You are on page 1of 27

7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

HOME EXAMS STORE 3RD PART Y ABOUT LICENSURE ABOUT US CONTACT

Overview
The is the Mechanical Engineering PM Mechanics and Materials Session. Questions are ordered
from Q 081 through Q 120. Problems are in either S.I. or U.S. Customary Units.

This test is available for download for free. No obligation required.

Question to Topic Map

Q 081Q 086 Statics


Q 087Q 089 Kinematics
Q 090Q 093 Dynamics
Q 094Q 097 Material Properties
Q 098Q 104 Strength of Materials
Q 105Q 108 Mechanical Components
Q 109Q 112 Joints and Fasteners
Q 113Q 116 Vibration and Dynamic Analysis
Q 117Q 120 Materials and Process

A full answer key and step-by-step solution set can be purchased here. The answer key is
provided free here. Clicking on an answer choice will also take you to the answer key.

Q 081
An initial analysis must be performed on the design of a proposed linear positioning system. All
components are aluminum alloy unless otherwise noted. The screw diameter is 0.84 inches.

The critical speed (rpm) of the lead screw prior to the installation of the table can be
approximated from:

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 1/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

critical speed = (215 / L^2) * sqrt(g * E * I / (rho * A))

where:

L = lead screw length (inch) = 48


E = modulus of elasticity (psi) = TBD
I = moment of inertia (inch^4) = TBD
= density (lb/inch^4) = TBD
A = cross sectional area (inch^2) = TBD

[A] 1,100
[B] 3,850
[C] 81,250
[D] 100,000

Q 082
A signal arm carries two traffic signals and a sign, as shown. They are rigidly attached to the arm.
Each traffic signal is 0.2 m^2 in area and weighs 240 N. The sign weighs 60 N/m^2. The design
wind pressure is 120 N/m^2

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 2/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

The maximum moment that the connection between the arm and pole can withstand due to the
wind is 7000 N x m, and the maximum permitted moment due to the loads is 5000 N x m. As
limited by moment on the connection, the maximum allowable area of the sign in m^2 is most
nearly.

[A] 2.04
[B] 4.15
[C] 5.65
[D] 7.03

Q 083
In the structure shown, the beam is pinned at point B. Point E is a roller support. The beam is
loaded with a distributed load from point A to point B of 600 N/m, a 200 Nm couple at point C,
and a vertical 700 N force at point D.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 3/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

If the distributed load and the vertical load are removed and replaced with a vertically upward
force of 1500 N at point F (not shown, located 4.5 m to the left of B). What moment at point F
would be necessary to keep the reaction at point E the same?

[A] -7000 Nm (ccw)


[B] -4500 Nm (ccw)
[C] 3200 Nm (cw)
[D] 9400 Nm (cw)

Q 084
Consider the figure. The x and y coordinates of the centroid of the area (in cm) are most nearly.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 4/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

[A] (4.87, 6.03)


[B] (3.70, 4.50)
[C] (3.53, 5.79)
[D] (4.20, 5.10)

Q 085
A 350 kg square plate (10 m x 10 m) is suspended horizontally by four wires of equal length at
each corner. The tension in the four wires is equal. If one of the wires snaps, determine the
tension (in N) in each remaining wire.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 5/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

[A] (Ta, Tb, Tc) = (655, 1715, 655)


[B] (Ta, Tb, Tc) = (1400, 0, 1400)
[C] (Ta, Tb, Tc) = (1715, 0, 1715)
[D] (Ta, Tb, Tc) = (1715, 1715, 0)

Q 086
A cord is wrapped 1/4th around a 3 inch OD pipe as shown. The coefficient of friction (dynamic
and static) between the cord and pipe is u = 0.25.

A dingus with a weight of 100 lb is suspended from one end of the cord and a force P applied to
the other end. The minimum force P (lb) required to just support the 100 lb dingus in the position
shown is most nearly.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 6/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

[A] 15.0
[B] 33.5
[C] 45.0
[D] 148.0

Q 087
A 100 lbm frozen turkey is launched with initial velocity of 1000 ft/sec. It has a launch angle of 45
degrees from the horizontal, and impact elevation of 5000 ft below the launch elevation.
Neglecting air resistance, what is most nearly the horizontal travel distance?

[A] 3.2 miles


[B] 6.7 miles
[C] 12 miles
[D] 22 miles

Q 088
Rigid link AB is 20 m long. It rotates counterclockwise about point A at 30 rpm. A thin disk with a
radius of 3 m is pinned at its center to the link at point B. The disk rotates counterclockwise at

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 7/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

100 rpm with respect to point B. The maximum tangential velocity seen by any point on the disk
(in m/s) is most nearly

[A] 26
[B] 56
[C] 78
[D] 103

Q 089
A car traveling at 100 mph must be able to stop within a distance of 700 ft. The wheel diameter is
25 inches. Assume no brakes lock up during this braking; all brakes are on for total time duration.
Neglect rolling resistance and aerodynamic drag.

The angular deceleration (rad/s^2) of the wheel as the car brakes uniformly from 100 mph to a
stop over a distance of 700 ft is most nearly.

[A] 5.7
[B] 7.5
[C] 11.2
[D] 14.8
http://oughtredco.com/exams/mechanical-pe-081-120#Q081 8/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

Q 090
An industrial electromagnet weighing 400 pounds unloaded holds 150 pounds of scrap metal.
The current is suddenly removed. If the total equivalent stiffness of the cable and the crane is
2000 pounds/inch, what will be the minimum cable tension (lbf) and frequency (Hz) of oscillation
is most nearly.

[A] 250, 7
[B] 300, 7
[C] 150, 3
[D] 300, 3

Q 091
A 5 kg disk with a diameter of 0.1 m is rigidly attached at point B to a rod 2 m in length. The rod
has a mass of 1 kg. The rod-disk combination rotates around point A. The mass moment of inertia
about point A for the assembly in kgm^2 is most nearly:

[A] 0.45
[B] 0.77

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 9/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

[C] 3.6
[D] 21

Q 092
A 10 ton train car, traveling at 25 feet per second, passes point A, rolls down an incline, and is
stopped by a spring bumper that compresses 3 feet. A constant frictional force of 65 lbf acts on
the car. The required spring modulus in lbf / ft is most nearly.

[A] 12,250
[B] 38,450
[C] 50,375
[D] 60,120

Q 093
A wheel with a radius of 0.55 m has a mass of 150 kg. The wheel is pinned at its center and has a
radius of gyration of 0.25 m. A rope is wrapped around the wheel and supports a hanging 200 kg
cube.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 10/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

When the wheel is allowed to spin, the rope begins to unwind. The angular acceleration of the
wheel in rad/sec^2 is most nearly.

[A] 15.4
[B] 18.5
[C] 24.8
[D] 30.8

Q 094
An aluminum bar with E = 10 x 10^6 psi that is 2 feet long has a cross sectional area of 0.25 in^2 is
mounted against a spring as shown. The spring has a spring constant of 5,000 lb/in. If the
nominal coefficient of thermal expansion is 5 x 10^-6 in / in F, the increase in force produced in
the bar by a temperature increase of 300 F is most nearly.

[A] 87
[B] 170
[C] 690
[D] 754

Q 095
The engineering stress and strain for an aluminum sample (Poisson's ratio of 0.2) were 15,000 psi
and .0400 inch/inch. The true stress (psi) and true strain (in/in) is most nearly.

[A] 14,900; .035


[B] 15,000; .040
[C] 15,242; .039
[D] 15,456; .042

Q 096
Zinc is commonly plated on steel machine screws and fasteners to prevent corrosion. What is the
name of this type of corrosion protection?

[A] passivation
[B] anodic protection
[C] cathodic protection
[D] galvanization

Q 097
http://oughtredco.com/exams/mechanical-pe-081-120#Q081 11/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

Aluminum is more resistant to rusting than steel. Why?

[A] Iron can be attracted through a magnetic field


[B] Iron has a different cubic structure than aluminum resulting in a more corrosive surface
[C] The reaction rate between aluminum and oxygen is higher
[D] The reaction rate between iron and aluminum is higher

Q 098
The Goodman Relation / Failure Criterion is used to relate what two stresses to fatigue life:

[A] axial and torsional stress


[B] temperature induced and axial stress
[C] torsional and bending stress
[D] alternating and mean stress

##Q 099

A 30 inch long cantilever beam carries a uniformly distributed load of 12 lb/inch extending 10
inches from its free end. The shear force (lb) in the beam at a distance of 6 inch from the free end
is most nearly.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 12/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

[A] 55
[B] 72
[C] 95
[D] 110

Q 100
A cantilevered flat steel spring supports a tip load that periodically varies between 0 lbf and 2 lbf.
The spring is 0.75 in wide and 4.0 in. long. Tensile yield strength is 60,000 psi, tensile ultimate
strength is 120,000 psi, and endurance strength after accounting for various derating factors is
50,000 psi. The design factor of safety is 2. The minimum required spring thickness for ultimate
life is most nearly.

[A] 0.023 in.


[B] 0.031 in.
[C] 0.042 in.
[D] 0.052 in.

Q 101
http://oughtredco.com/exams/mechanical-pe-081-120#Q081 13/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

A 25 ft length of 5 in nominal diameter schedule-40 steel pipe full of water is simply supported.
The maximum pipe deflection in inches is most nearly.

[A] 0.13
[B] 0.45
[C] 0.57
[D] 0.64

Q 102
Bolt test specimens made of an experimental low carbon steel are subjected to completely
reversed loading. At a stress amplitude of 70 ksi, the life is 1,000 cycles. At 30 ksi, the life cycle is
1,000,000 cycles. The number of cycles of life expected at a stress amplitude of 50 ksi is most
nearly.

[A] 15,000
[B] 200,000
[C] 600,000
[D] 1,000,000

Q 103
An inner steel cylinder (where its diameter = 5 inch) is surrounded by an aluminum tube (where its
diameter = 10 inch) as shown in the cross section. The aluminum and the steel are well bonded. A
uniform compressive load of 50 kips is applied axially. Use E_steel = 3.00 x10^7 psi and

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 14/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

E_aluminum = 1.00 x 10^7 psi. The stress in the steel inner cylinder in psi is most nearly

[A] 728
[B] 850
[C] 1000
[D] 1275

Q 104
The figure shows a flattening device for clay blanks. The device consists of a slider at A. The
slider moves in a vertical guide. Joints connect Links ABC, BD, and the slider at A. All links and
pins at ABD are made with materials having the following physical properties:

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 15/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

Modulus of Elasticity 30 x 10^6 psi


Yield Strength, S-y 60,000 psi
Ultimate Strength, S-u 100,000 psi
Shear Strength 20,000 psi

Link BD, of length 7.07 inch, is made out of a solid bar of circular cross section and is designed to
carry an axial load of 500 lb. A safety factor of 2 against yield and 1.5 against buckling is desired
for safety reasons. The diameter (in.) of the bar used for Link BD is most nearly.

[A] 0.103
[B] 0.146
[C] 0.184
[D] 0.225

Q 105
A ball bearing is subjected to a radial load of 100 lb (with no axial load), has a rated life of
200,000 min, and a rated speed of 500 rpm.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 16/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

The allowable radial load (lb) of the bearing when rotating at 5 rad/sec with a design life of
350,000 min is most nearly.

[A] 264
[B] 207
[C] 144
[D] 89

Q 106
An 10 in diameter schedule 40 seamless steel pipe carries steam at 800 F. The maximum allowed
tensile stress is 12.8 x 10^3 psi. The double butt flange welds are not radiographed. The
manufacturing allowance is 20%, and corrosion allowance is 0.12 in. The maximum allowable
pressure in psi is most nearly.

[A] 290
[B] 378
[C] 469
[D] 623

Q 107
A hydraulic cylinder with an inside diameter of 10 inch is subjected to an internal pressure of
2,500 psi. Ignore end effects. Assuming allowable stress of 10,000 psi and a safety factor of 3,
the required thickness (in.) is most nearly.

[A] 5.80
[B] 4.37
[C] 2.12
[D] 1.45

Q 108
A gear drive is used to lift a garage door to a factory, as shown in the figure. The coefficient of
friction for all mating surfaces of the vertical screw is 0.15, and the friction in the gearbox is
negligible.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 17/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

The vertical screw shown in the figure has a mean diameter of 2 inch and a pitch of 0.50 inch.
The gearbox ratio is 4:1 When the total vertical force to lift the garage door is 2,000 lb, the output
torque (lb-in) from the motor is most nearly.

[A] 115
[B] 240
[C] 310
[D] 820

Q 109
The end of a circular steel tube is welded to a steel plate. The full-perimeter external fillet weld
has a 3/16 in leg, and allowable load is 8,400 lbf/in of leg. The tube outside diameter is 2 in. The
tube and plate thickness is 1 in.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 18/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

A load is applied 4 in. from the plate surface, parallel to the plate, perpendicular to the tube axis,
and at the centroid of the tube section. What is most nearly the maximum supported load?

[A] 3810 lbf


[B] 3460 lbf
[C] 2820 lbf
[D] 1130 lbf

Q 110
A cantilevered beam 40 m long is supported at its left end (Point A) and 8 m from its right end
(Point B). The beam bears a uniform load of 25 N/m and a concentrated load of 600 N applied 10
m from its right end. The vertical shear acting on the beam at point C, in N, which is 12 m from the
left end, is most nearly.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 19/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

[A] -37
[B] -112
[C] 325
[D] 1000

Q 111
A 1/4 inch steel plate is attached to a steel beam with three 1/4-inch UNC bolts, as shown.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 20/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

The load (lb) that the highest loaded bolt will carry is most nearly.

[A] 1680
[B] 4570
[C] 8660
[D] 9720

Q 112
The blind pressure vessel flange is restrained by eight equally spaced 7/16-14 inch UNC steel
bolts. The internal diameter of the pressure vessel is 12 inches. To maintain an adequate seal,
each bolt is preloaded to 7,000 lb.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 21/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

The bolt stiffness (k_bolt) and the material stiffness (k_parts) are numerically equal. The bolt
stress (psi) for an internal pressure of 300 psi is most nearly:

[A] 19,000
[B] 54,000
[C] 68,000
[D] 86,000

Q 113
An experimental widget can be modeled as a mass/spring mechanism. The spring constant of 50
lbf/in and a mass of 7 lbm undergoes free vibration.

The linear frequency (cycles/sec) of this vibration is most nearly.

[A] 0.94
[B] 1.7
[C] 4.3
[D] 8.3

Q 114
http://oughtredco.com/exams/mechanical-pe-081-120#Q081 22/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

Q 114
A 100 lbm motor turns at 2000 rpm and is supported on a resilient pad having a stiffness of 2000
pounds per inch. Due to an imbalance condition, a periodic force of 30 pounds is applied in the
vertical direction once each revolution. If the motor is constrained to move vertically, the
amplitude of vibration in inches is most nearly.

[A] .0032
[B] .0065
[C] .012
[D] .019

Q 115
A rotating mechanisms comprises a vertical axis, three steel balls spinning around that axis, and
an ideal torsional spring resisting the motion.

Arms supporting the balls are rigid and massless, the distance from the vertical axis to ball
centers is 0.5 inch. The torsional spring constant is 3.5 x 10^-3 inch-lbf / rad. The steel ball
diameter and density are 1.5 inch and 0.125 lbm/inch^3, respectively. The natural torsional
frequency (in Hz) of the pendulum is most nearly.

[A] 0.16
[B] 0.24
[C] 0.33
[D] 0.51

Q 116
The block spring system shown oscillates once every 6 seconds. There is no friction between the
block and the surface. If the spring constant is 2 N/m the approximate mass of the block in kg is
nearly.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 23/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

[A] 1.8 kg
[B] 2.6 kg
[C] 5.9 kg
[D] 6.8 kg

Q 117
You manage a toy production department and you are new to the job. You must make a decisions
about equipment selection and production costs. Part material cost is $7 for each part scrapped,
not including sunk labor costs.

Machine Labor Cost (per Production Rate Part Scrap Part Setup
hour) (units/hr) Rate Cost
Manual $40 10 1 of 32 $9
CNC w/ manual $22 11 1 of 80 $4
load
CNC w/ auto load $17 16 1 of 60 $16
3d printing $10 7 1 of 300 $250

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 24/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

The % increase of good parts per 80-hr work week that can be made on the CNC with auto
loading vs manual loading is most nearly.

[A] 15
[B] 24
[C] 45
[D] 124

Q 118
Bean counters must select a structural polymer from the following list of materials. Based on the
following requirements and info, they are going to attempt to make a design selection. One
critical dimension, fabricated to 10.000 inches at 25 degrees C, must not exceed 10.055 inches at
the operating temperature of 100 degrees C. Material weight must be less than half that of
aluminum, which has a specific gravity of 2.71.

Material Yield Specific Coefficient of Thermal Maximum Operating


Strength [psi] Gravity Expansion [in / (inC)] Temperature [F]
A 4,500 1.05 90 x 10^-6 190
B 10,000 1.5 70 x 10^-6 220
C 8,000 1.1 80 x 10^-6 165
D 9,300 1.20 70 x 10^-6 260

Which is the best material for the application?

[A] Material A
[B] Material B
[C] Material C
[D] Material D

Q 119
Table I shows subgroup data from a measurement process over a 12-hour period. Each subgroup
is made up of a sample size of 6.

Table 1

Subgroup 6:00 9:00 12:00 15:00 18:00


1 7.2 7.5 8.3 8.3 6.8
2 7.1 7.1 7.6 8.1 7.3
http://oughtredco.com/exams/mechanical-pe-081-120#Q081 25/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

3 6.9 7.6 7.9 7.2 7.0


4 7.4 7.8 8.1 8.4 7.2
5 7.2 7.8 8.9 8.4 6.9

Table 2

Sample Size A2 D4 D3
2 1.88 3.27 0.00
3 1.02 2.57 0.00
4 0.73 2.28 0.00
5 0.58 2.11 0.00
6 0.48 2.00 0.00

From the data provided in Tables 1 and 2, the upper control limit (UCL) and the lower control limit
(LCL) of an R chart are most nearly.

[A] UCL = 3.41; LCL = 0


[B] UCL = 1.39; LCL = -1.39
[C] UCL = 2.42; LCL = -2.42
[D] UCL = 2.68; LCL = 0

Q 120
A 0.500 inch diameter hole and pin are to be combined during assembly. Drawings indicate
tolerances as listed. The basic hole system is used.

Feature High Tolerance Low Tolerance


Hole Diameter +4.6 x 10^-3 inch -0 x 10^-3 inch
Pin Diameter -6.0 x 10^-3 inch -7.0 x 10^-3 inch

This fit is most nearly designated as:

[A] RC7 free running fit


[B] RC9 free running fit
[C] LT3 locational-transitional fit
[D] FN2 medium drive fit

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 26/27
7/10/2017 Mechanical PE PM Mechanics and Materials Oughtred Co.

Privacy Policy

Like 2 people like this. Be the first of your friends.

Tweet 0

Copyright 2014-2016 Oughtred Co.

http://oughtredco.com/exams/mechanical-pe-081-120#Q081 27/27

You might also like