber diameter Minimum optical Maximum optical Rx sensitivity Rx Saturation Maximum
Vitesse standard Connecteur / Mode Longueur Diamtre power available power available Sensibilit Rx Saturation Rx distance
donde fibre optique Puissance optique Puissance optique (dBm) (dBm) Distance
(nm) (m) minimale TX maximale Tx maximale
(dBm) (dBm) (km / mi)

100FX Multimode SC 1300 50/125 -22.5 -14 -33.9 -14 2 / 1.24


62.5/125 -19 -14 -33.9 -14 2 / 1.24

BBV35290-01 3/4
V DC / V AC
E

x3

1
2

Click!

4
3 5
x3 x2
2

Terminal Description Voltage


Borne Tension

1 -
L

2 Reserved (Rserv) -

0.5...1.5 mm 0.5...2.5 mm 0.5...2.5 mm 8 mm 0.6x3.5 mm 3 mm 0.6 N.m 3 24-250 V DC


or/ou
AWG 20...16 AWG 20...12 AWG 20..12 0.31 in 0.02 x 0.14 in 0.12 in 6 lb-in 4 110-240 V AC

1,2 N.m

2010 Schneider Electric - All rights reserved / Tous droits rservs


11 lb-in

2
1
PZ2

mm b Earthing braid, to be connected


5 to cubicle grounding.
in 0.19
1
0.03 b Tresse de mise la terre, raccorder
la masse de la cellule.

Schneider Electric Industries SAS As standards, specifications and designs change from time to time,
35, rue Joseph Monier please ask for confirmation of the information given in this publication.
CS 30323
F - 92506 Rueil-Malmaison Cedex En raison de lvolution des normes et du matriel, les caractristiques
RCS Nanterre 954 503 439 indiques par le texte et les images de ce document ne nous engagent
Capital social 896 313 776 quaprs confirmation par nos services.

www.schneider-electric.com
Printed on recycled paper.
BBV35290-01 Ce document a t imprim sur du papier cologique. 02-2010

You might also like