Professional Documents
Culture Documents
Part 1: Based on the STM method, you are required to calculate the theoretical failure load
of the deep beam. In order to find a good STM, you need to determine the distribution of
elastic stresses using a commercial package such as ANSYS, ABAQUS, etc. You also need
to clearly show the distribution of elastic stresses over the cross-section under the point load
by using your elastic model. However, it is not necessary to calculate any particular value of
stress or failure load in ANSYS or ABAQUS.
Part 2: The theoretical failure load calculated from Part 1 using STM method must be
compared with the measured experimental value. Discuss the reasons which cause the
difference between experimental and theoretical results.
It is noted that the deep beams will be tested on Thursday 17 August, 2017 based on the
following schedule:
Note: You are to complete this project in teams of two (2) and you are free to choose your
team member. Please note it is your responsibility to keep a photocopy of your
submission. Your submission must cover both Parts 1 and 2. You need to use the marking
scheme sheet given on Moodle as the first page after the standard Monash cover sheet.
You must place your report by 5:00 pm Monday 28 August, 2017 in the assignment box
(The assignment box is located in Building 60 next to the Department Office).
P
870 870 R8
125
250
R8@200
each face
500 500
200
1740
Dimensions in mm