Professional Documents
Culture Documents
com
Package Content 1.1 Physical Description
Power Switch This switch is used to power on the WIFER.
WIFER Micro USB Port This port is used to connected to be the provided power adapter.
EUR USA
NHA24030 00
QSG Power Adapter USB Cable Ethernet Port
System Requirement
Supported operating system:
p Windows XP p Windows Vista p Windows 7
Windows 8 iOS Android Default Settings:
SSID: SE_TCSEGW_XXXXXX
p p p
Mac IP:223.22.33.223
NHA24030 00
Slide and remove the rear Access Point Mode Beginner step-by-step quick start for first connection.
Scan cover of the WIFER. WIFER Access Point Mode gives wire Step 1: establish wireless network connection.
access to an Ethernet LAN using Wireless 1. Keep LAN port open and power on WIFER.
connection
WLAN 2. Activate your WIFI interface inside your laptop, tablet, ...
Ethernet 3. Check if your (laptop, tablet, ) device is auto IP setting.
Power
4. Search SSID SE_TCSEGW_XXXXXX : Refer to 3 Connect to Network.
5. Enter the Wireless Password : Refer to 1.1 Physical Description.
Insert and press the battery 6. Launch the connection with SSID SE_TCSEGW_XXXXXX
Solid (Green) The battery is full or the power supply until it snaps into place.
is normal. and wait until WIFI connection achieved.
Power Solid (Orange) The battery is being charged. 2
Step 2: access to WIFER WEB site.
Solid (Red) The battery power is low, you need to 1. Depending on the Browser type, the WIFER WEB site can be
charge it. automatically openned without more action.
Flashing (Red) The battery is abnormal.
Ethernet Cable
2. If the WIFER WEB site is not openning you can force the
Ethernet Flashing The Ethernet port is transferring data.
Off No device is linked to the LAN port.
Install the rear cover, push Charge Battery browser to open it by entering a simple URL like "www.a.com".
the power switch on.
On The wireless function is enabled. 3. If the WIFER WEB site is not again openning you Disable
WLAN Flashing There is data being transferred through proxy in your web browser.
wireless.
Off The wireless function is disabled due to 4: For the fist time you open the WIFER WEB site enter:
internal error.
Scan is working and at least one device is User Name: admin
On NOTE: 1. We dont suggest using the device without battery.
Scan detected. Password: admin.
Flashing Scan is working and no device is detected. 2. Low battery may influence the use of the WIFER.
Off Scan is not started. Please charge it in time. USB Cable
3 Connect to Network
Example of Wireless Network Connection. Make sure your device is wireless enabled.
sunrise123 SE_TCSEGW_123456
SE_TCSEGW_987654
SE_TCSEGW_123456 SE_TCSEGW_123456 SE_TCSEGW_123456
SE_TCSEGW_987654
SE_TCSEGW_123456
SE_TCSEGW_987654
NOTE: 1. The default SSID of the network is SE_TCSEGW_XXXXXX. (The xxxxxx is the last six characters of the WIFERs MAC address.)
2. The pre-encryption function is enabled by default and the default Network key/Security key is the Wireless Password on the label.
You can find SSID and the Wireless Password by refer to 1.1 Physical Decsription.
NHA24030 00
10 - 2014