Professional Documents
Culture Documents
Chapter 1: Installation
FibeAir1500 SP Acceptance & Commissioning Procedure Rev1.0
Proprietary and Confidential
General
This chapter provides instructions for the installation of the FibeAir IP-10 IDU at the customer
site.
Installation Requirements
Required Tools
The following tools are required to install the IDU:
Philips screwdriver (for mounting the IDU to the rack and grounding screw)
Flathead small screwdriver (for PSU connector)
Sharp cutting knife (for wire stripping)
Crimping tool for ground cable lug crimping (optional: if alternative grounding cable is used).
A grounding wire is connected below the IDU-RFU interface using a single screw with two
washers.
Interface Descriptions
The following photo shows the different IDU ports and their functions.
Chapter 2: Commissioning
FibeAir IP 10 installation & Commissioning Procedure Page 5 of 29
Proprietary and Confidential
Select the TCP/IP and click the properties button, then the
following window will come
Go to start and click on the run then type there CMD then
click on ok. Command window will open
Then type the command
Example:-
H:\>ping 192.168.1.1
After the reset when the IDU comes please configure the MRMC
Script.
Go to Configuration > Radio > MRMC, Click on MRMC right side window
will open.
Configure the MRMC Script as per the details
Click on the Apply, Then system will take the reset.
After enabling the port of Both the IDU connect the Cross Cable (Rj45)
9. Configure E1 :-
Go to Configuration > Interface > E1 Port, Click on E1 port then right side
window will open.
There we have two option Select all and Enable One by One as per the
requirement.
Example:- Select All
Define the any name in the name and click on the ok.
Then Select the Com port of the computer and click on the Ok.
Then Select the Port Speed (115200).Data Bit (8), Priority (None)
Stop Bits (1) and Flow Control (None)
Click on the ok.
Then the following window will come.
Then following window will come there we have to press the Enter 2
times.
Then will have the option for User name /Password.
2. CLI Command :-
8. Check Vlan ID
21.Clear PM Report
IP-10:/management/mng-services/pm-service> clear-entire-pm
Warning: This command will clear all performance monitors.
Are you sure? (yes/no):yes
IP-10:/> /management/mng-services/pm-service/clear-entire-pm
Warning: This command will clear all performance monitors.
Are you sure? (yes/no):yes
24. Check and change remote End IP Address, Subnet mask, Gateway
IP-10:/> get platform/remote-idu/remote-ip-address
192.168.1.20
IP-10:/> set platform/remote-idu/remote-ip-address 192.168.1.10
30. Mute TX
IP-10:/> get radio/rfu/mute-tx
disable
IP-10:/> set radio/rfu/mute-tx
disable enable