Professional Documents
Culture Documents
(/)
(/download_file/view/987/368/)
Click to Enlarge
Fabricate the additional drawbar and tilt components as per the details below -
The pivot support tube hole for mounting the pivot shaft, requires a relative amount of
accuracy to ensure a snug fit for the shaft as well as being square to the upper surface of
the tube.
1 de 4 05/06/2016 19:21
Trailer Sauce :: Tongue & Sub Chassis Components http://www.trailersauce.com/trailer-plans/tow-dolly/tongue-sub-chassi...
(/trailer-plans/tow-dolly/tow-dolly-trailer-plans-purchase/)
Use a 50mm bi-metal holesaw suitable for cutting steel if available - if not, use a 51mm
holesaw (2"). Pre drill a small centre hole on both sides of the pivot support and clamp the
RHS to the drill press bed.
Use a slow cutting speed and plenty of cutting fluid to keep the holesaw cool and
lubricated.
Fabricate the tilt shroud from a section of 75 x 75 x 4.0 SHS by cutting off one face
(remove the face with the internal seam weld) and welding flatbar as shown above.
(/TRAILER-PLANS/TOW- (/TRAILER-PLANS/TOW-DOLLY/SUB-
DOLLY/TONGUE/) CHASSIS-COMPONENTS-CONTD/)
BACK TO TOP
2 de 4 05/06/2016 19:21
Trailer Sauce :: Tongue & Sub Chassis Components http://www.trailersauce.com/trailer-plans/tow-dolly/tongue-sub-chassi...
Maintenance
(/maintenance/) /+Trailersauce1/posts)
Contact Us
(/contact-us/) (https://www.facebook.com
/Trailersauce)
3 de 4 05/06/2016 19:21
Trailer Sauce :: Tongue & Sub Chassis Components http://www.trailersauce.com/trailer-plans/tow-dolly/tongue-sub-chassi...
(https://www.youtube.com/channel
/UCJ7Yl2AAXbkcZWwgPlOxWHw)
4 de 4 05/06/2016 19:21