Professional Documents
Culture Documents
KEY 1 High Impact (Tier 1) 2 Medium Impact (Tier 2) 3 Low Impact (Tier 3)
4.2.2 Plans and/or specifications provide all information with which compliance
[PR1]1 can be determined for the building envelope and delineate and
document where exceptions to the standard are claimed.
4.2.2, 6.4.2 Plans, specifications, and/or calculations provide all information with
[PR2]1 which compliance can be determined for the mechanical systems and
equipment and delineate and document where exceptions to the
standard are claimed.
1
Use Comments/Assumptions to document code requirements that pass due to exceptions, and specify the exception. Also use Comments/Assumptions to document
multiple values observed for a given code requirement, such as multiple equipment efficiencies.
11/19/2010 Page 1
4.2.2, 7.4.1 Plans, specifications, and/or calculations provide all information with
[PR3]1 which compliance can be determined for the service water heating
systems and equipment and delineate and document where exceptions
to the standard are claimed.
Additional Comments/Assumptions:
11/19/2010 Page 2
General building information only required if different than above
Heated
0
5.8.1.2 Slab edge insulation installed per manufacturers
[FO4]2 instructions.
Additional Comments/Assumptions:
11/19/2010 Page 3
General building information only required if different than above
90.1-2007 Verified
Framing / Rough-In Inspection Complies? Comments/Assumptions
Section # Value
5.4.3.2 Fenestration meets maximum air leakage
[FR1]3 requirements.
cfm/ f2
5.4.3.2 Doors meet maximum air leakage requirements.
[FR2]3
cfm/ f2
5.4.3.2 Fenestration and doors labeled for air leakage.
[FR3]3
11/19/2010 Page 4
Non-Swinging
Additional Comments/Assumptions:
11/19/2010 Page 5
General building information only required if different than above
Additional Comments/Assumptions:
11/19/2010 Page 6
General building information only required if different than above
90.1-2007 Verified
Mechanical Rough-In Inspection Complies? Comments/Assumptions
Section # Value
6.4.1.4, HVAC equipment efficiency verified. Non-NAECA Efficiency:
6.4.1.5 HVAC equipment labeled as meeting 90.1.
[ME1]2
11/19/2010 Page 7
6.5.1, Air economizers provided where required, meet the
6.5.1.1.1, requirements for design capacity, control signal, and
6.5.1.1.2, high-limit shut-off and integrated economizer
6.5.1.1.3, control.
6.5.1.3
[ME12]1
6.5.3.1.2 HVAC fan motors not larger than the first available
[ME21]2 motor size greater than the bhp.
bhp:
11/19/2010 Page 8
6.5.4.1 HVAC pumping systems >10 hp designed for variable
[ME25]3C fluid flow.
Additional Comments/Assumptions:
11/19/2010 Page 9
General building information only required if different than above
9.4.1.2 Independent lighting control installed per approved lighting plans and all
[EL2]2 manual control readily accessible and visible to occupants.
9.4.1.4 Verify separate lighting control devices for specific uses installed per
[EL4]1 approved lighting plans.
9.4.2 Ballasted one and three lamp fixtures with >30 W/lamp have two lamp
[EL5]3 tandem wired ballasts when >2 fixtures in same space on same control.
9.6.2 Additional interior lighting power allowed for special functions per the
[EL8]1 approved lighting plans and is automatically controlled and separated
from general lighting.
Additional Comments/Assumptions:
11/19/2010 Page 10
General building information only required if different than above
90.1-2007 Verified
Insulation Inspection Complies? Comments/Assumptions
Section # Value
5.4.3.1 All sources of air leakage in the building thermal
[IN1]1 envelope are sealed, caulked, gasketed or weather
stripped to minimize air leakage.
SRI:
11/19/2010 Page 11
5.8.1.5 Insulation is installed in substantial contact with the
[IN12]2 inside surface separating conditioned space from
unconditional space.
Additional Comments/Assumptions:
11/19/2010 Page 12
General building information only required if different than above
6.4.3.1.2, Temperature controls have the following features: dead band controls,
6.4.3.2, setpoint overlap restrictions, off-hour controls, automatic shutdown,
6.4.3.3, setback controls.
6.4.3.3.1,
6.4.3.3.2
[FI3]2
6.4.3.3.3 Systems with air capacity >10,000 cfm include optimum start controls.
[FI4]2
6.4.3.5 Heat pump controls prevent supplemental electric resistance heat from
[FI5]3 coming on when not needed.
6.7.2.3 An air and/or hydronic system balancing report is provided for HVAC
[F9]1C systems serving zones >5,000 f2 of conditioned area.
6.7.2.4 Verify HVAC control systems have been tested to ensure proper operation,
[FI0]1C calibration and adjustment of controls.
7.4.4.4 Controls are installed that limit the operation of a recirculation pump
[FI12]3 installed to maintain temperature of a storage tank.
7.4.5.1 Pool heaters are equipped with on/off switch and no continuous burning
[FI13]3C pilot light.
7.4.5.2 Pool covers are provided for heated pools and pools heated to >90F have
[FI14]2C a cover >R-12.
11/19/2010 Page 13
8.7.1 Furnished as-built drawings for electric power systems.
[FI16]3
8.7.2 Furnished O&M manual for electrical power systems and equipment.
[FI17]3
9.1.3 Installed lamps and fixtures are consistent with what is shown on the
[FI8]1 approved lighting plans.
Additional Comments/Assumptions:
Evaluator Assessment
Please provide a general description of what was discovered during the onsite evaluation, and a professional estimate of what you feel the compliance
rating should be, regardless of the individual metrics scored above. Include your assessment of the most impactful energy requirements for this
particular building.
11/19/2010 Page 14
ARRA Compliance Calculations
Points Points
Error Check Tier Points Possible Received
ERROR! 1 3 0 0
ERROR! 1 3 0 0
11/19/2010 Page 15
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
11/19/2010 Page 16
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
11/19/2010 Page 17
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 2 2 0 0
ERROR! 1 3 0 0
ERROR! 2 2 0 0
11/19/2010 Page 18
11/19/2010 Page 19
ERROR! 2 2 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
ERROR! 3 1 0 0
11/19/2010 Page 20
ERROR! 2 2 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
ERROR! 3 1 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 3 1 0 0
11/19/2010 Page 21
ERROR! 1 3 0 0
ERROR! 2 2 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 2 2 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
11/19/2010 Page 22
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
ERROR! 3 1 0 0
ERROR! 2 2 0 0
ERROR! 1 3 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
11/19/2010 Page 23
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 1 3 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 2 2 0 0
11/19/2010 Page 24
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
11/19/2010 Page 25
11/19/2010 Page 26
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 3 1 0 0
11/19/2010 Page 27
ERROR! 1 3 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 2 2 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
ERROR! 1 3 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 2 2 0 0
11/19/2010 Page 28
11/19/2010 Page 29
ERROR! 3 1 0 0
ERROR! 3 1 0 0
ERROR! 1 3 0 0
11/19/2010 Page 30
11/19/2010 Page 31