Professional Documents
Culture Documents
ENGINEERING
1. Construct the Commutation Circuit using SCR & draw the phase control characteristics.
3. Construct a MOSFET based PWM Chopper Circuit and test the performance of it.
4. Construct an IC Based Buck Converter Circuit using PWM and test it.
5. Write a Simple Ladder Logic Program for AND operation, OR operation & XOR operation
and verify the same using PLC.
6. Write a Simple Ladder Logic Program to interface a Lift Control with PLC and test it.
7. Write a Simple Ladder Logic Program to interface a Conveyor Control with PLC and test it.
8. Write a Simple Ladder Logic Program for Timer with branching & subroutines with PLC
and test it.
9. Write a Simple Ladder Logic Program for Counter with branching & subroutines with PLC
and test it.
10. Draw the circuit for Amplitude Modulation & Demodulation. Simulate the same using the
simulation tool like PSPICE / Multisim / OrCAD / TINA.
11. Draw the circuit for Frequency Modulation & Demodulation. Simulate the same using
the simulation tool like PSPICE / Multisim / OrCAD / TINA.
12. Construct and test a Symmetrical T & Pi Attenuators for a loss of 1db, 2db, 4db & 8db and
terminating resistance of 600 ohms and draw the characteristics for the same.
13. Construct and test a Constant K Passive Low Pass Filter for a Load Resistance of (R L) 600
ohms and Cut-Off frequency of (fc) 5.3 KHz and draw the characteristics for the same.
14. Construct and test a Constant K passive High Pass Filter for a Load Resistance of (R L) 600
ohms and Cut-Off frequency of (fc) 12 KHz and draw the characteristics for the same.
15. Construct Pulse Amplitude Modulation (PAM) Generation & Detection circuits and
test their performance.
16. Construct Pulse Code Modulation (PCM) Transmitter and Receiver circuits and
test their performance.
17. Construct a Three Way Cross Over Network and test the performance of it.
ALLOCATION OF MARKS
CIRCUIT DIAGRAM 20 Marks
CONNECTION / MAKING
THE CIRCUIT USING THE 20 Marks
SIMULATION TOOL
HANDLING OF
EQUIPMENT& EXECUTION / 20 Marks
SIMULATION
RESULT / OUTPUT 10 Marks
VIVA-VOCE 05 Marks
TOTAL 75 Marks
DIPLOMA IN ELECTRONICS AND COMMUNICAITON
ENGINEERING
Scheme: M-Scheme
Semester: IV
1. Verify the truth-tables of the logic gates AND, OR and EX-OR using ICs.
2. Verify the truth-tables of the logic gates NAND, NOR and NOT using ICs.
3. Realize the Basic Logic Gates with only NAND gates using ICs and verify the truth-tables of them.
4. Realize the Basic Logic Gates with only NOR gates using ICs and verify the truth-tables of them.
6. Construct and verify the following logic circuits (i) Half Adder (ii) Half Subtractor.
17. Construct and test a Single Digit Decade Counter with 7 Segment Display.
21. Simulate ANY THREE of the following circuits using any one of the simulation tools like PSPICE
/ Multisim / OrCAD / TINA: 1. Hartley Oscillator 2. Phase Shift Oscillator 3. Sine Waveform
Generator 4. Square Waveform Generator 5. Triangular Waveform Generator 6. Precision
Rectifier.
ALLOCATION OF MARKS
6. TOTAL : 75 Marks