Professional Documents
Culture Documents
LAWN MOWER
LazerCut
LCS400
CONSUMER
HELPLINE
1800 466 068
1 1 2
4. 5. 6.
1 1 4
7. 8.
1 1
PAGE 2
1
2
3 5
10
8 7
7. Muffler/Exhaust
PAGE 3
WWW.SANLI.COM.AU
INSTRUCTION MANUAL
Parts required:
4 x Bolts and Nuts
1. LOWER HANDLEBARASSEMBLY
1.
PAGE 4
ASSEMBLY GUIDELINES
LAWN MOWER LCS400
2. UPPER HANDLEASSEMBLY
2. 3.
Parts required:
2 x Handle Knobs
2 x Bolts
4. 5. 6.
2. Upper Handle Assembly 4. Attach the Grass Catcher 6. Complete machine ready for your
Fit the right side Handle Knobs and Lift the Rear Flap with one hand. lawn.
Bolts.
5. Attach the Grass Catcher
3. Fit the Cable Clip Lower the Grass Catcher
Push the Cable Clip into place. hook onto bar.
PAGE 5
INSTRUCTION MANUAL
PAGE 6
BEFORE YOU BEGIN/STARTING THE ENGINE
LAWN MOWER LCS400
ON OFF
Fig 5 Fig 6
CO ART
ST
LD
RU
N
ST
OP
Fig 7 Fig 8
CO ART
ST
LD
RUN
RU
N
ST
OP
Starting the engine 4. Firmly hold the top handle with 6. To restart a hot engine, move the
1. Make sure that your mower is one hand, and then with your throttle control lever to the Run
on a safe, at area (a paved area other hand pull the cord slowly position and then refer to
or path is ideal - avoid thick wet until you feel resistance. Then Point 4 .
grass and gravel surfaces) away pull vigorously with one steady
7. To turn off your mower, slide the
from fuel or fueling area to action (Fig. 7). Guide the cord
throttle control lever down to the
make starting safe. back to its rest position (do not
Stop position. After it has stopped,
release).
2. Slide the Red petrol tap lever slide the Red petrol tap lever to
to the left On position (Fig. 5). 5. When the engine has been the right Off position.
running for at least 15 seconds
3. Move the throttle control lever
(more time on cold days) (Fig. 8)
located on the handle to the
adjust the throttle control lever
Cold Start position
to the Run position.
(Fig. 6).
PAGE 7
INSTRUCTION MANUAL
Fig12 Fig13
ON OFF
Attach the Grass Catcher Cleaning your Mower tarpaulin or similar cover as it may
The grass catcher attaches easily by cause condensation resulting in
! WARNING! Turn mower off before cleaning
lifting the mowers Rear Flap with corrosion.
one hand (Fig. 9) and slide the Grass Cut grass is damp. Regular cleaning
Catcher into position (Fig. 10). after each use will ensure better Transporting your Mower
functioning of the mower and reduce Ensure the fuel tank is empty. Run
Cutting Height Adjustment the risk of corrosion or seizure. the engine until any remaining fuel is
Turn mower off before Having finished mowing, allow consumed. Allow the engine to cool.
! WARNING! adjusting cutting height lever the engine to cool then remove Turn fuel tap to OFF position (Fig. 13).
For best results adjust the cutting accumulated grass clippings from and
height of your mower to suit the around the engine with a brush. Clean How to cut for best results
mowing conditions. Do not try to the grass collection bag annually with For best results cut your lawn in
remove too much grass in one pass. a brush or gentle spray of water and alternative directions switching
allow to dry. direction each time you cut. Cut your
Adjustment of the cutting height is lawn at an equal and same height.
Clean underneath regularly - Slightly overlap your cutting lines.
made centrally. Take hold of the cut disconnect the spark plug cap and tilt
height adjustment lever, positioned on the mower on back. Remove cut grass
the mowers righthand rear wheel. from the cutting system with a scraper
and a brush.
Move the lever outwards to release
it from its locating notch. Move Do not use a pressure washer or hot
the lever towards the front of the water to clean the mower. Dry off the
machine to increase the cutting height machine before storing by leaving it
and towards the rear to reduce the running for a few minutes on a flat,
cutting height. Return the lever to clear surface to prevent corrosion or
the locating notch to set the desired seizure.
cutting height.
Make sure the handle fits snugly and Storing your Mower
securely into its serrated holder. Store your mower in a dry, well-
ventilated area, away from flames,
Mowing your Lawn sparks or heat sources. Disconnect the
Start your mower (see: Starting the spark plug cap. Avoid storing beneath a
engine). After mowing and emptying
the Grass Catcher ensure the engine
is not running and turned off.
PAGE 8
USING YOUR MOWER/SAFETY TIPS
LAWN MOWER LCS400
CO ART
ST
LD
RU
N
3/4 5 7
ST
OP
HOT!
8 12 19
Max 20
1. Before starting your mower inspect 8. Mow across the face of slopes, not 14. Do not transport the
it carefully to ensure that there are up & down, and avoid mowing on mower in a vehicle if there
no loose parts and that it is in good very steep slopes. We recommend is any petrol in the tank.
working order. you avoid mowing when it is
raining, after nightfall or in poor 15. Be aware that the machines
light conditions. exhaust area and other parts
2. Be sure of your footing. of the lawnmower get very
Always walk, never run, when
9. Do not operate the machine by hot during and right after use.
operating the lawnmower.
pulling it towards you as you risk
pulling it onto your feet. Instead, 16. Turn off the engine before
3. Keep hands, feet and clothing away emptying the grass-catcher and
from the mowers moving parts always push and walk behind your
lawnmower. before clearing any grass caught in
always wear appropriate footwear
the rear ap where the catcher ts.
(avoid sandals or open shoes).
10. Do not ll the tank, or start the
lawnmower indoors, or in a poorly 17. Store fuel and oil in a cool well-
4. Never put your hands or feet ventilated area, as exhaust gases ventilated place, away from direct
underneath the chassis of the sunlight and gas cylinders or hot
contain poisonous substances
lawnmower while the engine is water heater systems.
and petrol fumes are ammable
running. and dangerous. 18. It is recommended that you wear
5. Clear the area to be mowed of any a ear protectors, safety goggles
11. Do not alter engine governing
stones, sticks, wire and debris and safety boots when using the
settings or over-rev the engine, as
before beginning. Always ensure lawnmower.
excessive speed is dangerous and
that you mow a safe distance away can reduce engine life. 19.To inspect the underside of your
(over 14 metres) from adults,
children and animals. 12. Do not smoke when lling mower, only tilt the lawnmower to
the fuel tank, using the machine, your right, or back, when standing
6. Turn off the engine and disconnect or when petrol is in the immediate behind it (this is the side where
the spark plug cap before the exhaust is near the ground)
area. Never use or store the
cleaning, transporting, or making otherwise oil may leak into
mower near a naked ame.
adjustments. Never leave the inappropriate areas of the engine.
mower unattended. 13. Always use fresh 95 octane Never tilt the lawnmower when
premium unleaded petrol that is the engine is running.
7. Never open the fuel ller cap, or not more than 4-6 weeks old. Fill
ll the tank, if the engine is still hot 20. All servicing and repair work
the tank using a funnel, but never
after use. Please ensure that under warranty must be carried
completely. Clean up any overow
you securely tighten the petrol cap out by an Authorised Dealer.
or splashes before starting.
after lling.
PAGE 9
INSTRUCTION MANUAL
MAINTENANCE SCHEDULE
! WARNING! The following procedures must be carried out before you start the engine of your lawnmower.
Before and after each mowing For best mowing results, have the OUT
session, check that the blade, its edges sharpened and the blade
attachment bolts and drive shaft balanced at least once a year by a
are not damaged or excessively specialist service dealer or agent.
worn. Never try to straighten a
Spark Plug
bent blade. Replace a damaged, Mounting the blade
Check the spark plug initially after
worn or bent blade as soon as Wear appropriate protective gloves
the first five hours of mower use.
possible. Use only genuine SANLI to prevent possible injury when
Thereafter, maintenance of the spark
parts or those approved by SANLI. handling the blade. Disconnect
plug should take place every 25 hours.
the spark plug cap and tilt the
Excessive vibration when mowing
mower on its side with air filter side Remove the spark plug cap (Fig.14)
is a good indication of a problem
uppermost. using a rotary motion and then remove
with the cutting system.
the spark plug with the wrench
Check that all components (the
provided (Fig.15).
Vibration from a bent or damaged
blade can cause costly damage to the
blade, key, blade holder, screws and
! mower. Working with an excessively washers) are present, clean and in Clean off any carbon deposits using a
worn blade wastes fuel and can
WARNING! lead to injury if the blade becomes
good condition. copper brush and check the electrode
detached from the machine. Position the blade on its support gap with a feeler gauge (the gap should
with the cooling fins facing the be 0.7 mm). Replace and tighten the
Removing the blade engine. serviced spark plug and replace the
Wear appropriate protective cap.
Check the correct alignment and
gloves to prevent possible
matching of pads with the blade. If the spark plug is worn or damaged,
injury when handling the blade.
The blade must be positioned replace with a new spark plug of the
Disconnect the spark plug cap
precisely on its stand. same or suitable type for the engine.
and tilt the mower on its side with
If in doubt, contact your point of
air filter and carburettor side Tighten the screws connecting all of
purchase or local dealer.
uppermost. the components. Make a final visual
check that all parts are present and
Holding the blade firmly in one
aligned before tightening the fixing
hand, use a spanner or socket to
bolt very firmly with a wrench while
loosen the blade screw.
holding the blade firmly in one hand
(NB wear suitable gloves).
PAGE 10
BASIC MAINTENANCE
LAWN MOWER LCS400
Fig16
Fig17 Fig18
MAX MAX
MIN
MIN
Do not twist the foam cartridge to for this). Insert the filter cartridge Changing the oil
clean it as this could cause damage.
If your mower is not serviced into its housing and replace The first oil change should be
correctly, you could reduce your
mowers ability to operate and void
the filter lid, ensuring that each carried out after the first 5 hours
WARNING!
warranty. component is in place and properly of mower use. Thereafter, change
installed. If the filter cartridge is the oil after every 25 hours use
damaged or is very dirty, replace it or at least once a year. Leave the
Air Filter using a genuine part. engine running outdoors for several
An air filter in poor condition minutes to warm the oil and make it
will reduce the performance and Checking the oil level more fluid.
life of the engine while making it Position the mower on a firm,
harder to start. Regular checks level surface. Unscrew the oil level ! WARNING!
Parts of the engine will become very
hot and can cause severe burns.
are therefore essential, especially dipstick (Fig.17) and wipe dry.
when using the mower in dusty Insert the dipstick until it reaches Remove the spark plug cap and
conditions. Check and clean the air the filler neck, but do not screw unscrew the oil level dipstick. Place
filter every 25 hours of use or more in. Remove the dipstick and check a suitable container beneath the
often if the engine is used in a dusty the oil level holding the dipstick mowers oil filler pipe and tilt the
environment. horizontal. mower onto its side with the air
Remove the air filter cover lid and filter and carburettor uppermost.
carefully remove the foam filter The oil level should be between Allow the oil to drain completely
cartridge. Clean the cartridge in a the minimum and maximum oil into the container. Return the
small bowl of warm water containing level marks on the dipstick (Fig.18). mower onto its four wheels and fill
a few drops of washing-up liquid Add oil if necessary and repeat the the engine with new oil.
until it is perfectly clean and free above checking process. Running
from all traces of grease and dust. the engine without oil or with too
Rinse the filter cartridge in clean little oil can cause serious engine
water and then squeeze gently to damage.
remove most of the water. Let it air
dry until it is completely dry. Note: Dispose of used engine oil carefully,
responsibly and in accordance with local or
Clean the cover and inside of the air national regulations
filter box with a clean lint-free cloth.
Apply a uniform layer of oil to the
outside of the cartridge filter with a
brush (you can use clean engine oil
PAGE 11
INSTRUCTION MANUAL
TECHNICAL SPECIFICATION
Consistent with our policy of continuous
improvement, SANLI reserves the right
to change the design and configuration
of any of its products without notice or
b obligation.
Therefore, please treat the text
e and images in this manual as being for
illustrative purposes only. They may
in no case serve as a basis for any
a c d legal claim.
PAGE 12
WARRANTY CONDITIONS
LAWN MOWER LCS400
Please note that your warranty is affected by terms and conditions. Read on to fully
understand what is covered by the warranty and what is not covered. Those items not
covered by the warranty are the responsibility of the owner and any repairs will be at
the owners expense.
The warranty does not affect your statutory rights or remedies as outlined in applicable
consumer legislation.
Sanli company provides an express warranty for this product for a period of 2 years
from your original purchase date with the exception of commercial-use which is for
a period of 90 days. The warranty is not transferable and is only applicable to the
original purchaser that can provide original proof of purchase.
Defective parts will be replaced or repaired by an Authorised Sanli Dealer without
charge for labour or materials, subject to conditions. Repairs or adjustments required
by failure to follow the manufacturers instructions are chargeable to the owner.
PAGE 13
INSTRUCTION MANUAL
Notes.
PAGE 14
Notes.
PAGE 15
WWW.SANLI.COM.AU