Professional Documents
Culture Documents
PQ05RF1 Series
1A Output Low Power-Loss Voltage Regulators
3.60.2
Built-in ON/OFF control terminal (PQ05RF1/PQ05RF11
7.40.2
series)
Built-in output voltage minute adjustment terminal (Critical 3.20.1
4.8MAX
15.60.5
PQ05RF1
29.1MAX
rate of ripple rejection is improved.)
(PQ05RF1V series)
41.4 +0.3
0
Lead forming type (PQ05RF1A/1B series) is also available.
13.5MIN
40.6 +0.2
0.1 (1.5)
+ +
4 Output
ON/OFF ASO : Area of Safety
Overheat Overheat
control circuit protection protection
Operation circuit
circuit
3 3
Notice In the absence of confirmation by device specification sheets,SHARP takes no responsibility for any defects that may occur in equipment using any SHARP
devices shown in catalogs,data books,etc.Contact SHARP in order to obtain the latest device specification sheets before using any SHARP device.
Internet Internet address for Electronic Components Group http://sharp-world.com/ecg/
Low Power-Loss Voltage Regulators PQ05RF1 Series
15
60
10
40
5
20
PD1
0 0
25 0 50 100 150 0 0.5 1.0 1.5 2.0
Ambient temperature Ta (C) Output current IO (A)
Note) Oblique line portion : Overheat protection may operate in this area.
Fig.5 Output Voltage Minute Adjustment Fig.6 Output Voltage Minute Adjustment
Characteristics (PQ05RF1V) Characteristics (PQ09RF1V)
6.0
R1=390 R1=1k
R1=1k R1=390
9.9
Output voltage VO (V)
Output voltage VO (V)
5.5
R1=3.9k
R1=
5.0 3.9k
9.0
4.5
8.1
10 2
10 3
10 4
103 104 105
R2 () R2 ()
Low Power-Loss Voltage Regulators PQ05RF1 Series
Fig.7 Output Voltage Minute Adjustment Fig.8 Output Voltage Deviation vs. Junction
Characteristics (PQ12RF1V) Temperature (PQ05RF1/PQ05RF11/PQ05RF1V)
150
13.2 R1=390 VIN=7V
R1=1k
50
12.0
0
50
10.8 100
103 104 105 25 0 25 50 75 100 125
R2 () Junction temperature Tj (C)
Fig.9 Output Voltage Deviation vs. Junction Fig.10 Output Voltage Deviation vs. Junction
Temperature (PQ09RF1/PQ09RF11/PQ09RF1V) Temperature (PQ12RF1/PQ12RF11/PQ12RF1V)
200 250
VIN=15V VIN=18V
Output voltage deviation VO (mV)
0 0
50
50
100
100 150
150 200
25 0 25 50 75 100 125 25 0 25 50 75 100 125
Junction temperature Tj (C) Junction temperature Tj (C)
Fig.11 Output Voltage vs. Input Voltage Fig.12 Output Voltage vs. Input Voltage
(PQ05RF1/PQ05RF11/PQ05RF1V) (PQ09RF1/PQ09RF11/PQ09RF1V)
8 10
7
Output voltage VO (V)
6
Output voltage VO (V)
RL=
5 RL=
RL=18
4 5
RL=10 RL=5 RL=9
3
1
0 0
0 2 4 6 8 10 0 5 10 15
Input voltage VIN (V) Input voltage VIN (V)
Low Power-Loss Voltage Regulators PQ05RF1 Series
Fig.13 Output Voltage vs. Input Voltage Fig.14 Circuit Operating Current vs. Input Voltage
(PQ12RF1/PQ12RF11/PQ12RF1V) (PQ05RF1/PQ05RF11/PQ05RF1V)
20 40
30
RL=
10 20
RL=24 RL=5
RL=12
5 10 RL=10
RL=
0 0
0 5 10 15 20 25 0 5 10
Input voltage VIN (V) Input voltage VIN (V)
Fig.15 Circuit Operating Current vs. Input Voltage Fig.16 Circuit Operating Current vs. Input Voltage
(PQ09RF1/PQ09RF11/PQ09RF1V) (PQ12RF1/PQ12RF11/PQ12RF1V)
40 40
Circuit operating current IBIAS (mA)
20 20
RL=9 RL=12
RL=12
RL=18
10 10 RL=24
RL= RL=
0 0
0 5 10 15 0 5 10 15 20 25
Input voltage VIN (V) Input voltage VIN (V)
Fig.17 Dropout Voltage vs. Junction Fig.18 Quiescent Current vs. Junction
Temperature Temperature
0.5 10
VIN=35V
IO=0
Quiescent current Iq (mA)
0.4 8
Dropout voltage Vi-O (V)
IO=1A
0.3 6
0.75A
0.2 4
0.5A
0.1 0.25A 2
0 0
25 0 25 50 75 100 125 25 0 25 50 75 100 125
Junction temperature Tj (C) Junction temperature Tj (C)
Low Power-Loss Voltage Regulators PQ05RF1 Series
Fig.19 Ripple Rejection vs. Input Ripple Frequency Fig.20 Ripple Rejection vs. Input Ripple Frequency
(PQ05RF1/PQ05RF11/PQ09RF1/PQ09RF11/PQ12RF1/PQ12RF11) (PQ05RF1V/PQ09RF1V/PQ12RF1V)
80 80
70 70
Ripple rejection RR (dB)
50 50
40 40
30 30
IO=0.5A,ei(rms)=0.5V,
20 IO=0.5A,ei(rms)=0.5V, 20 Cref=3.3F
VIN=7V(PQ05RF11/PQ05RF11) VIN= 7V(PQ05RF1V)
10 VIN=15V(PQ09RF11/PQ09RF11) 10 VIN= 15V(PQ09RF1V)
VIN=18V(PQ12RF11/PQ12RF11)
0 0 VIN= 18V(PQ12RF1V)
0.1 1 10 100 0.1 1 10 100
Input ripple frequency f (kHz) Input ripple frequency f (kHz)
Fig.21 Ripple Rejection vs. Output Current
80
70
Ripple rejection RR (dB)
PQ05RF1V/PQ09RF1V/PQ12RF1V
PQ05RF1/PQ05RF11
60 PQ09RF1/PQ09RF11
PQ12RF1/PQ12RF11
50
f=120Hz,ei(rms)=0.5V,
Cref=3.3F(V Type)
40 VIN= 7V(PQ05RF1 Series)
VIN= 15V(PQ09RF1 Series)
VIN= 18V(PQ12RF1 Series)
30
0 0.5 1.0
Output current IO (A)
Typical Application
PQ05RF1/PQ05RF11 Series PQ05RF1V Series
VIN
VO VIN VO
1 2 1 2 +
+ + + R2' R2 +
Load
Load
Specific IC 4
Specific IC CO CO
R1' Cref R1
3 3
4
ON/OFF
signal High or Open : Output ON
Low : Output OFF
R2'R2
VO=Vref 1+ R1'+R1
CMOS or TTL R2'+R2 R1'R1
10.2MAX 4.50.2
2.80.2
3.60.2
7.40.2
16.40.7
PQ05RF1 3.20.1
)
.5
(2.0)
(24.6)
0
.0
(5
(1.5)
41.4 +0.3
0
4.4MIN
40.6 +0.2
0.1
(0.5)
(3.2)
3(2.54) 50.5
8.20.7
( ) : Typical value
Radius of lead forming portion : R=0.5 to 1.5mm
DC input(VIN)
DC output(VO)
GND
Specific IC ON/OFF control
terminal(VC)
Note) The value absolute maximum ratings and electrical characteristics is same as ones of PQ05RF1/11 series.
(i) The devices in this publication are designed for use in general electronic equipment designs such as:
- - - Personal computers
- -- Office automation equipment
- -- Telecommunication equipment [terminal]
- - - Test and measurement equipment
- - - Industrial control
- -- Audio visual equipment
- -- Consumer electronics
(ii) Measures such as fail-safe function and redundant design should be taken to ensure reliability and safety when
SHARP devices are used for or in connection with equipment that requires higher reliability such as:
- -- Transportation control and safety equipment (i.e., aircraft, trains, automobiles, etc.)
- - - Traffic signals
- - - Gas leakage sensor breakers
- - - Alarm equipment
- -- Various safety devices, etc.
(iii)SHARP devices shall not be used for or in connection with equipment that requires an extremely high level of
reliability and safety such as:
- - - Space applications
- -- Telecommunication equipment [trunk lines]
- -- Nuclear power control equipment
- -- Medical and other life support equipment (e.g., scuba).
Contact a SHARP representative in advance when intending to use SHARP devices for any "specific" applications
other than those recommended by SHARP or when it is unclear which category mentioned above controls the
intended use.
If the SHARP devices listed in this publication fall within the scope of strategic products described in the Foreign
Exchange and Foreign Trade Control Law of Japan, it is necessary to obtain approval to export such SHARP devices.
This publication is the proprietary product of SHARP and is copyrighted, with all rights reserved. Under the copyright
laws, no part of this publication may be reproduced or transmitted in any form or by any means, electronic or
mechanical, for any purpose, in whole or in part, without the express written permission of SHARP. Express written
permission is also required before any use of this publication may be made by a third party.
Contact and consult with a SHARP representative if there are any questions about the contents of this publication.