Professional Documents
Culture Documents
Diamagnetic
4. The tube will conduct during both halves of the cycle 33. the collector current at its maximum value
11. Lenz law 40. protect drive circuits from high voltage transient surges
17. How amplification can be thought of as a decision making process 46. Buffer
25. Global Positioning System 54. split into halves and connected in parallel
57. ROM
58. Hole 88. when to shift a bit of data from input of the flip-flop to the output
60. 2 90. Typical power rating of a carbon-composition resistor ranged from 0.125 W to 2W
71. 200 V
24. The flux density, which exist in the iron core when the magnetic field intensity is 53. As an RF detector
reduced to zero.
54. Lithium
25. increased voltage supply
55. Logic probe
26. 2
56. 4
27. Flip-flop
57. Its internal capacitance varies with the applied voltage
28. 1 watt or less
58. Coulombs first law
29. No current flows from emitter to collector
59. C
30. macro-instruction
60. Counter
31. a lower input resistance
61. 4 cells
32. Eddy
62. A regulator in which the conduction of a control element is varied in direct
33. Light waves proportion to the voltage or load current.
32. discrete 62. the presence of capacitance both external and internal
34. Multiplexing 64. A force set up when current flows through a conductor
43. 10 Gb/cm 73. it has a very high voltage gain and low noise level
46. Compensate aging battery of the meter 76. inverse parallel connected SCRs with common gate
93. multiplexer 21. current varies directly as the voltage and inversely as the resistance
29. Register
2. 166 Joules 32. output is present for less than 180 degrees of the input signal cycle
10. two coils wound on a common core 40. stores electrical energy
12. an area of low charge density around the P-N junction 42. Low resistance
15. 14.5 MHz 45. its value cannot be stepped up or down by transformer
56. the size and thickness of the crystal material 85. Asynchronous
58. no current flow from the emitter to collector 87. Yes or one
60. great force capability handling heavy loads 89. in biasing circuits DC negative feedback is provided while amplifiers employ AC
negative feedback
61. the effective resistance is increased
90. electrons are drawn to the grid and not reach the plate
62. a capacitor
91. Flux
63. the rms voltage is always greater than the average voltage
92. Increased field voltage
64. gate, anode 1 and anode 2
93. Coulomb
65. An ohmmeter test across the base collector of a transistor should show low
resistance for both polarity 94. 1.7 V and 20 mA
67. P type collector, N type base, P type emitter 96. Nickel-cadmium cell
5. 14 35. forward-biased
7. M 37. increases
8. In the most distant orbit from the nucleus 38. A half-wave rectified voltage
9. When a valence electron breaks away from the atom 39. voltage but not for current
10. When an atom gains an extra valence electron 40. more positive than the anode
11. Silicon 41. The changes in the output voltage and input voltage
12. Conduction band 42. The changes in load current and output voltage
16. eight valence electrons, four of its own and four shared 46. one-half
28. The dc voltage applied to control the operation of the devices 58. Impedance matching
82. Both Vinton Cerf and Bob Khan 10. Suppressor grid
24. An ohmmeter test across the base-collector of a transistor should show high 52. Computerized Tomography (CT) or Computerized Axial Tomography (CAT)
resistance in the opposite polarity
53. Phototransistor
25. Dynamotor
54. Micro- electronics
26. one
55. The NiCd cell is primary type
27. The resistance of the coil and inductor
56. Magnetic field
28. Moving either the magnet or the coil
57. Precession
29. Printed circuit board (PCB)
58. Control transformer
30. Dual or double speed synchro system
59. To obtain instruction
31. NOR Gate
60. Battery charge
32. Armature reaction
61. Extrinsic
33. That frequency at which the grounded emitter current gain has decreased to 0.7
of that obtainable at 1 kHz in a transistor 62. Astable multi-vibrators
39. Voltage regulation 68. Differentials synchros can handle more signal and also perform addition and
subtraction functions
40. Forward bias
69. Field intensity
41. Volt ampere
70. Isolation
42. UNIVAC
71. Spectroscopy
43. Reluctance
72. Only a, c and d
44. IBM-701
73. Only b and c
45. Atom
74. Interpoles and compensating windings
46. larger
75. Position servo
47. Both column and row decoders
76. Glass cockpit
48. Resonant frequency
77. Feedback
78. Use to block signal 5. Vibrating-reed devices or tuned circuits
95. The phenomenon where RF current flows in a thinner layer of the conductor, 22. 600 rpm
close to the surface, as frequency increases.
23. 250 hours
96. Magnetic susceptibility
24. 100 hours
97. Ferrite
25. Tuned circuits
98. Magnetic induction
26. Two
99. Class C
27. Four
100. Bonding wires
28. By varying the input voltage to the field coils
29. Amplidynes
PART 7
30. 10,000
1. Sorting
31. Compound-wound dc generators
2. FORTRAN
32. P-type material
3. 30 or 60 MHz
33. The gate terminal
4. Tachometer
34. The dual-gate MOSFET
35. To prevent damage from static electricity 65. Mechanical or electromechanical
43. The SCR is primarily used for switching power on or off 73. Information
45. The forward bias must be reduced below the minimum conduction level 75. Negative feedback
47. During both alternations 77. The potential difference depends on the diameter of the conductor that cuts the
magnetic field
48. Forward bias
78. 1 to 2 V
49. Very low
79. An ideal voltage source can be in parallel with an open circuit
50. Variable capacitance
80. 10 kW
51. The depletion region decreases
81. The power in watts, voltage and current
52. Capacitance decreases
82. 0.707
53. The minority carriers
83. 7.95
54. Zener effect and avalanche effect
84. Floating state
55. Zener effect
85. Thermal energy
56. Electrons
86. Electrostatic field
57. Wien bridge oscillator
87. Period
58. Secondary emission
88. Leakage flux
59. Cathode biasing
89. Integrated circuit
60. All of the choices
90. Number of valence electrons
61. Analog
91. Electrostatic field
62. Speed and efficiency
92. Energy
63. Special-purpose
93. Electrochemical action
64. Continuous electrical or physical conditions
94. 135 V 22. Revolution
53. the north pole of the compass will point in the directions of the magnetic lines of 82. microswitch
force
83. hysteresis loss
54. magnetic amplifiers
84. soft iron
55. rigidity
85. 1000
56. reverse synchros
86. blocking factor
57. all of the choices
87. motor reversal
58. rating
88. armature reaction
59. all of the choices
89. troubleshooting
60. according to their functions
90. CALIBRATE
61. all of the choices
91. all of the choices
62. closed-loop control system
92. ground potential
63. roughness
93. all of the choices
64. correction voltage
94. mutual inductance
65. both A and C
95. in the early 1950s
66. A = 1
96. no more than 10
67. sponge lead
97. 10 to 50 degrees Celsius
68. sweep generator
98. over 100 million
69. underdamped system
99. generations
70. all of the choices
100. firmware
71. friction clutch damping
72. gassing
PART 9
73. Colpitts oscillator
1. 2
74. 50 V
2. 2
75. class AB
3. 7
76. class C
4. 69.3 ms
77. zinc container
5. 5.386 W
78. wirewound resistor
6. 2LA (1+k)
79. fresh water
7. 0.277 ms
80. dielectric field
8. Excitor
9. Shunted 39. 1%
37. Very narrow 67. By using a current transformer and a capacitor shunt
74. 6 kHz at -6 dB
76. Hunting
79. rem
86. Electrolytic
87. Electrolytic
90. Quiescence
91. 1.280-1.300
92. A, B, C and D
96. two
97. A, B, C, D and E