Professional Documents
Culture Documents
PLUMMER BLOCK
Assembly
PARTS:
1) Casting 2) Cap
3) Upper Brass 4) Lower Brass
5) Bolt 6) Lock Nut
7) Nut
TOOLS USED:
Hole Tool
CONSTRAINS:
Vertical Tangent
Horizontal Perpendicular
Symmetric Middle
Collinear Parallel
Equal
Part No 1 (Casting)
Select &
Select & .
File Save.
Window Close.
File Exit.
Part No 2 (Cap)
Select &
Select .
Give the rotation angle 180 degrees.
Click .
Click and select RIGHT plane.
Sketch the figure as shown below.
Select .
Give the rotation angle 180o.
Click .
Click and select RIGHT plane.
Draw the Sketch as shown below.
Select .
Give the rotation angle 360o.
Click .
File Save.
Window Close.
File Exit.
Part No 5 (BOLT)
Select .
Give the rotation of 360o.
Click .
Make M 10.
Section Define.
Click .
Click and select TOP plane.
SKETCH REFERENCES.
Draw a horizontal center line and sketch as shown below.
Click .
Part No 7 (NUT)
Click .
Click and select TOP plane.
SKETCH REFERENCES.
Draw a horizontal center line and sketch as shown below.
Click .
ASSEMBLING OF CASTING
Select .
Select constraint.
Select the face of lower brass and casting as shown below.
Select .
Select .
Select constraint.
Select the face of Upper brass and Lower brass as shown below.
Select .
Select .
Select constraint.
Select the face of Upper brass and Lower brass as shown below.
Select .
ASSEMBLY OF CAP
Select .
Select constraint.
Select .
Select constraint.
Select the face of brass and brass as shown below.
Set ..
ASSEMBLY OF BOLT
Select constraint.
Select the face of bolt and casting as shown below.
Select .
Select &
Select constraint.
Select the face of lock nut and cap as shown below.
Select .
Select &
ASSEMBLY OF NUT
Select constraint.
Select the face of nut and lock nut as shown below
Select .
Select &
EXPLODED VIEW: