You are on page 1of 3

9.

3 Imhoff Tank

Imhoff or Emscher tanks are typically used for domestic or mixed wastewater flows above 3
m3/d, where the effluent will be exposed above ground for further treatment, and therefore
the effluent should not stink, as it could be the case with a septic tank. The Imhoff tank
separates the fresh influent firmly from the bottom sludge.

The tank consists of a settling compartment above the digestion chamber. Funnel-like baffle
walls prevent up-flowing foul sludge particles from getting mixed with the effluent and from
causing turbulence. The effluent remains fresh and odourless because the suspended and
dissolved solids do not have an opportunity to get in contact with the active sludge to become
sour and foul. Retention times of much longer than 2 h during peak hours in the flow portion
of the tank would jeopardise this effect.

When sludge ferments at the bottom, the sludge particles get attached to foul gas bubbles and
start to float upwards, as in the septic tank. The up-flowing sludge particles assemble outside
the conical walls and form an accumulating scum layer. This scum grows continuously
downwards, until the slots through which settling particles should fall into the lower
compartment are closed. The treatment effect is then reduced to that of a too small septic
tank. It is for this reason that the sludge and scum must be removed regularly, at the intervals
the sludge storage had been designed for.

Only part of the sludge should be removed so as to always keep some active sludge present.
Sludge should be removed right from the bottom to be sure that only fully digested substrate
is discharged. If sludge is removed by hydraulic pressure (gravity), the pipes should be of 150
mm diameter. A hydraulic head loss of 30 cm to 40 cm must be taken into account. If pipes of
only 100 mm are used, the head loss is likely to be more than 50 cm. When sludge is
removed it should be immediately treated further in drying beds or compost pits for pathogen
control.

The inlet and outlet pipe is made as in a septic tank. Pipe ventilation must be provided, as
biogas is also produced in the Imhoff tank. Additional baffles to reduce velocity at the inlet
and to retain suspended matter at the outlet are advantageous. The upper part of the funnel-
shaped baffles is vertical for 30 cm above and 30 cm below the water surface. The shape of
an Imhoff tank may be cylindrical, however the funnel remains rectangular in order to leave
some space outside the funnel for removal of scum. The funnel structure may consist of ready
made parts from ferro-cement.

Starting Phase and Maintenance

As with the septic tank, a special starting phase is not required. Desludging is necessary at
regular intervals not forgetting to leave some younger bottom sludge behind in the tank. The
sludge can be removed by pumping or hydraulic pressure pipes right from the bottom. The
liquid may remain inside. Scum should be removed before the sludge is removed failing
which the scum must be lifted from further down. Scum needs to be removed before it grows
to the extent that it closes the slots between upper and lower compartments. Should this
happen, gas bubbles appearing in rows on the water surface above the slots indicating that
scum must be removed.

Calculation of Dimensions

The upper compartment, inside the funnel walls, should be designed for 2 h HRT at peak flow
and the hydraulic load should be less than 1.5 m3/h per 1 m2 surface area. The sludge
compartment below the slots should be calculated to retain 2.5 litre sludge per kg BOD
reduced per day of storage for short desludging intervals. For longer intervals use data of
spread sheet (Tab. 24.). Treatment efficiency lies in the range of 25 to 50% COD reduction.
For domestic wastewater, the upper compartment should have a volume of approximately 50
l per user and the sludge compartment below the slots, should have a volume of
approximately 120 litre per user. This rule of thumb may be valid for a desludging interval of
one year. For more detailed calculation or in case of non-domestic wastewater use the
formula of the computer spread sheet.

9.3 Imhoff Tank

Imhoff atau Emscher tank biasanya digunakan untuk arus air limbah rumah tangga atau
campuran di atas 3 m3 / d, dimana limbah akan terkena di atas tanah untuk perawatan lebih
lanjut, dan oleh karena itu limbah seharusnya tidak bau, seperti itu bisa terjadi dengan septic
tank. The Imhoff tank memisahkan influen segar tegas dari lumpur bawah.

tangki terdiri dari kompartemen menetap di atas ruang pencernaan. dinding penyekat corong
seperti mencegah up-mengalir partikel lumpur busuk dari mendapatkan dicampur dengan
limbah dan dari menyebabkan turbulensi. limbah tetap segar dan tidak berbau karena padatan
tersuspensi dan terlarut tidak memiliki kesempatan untuk mendapatkan kontak dengan
lumpur aktif menjadi asam dan busuk. kali retensi lebih lama dari 2 jam pada jam sibuk di
bagian aliran tangki akan membahayakan efek ini.

Ketika lumpur fermentasi di bagian bawah, partikel lumpur terikat untuk busuk gelembung
gas dan mulai mengapung ke atas, seperti dalam septic tank. Partikel-partikel lumpur up
mengalir merakit luar tembok berbentuk kerucut dan membentuk lapisan sampah
terakumulasi. sampah ini tumbuh terus ke bawah, sampai slot di mana partikel menetap harus
jatuh ke dalam kompartemen yang lebih rendah ditutup. Efek pengobatan kemudian
dikurangi dengan yang dari septic tank terlalu kecil. Hal ini untuk alasan ini bahwa lumpur
dan sampah harus dibuang secara rutin, pada interval penyimpanan lumpur telah dirancang
untuk.

Hanya bagian dari lumpur harus dihapus sehingga selalu menjaga beberapa lumpur aktif
hadir. Sludge harus dihapus langsung dari bawah untuk memastikan bahwa hanya
sepenuhnya dicerna substrat dibuang. Jika lumpur dihilangkan dengan tekanan hidrolik
(gravitasi), pipa harus 150 mm diameter. Sebuah kerugian head hidrolik dari 30 cm sampai 40
cm harus diperhitungkan. Jika pipa hanya 100 mm yang digunakan, hilangnya kepala
cenderung lebih dari 50 cm. Ketika lumpur dihapus itu harus segera diobati lebih lanjut
dalam tidur pengeringan atau lubang kompos untuk pengendalian patogen.
Inlet dan outlet pipa dibuat seperti dalam septic tank. ventilasi pipa harus disediakan, seperti
biogas juga dihasilkan dalam tangki Imhoff. baffle tambahan untuk mengurangi kecepatan
pada inlet dan untuk mempertahankan tersuspensi di outlet menguntungkan. Bagian atas dari
baffle berbentuk corong vertikal untuk 30 cm di atas dan 30 cm di bawah permukaan air.
Bentuk tangki Imhoff mungkin silinder, namun corong tetap persegi panjang untuk
meninggalkan beberapa ruang luar corong untuk penghapusan sampah. Struktur saluran dapat
terdiri dari siap bagian yang terbuat dari ferro-semen.

Mulai Tahap dan Pemeliharaan

Seperti tangki septik, fase awal khusus tidak diperlukan. Penyedotan perlu secara berkala
tidak lupa untuk meninggalkan beberapa muda bawah lumpur di belakang di dalam tangki.
lumpur dapat dihilangkan dengan memompa atau pipa tekanan hidrolik yang tepat dari
bawah. cairan ini dapat tertinggal di dalam. Sampah harus dihapus sebelum lumpur dihapus
gagal yang sampah harus diangkat dari bagian bawah. Sampah perlu dihapus sebelum
tumbuh sejauh menutup slot antara kompartemen atas dan bawah. Jika hal ini terjadi,
gelembung gas muncul di baris di permukaan air di atas slot menunjukkan sampah yang
harus dibuang.

Perhitungan Dimensi

Kompartemen atas, di dalam dinding saluran, harus dirancang selama 2 jam HRT pada aliran
puncak dan beban hidrolik harus kurang dari 1,5 m3 / h per 1 m2 luas permukaan. Lumpur
kompartemen bawah slot harus dihitung untuk mempertahankan 2,5 liter lumpur per BOD kg
dikurangi per hari penyimpanan untuk interval penyedotan singkat. Untuk interval yang lebih
panjang menggunakan data dari spread sheet (Tab. 24.). efisiensi pengobatan terletak pada
kisaran 25 sampai 50% pengurangan COD. Untuk air limbah domestik, kompartemen atas
harus memiliki volume sekitar 50 l per pengguna dan kompartemen lumpur di bawah slot,
harus memiliki volume sekitar 120 liter per pengguna. aturan ini mungkin berlaku untuk
interval penyedotan dari satu tahun. Untuk perhitungan yang lebih rinci atau dalam kasus
limbah non-domestik menggunakan rumus dari komputer spread sheet.

You might also like