You are on page 1of 2

AL - 3036

First Semester M. E. (FT.) Digital Electronics


Examination
EMBEDDED SYSTEM DESIGN
Paper 1 UMEF 5
P. Pages : 3
Time : Three Hours j [ Max. Marks 80

Note : (1) All questions carry marks as indicated.


(2) Answer Three questions from Question 1
to 4 and Three questions from Question 5
to 8.
(3) Due credit will be given to neatness and
adequate dimensions.
(4) Illustrate your answer wherever necessary
with the help of neat sketches.
(5) Use pen of Blue/Black ink/refill only for
writing the answer book.

1. (a) What are major hardware components of


embedded system ? Show block diagram of
small scale embedded system and discuss 3
applications of embedded system. 6
(b) Describe interfacing of ARM 7 core processor
with S-RAM and Flash ROM and discuss
methods to improve speed of data transfer
between S-R AM and Flash ROM with
processor. 8

AL-3036 P.T.O.
2. (a) Explain memory protection unit which is 6. (a) What is worst case latency ? Explain with
provided in some of the ARM processor suitable examples. 6
cores. 7 (b) Explain in detail following scheduling
(h) Describe the AMBA architecture for ARM algorithms :
cores for interfacing on-chip peripherals and
(i) Rate monotonic.
memories. 6
(ii) Earliest deadline first. 7
3. (a) Explain with the help of example why
variables of data type unsigned integer are 7. (a) How does bottom-up approach of estimation
prefferred over that of data type char. In 'C' differ from top-down approach ? What are
programing for ARM processors. 5 their strengths and weaknesses ? 6
(b) Describe the mechanism of ARM Thumb (b) Describe a typical target system steup for
instruction set interchange procedure. 8 embedded system. What tools will you use
to perform for its testing ? 7
4. (a) Describe interrupt handling in 'CI Language
for ARM processor. 6 8. Write a 'C' program to read analog input from pin
(b) What is the need of including start-up code ADO.1 of LPC 2148 j.IC and display value in volts
for writing C program in ARM processor ? on LCD display. Assume that LCD is connected to
What are major constituents of start-up code pins Po.16 to Po.19 in 4 bit data mode and Po.20
7
and Po.21 are connected to Reg. select (Rs) and
7 enable (E) Pin of ACD controller. Use SDC in
software polling mode.
5. (a) What is RTOS ? Enlist features of p.Cos-II 13
RTOS. 7
(b) With neat diagrams explain Round Robin
.

model for task assignment and scheduling in


RTOS. Give one example. 7
AL-3036 2 AL-3036 3 330

You might also like