Professional Documents
Culture Documents
OWNER'S MANUAL
MODEL
LCS300AN/ LCS300AR
LCS500UN/ LCS500UR
P/NO : MFL63287304
1 Align the left side of the panel with 1 Press the to open the control
the stopper. panel.
2 Push the right side or panel into 2 Push the control panel to right.
the unit until it clicks.
2
Control panel
Caution Protective Case
The control buttons may not work properly if the control panel is not attached
properly. If this occurs, gently press the display.
Note
Do not leave the control panel in any area exposed to high temperatures or
direct sunlight. Periodically wipe the contacts on the back of the control
Do not drop the control panel or otherwise subject it to strong impact. panel with a cotton swap moistened with alcohol. For safety,
turn off the ignition before cleaning, and remove the key
Do not allow such volatile agents as benzine, thinner, or insecticides to come from the ignition switch.
into contact with the surface of the control panel.
Amplifier
Power (OPTIONAL)
Antenna Control Relay
A8 Power Antenna(Blue)
A7 Dimmer(Pink)
Dimmer Switch
A2 To Ignition(Red)
Ignition Switch
B 1 Violet / Black Stripe : Rear Right
A1 To Battery(+)(Yellow) B 2 Violet : Rear Right +
B 3 Gray / Black Stripe : Front Right
B 4 Gray : Front Right +
A5 Ground(-)(Black) B 5 Green/ Black Stripe : Rear Left
B 6 Green : Rear Left +
B 7 White/Black Stripe : Front Left
B 8 White : Front Left +
A4 Phone Mute(Orange)
A6 Not connected
8 CAR CD/MP3/WMA Receiver
1. Turn the unit on. Any key - Turning off the display light
2. Select a source. SRC 1. Press and hold DISP.
SRC
2. Press and hold it again to turn it on.
3. Adjust the volume. Rotate the VOLUME Note
volume knob
Under the light-off condition, press any keys, the light is turned on and then off
4. Turn the unit off. Press and hold Press and hold automatically if you dont press it within a few seconds.
OFF OFF
Resetting the unit
It resets the unit when it does not operate properly.
Basic operation - more you can do
1. Press [ ] and pull out the front panel.
Mute
(Refer to page 6 for detaching the control panel.)
1. Press MUTE to cut the sound. 2. Prick the RESET hold with sharp object.
2. To cancel it, press again.